New Researches in Biotechnology - Facultatea de Biotehnologii ...

More documents

Recommendations

Info

Proceeding of the 4 rd International Symposium“NEW RESEARCH IN BIOTECHNOLOGY” USAMV Bucharest, Romania, 2011THE EFFECT OF PREPARATES BASED ON SODIUM CARBONATEAND CITRIC ACID ON THE PARAMETER FALLING NUMBERIN HYPERDIASTAZIC FLOURSTAMBA-BEREHOIU R.*, POPESCU S.*, POPA C. N.*** U.S.A.M.V.B., Faculty of Biotehnologies, 59 Marasti Str., sector 1, Bucharest, radianatamba@yahoo.com,sazzpop@yahoo.com** FARINSAN S.A. Gradistea, Comana, Giurgiu district, cipnpopa@yahoo.comAbstract. The objective was to assess the influence of compounds of sodium carbonate and citric acidon the amylase activity of hyperdiastazic flour. Four samples of wheat, with Falling Number valuesbetween 88 sec and 153 sec, were ground on pilot mill. Flour was treated with varying amounts ofsodium carbonate/citric acid preparates and combinations. Results showed that the sodium carbonatepreparate provides a significant improvement of Falling Number values at doses above 50 g per 100kg, and citric acid increases Faling Number values of flour at doses greater than 200 g/100 kg.Combinations of the two, generally cancel this effect. Consequently, the use of sodium carbonate toimprove Falling Number parameter values is limited because it is necessary to maintain acid pH atwhich bakery processes occur.Keywords: wheat flour, sodium carbonate, citric acid, falling number1. INTRODUCTIONEnvironmental factors such as climatic conditions of the year, the area of culture,doses of nitrogen applied and fungicide treatments, influence the values of the FallingNumber parameter of wheat, protein quantity and composition. The Falling Numberparameter, known as Hagberg Falling index, reflects the amylasic activity of wheat andflour. More events were associated with low Falling Number, namely: late maturatingwheat, which leads to reduced starch content, a lower quality of gluten and excessiverainfalls that cause the starch detachment of proteins [1].Fungicide treatments and Fusarium infections have been incriminated in certainstudies for an easy decrease of the value of this parameter [2]. For some varieties of wheat,the low values of the Falling Number parameter were correlated with a number of geneticdisorders, characterized by continuation of α-amylase synthesis in the late maturation stagesof wheat grains. For most of these varieties, the phenomenon seems to be modulated by thethermal shocks (freezing), to which the wheat plant is exposed in late stages ofdevelopment [3, 4].Romanian wheat yields are generally characterized by relatively small values ofamylasic activity, often having higher Falling parameter values, higher than 350 seconds[5]. However, periodically, there are situations when the quality of crops is influenced byadverse weather conditions, especially during harvest. This leads to premature germinationof seeds and the increase of amylasic activity. A big amylasic activity of wheat is aproblem, as it leads to obtaining improper flour technological properties. Improvingsolutions are generally based on the change of dough pH, but have a limited effect, due tothe sensitivity of biochemical and rheological processes in dough to pH changes. Another92
Proceeding of the 4 rd International Symposium“NEW RESEARCH IN BIOTECHNOLOGY” USAMV Bucharest, Romania, 2011line of research, which aimed to use amylasic inhibitors, has a limited applicability, due totheir interference with the human digestive amylase.2. MATERIAL AND METHODSFour wheat samples taken from the 2010 harvest were analyzed in order todetermine the amylasic activity through the Falling Index (ISO 3093:1997).For each of the four samples we analyzed the Falling Number on the full meal(milled on the LM 120 laboratory mill taken from Perten Instruments AB) and the flourtype 550 (obtained by grinding the samples on a Chopin CD1 pilot mill).The obtained flour samples were treated with successive quantities of Rowelit(preparation based on 80% sodium carbonate, produced by Mühlenchemie), citric acid andcombinations from them, in accordance with the experimental plan in Table 1.Table 1. The quantities of Rowelit and citric acid used for treatmentsSample number ROWELIT(g/100 kg)CITRIC ACID(g/100 kg)ROWELIT + CITRIC ACID(g/100 kg)I.II.III.IV.50 100 200 50 100 200The results have been interpreted using the methods of descriptive statisticalanalysis and t test (Student) for pairs of samples.25+253. RESULTS AND DISCUSSIONThe results obtained by Falling Number parameter determination, of the wheatsamples and the flour produced from them, are presented in Table 2.50+50100+10025+100Table 2. Falling Number values and the estimates of their variability forthe wheat and flour samplesSample numberWheat(s)Wheat flour(s)I. 132 158II. 153 171III. 113 125IV. 88 120Mean 121.5 143.5St. dev. 27.671 24.906C.V. (%) 17.356 18.791The studied wheat samples had low values of the Falling Number parameter, wellbelow the permissible limits of acceptability for their exploitation in specific technologicalprocesses of the milling and bakery industry (at least 180 s). However, we can see that the100+2593
Page 1 and 2:
UNIVERSITY OF AGRONOMICAL SCIENCES
Page 3 and 4:
Proceeding of the 4 rd Internationa
Page 5 and 6:
Page 7 and 8:
Page 9 and 10:
Page 11 and 12:
Page 13 and 14:
Page 15 and 16:
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
Page 27 and 28:
Page 29 and 30:
Page 31 and 32:
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
Page 39 and 40:
Page 41 and 42: Proceeding of the 4 rd Internationa
Page 91: Proceeding of the 4 rd Internationa
Page 143 and 144:
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
Page 163 and 164:
Day 7Day 10Proceeding of the 4 rd I
Page 165 and 166:
Page 167 and 168:
Page 169 and 170:
Page 171 and 172:
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
Page 183 and 184:
Page 185 and 186:
Page 187 and 188:
Page 189 and 190:
Page 191 and 192:
Page 193 and 194:
Page 195 and 196:
Page 197 and 198:
Page 199 and 200:
Page 201 and 202:
Page 203 and 204:
Page 205 and 206:
Page 207 and 208:
Page 209 and 210:
Page 211 and 212:
Page 213 and 214:
Page 215 and 216:
Page 217 and 218:
Page 219 and 220:
Page 221 and 222:
Page 223 and 224:
Page 225 and 226:
Page 227 and 228:
Page 229 and 230:
Page 231 and 232:
Page 233 and 234:
Page 235 and 236:
show all

New Researches in Biotechnology - Facultatea de Biotehnologii ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?