Controllers - AGCO Parts
Controllers - AGCO Parts Controllers - AGCO Parts
2004-2005 Air Conditioning Applications: 2004-2005 Air Conditioning for TerraGators 8103,8104,3104, and 6103. The AG516854 Relay is used for the HAVC on the '04 TerraGators and is located in the side panel between the PDM blocks and master module. Note: AG137459 includes the Schrader valve, o-ring cap, and port adapter. FORK ASSEMBLY Fork Asm (Bushing Style) The brass bushing style front fork was used on all 3-wheel TerraGators until 1996. Make sure you inspect this area of your machine regularly. Note: () = quantities required. | Part | Description | | AG512583 | Front Wheel Bearings | | AG300640 | Radial Bushing (2) | | AG200069 | Thrust Washer (1) | RoGator/TerraGator | Part | Description | | AG719144 | Air Conditioner Compressor | | AG519278 | Receiver Dryer | | AG420834 | Condenser Coil | | AG727102 | Evaporator Coil | | AG718801 | Expansion Valve | | AG262906 | High Pressure Switch | | AG727093 | Blower Motor 2004 and up | | AG607237 | Low Pressure Switch | | AG718798 | Thermostat Heater, A/C | | AG718805 | Pressure Fan and Blower Motor ASM | | AG718807 | 12 Volt Relay | | AG061196 | Resistor for fan blower motor 2004 and up | | AG718787 | Electronic Water Valve | | AG727097 | Heater Core | | AG137459 | Port Charge Asm | | AG328801 | Fitting/AMFM Drain (Duckbill 4 Per) | | AG516864 | Relay 75 AMP | 2003-2008 864/1064/874/1074 Air Conditioning Applications: 2003-2004 864/1064 RoGator. 2005-2008 874/1074 RoGator. Note: AG716988 water shutoff valve and AG713362 heater control are used on s/n 864010104 and below and 1064010704 and below .AG061184 water shutoff valve is used on s/n 864010204 and up and 106401804 and up. For more information on the overhead controls for 864010204 and up and 1064010804 and up please refer to the 2004- 2006 8/1064 and 874/1074 Overhead Cab Controls section referred to earlier in this section. | Part | Description | | AG120976 | A/C Compressor | | AG519278 | Receiver Dryer | | AG607237 | Low Pressure Switch | | AG423598 | Condenser Coil | | AG262906 | High Pressure Switch | | AG713360 | Evaporator Coil | | AG713359 | Low Pressure Switch | | AG714552 | Expansion Valve | | AG058655 | Thermostat for Evaporator | | AG712815 | Pressurizer Motor | | AG712813 | Blower Motor | | AG713362 | Control Heater/ LOW Switch | | AG716988 | Water Shut off Valve | | AG061184 | Water Shut off Valve | Fork Asm (Bearing Style) This style fork assembly was used on the Generation 1 TerraGator from 1997 and up. 1603, 1803, 1903, & 2505. Note: () = Quantity required * AG510149 Bearings are for the 1903 and 2505 machines. | Part | Description | | AG512583 | Front Wheel Bearings | | AG510149 | Front Wheel Bearings (2) * | | AG519695 | Spindle Seal (1) | | AG519693 | Bearing Cone (2) | | 700710370| Bearing Cup (2) | | AG234245 | Spindle Gasket (1) | Fork Asm Newer Style Cab This front fork assembly is used on the new style cab 3-wheel TerraGators. 6103, 8103, 9103, & 9105. Note: () = Quantity required * AG510149 wheel bearings are for the 9103 and 9105 machines. | Part | Description | | AG512583 | Front Wheel Bearings | | AG510149 | Front Wheel Bearings (2) * | | AG520701 | Spindle Seal (1) | | AG520699 | Bearing Cone (2) | | AG520700 | Bearing Cup (2) | | AG237639 | Spindle Gasket (1) | 266
TRANSMISSIONS Torq-Boost 18 Speed This Transmission uses either Dextron II or Dextron III. approximately 8.5 gallons. Used on 1903 and 9103 machines. Notes: There is a core charge added to new transmissions and Reman Advantage transmissions. The amount credited depends on the condition of the core. | Part | Description | | AG060620 | Transmission Torq-Boost | | AG799985 | Reman Advantage Torq-Boost Transmission | | AG712106 | Trans. Filter Kit (Torque Boost) (1) | | AG713896 | Solenoid and Harness | | AG712217 | Seal O-Ring | Torq-Boost This transmission uses either Dextron II or Dextron III. approximately 8- 1/2 gallons. Used on 1803 machines. AG519126 was the transmission with the electric speedometer drive that preceded the AG060621. This was used starting with the electronic speedometer units released May 1994. Notes: There is a core charge added to new transmissions and Reman Advantage transmissions. The amount credited depends on the condition of the core. | Part | Description | | AG060621 | Torq Boost Transmission - Electronic Speedo Drive | | AG799984 | Reman Advantage Torq Boost Transmission | | AG712106 | Trans. Filter Kit (Torque Boost) (1) | | AG713896 | Solenoid and Harness | | AG715190 | Seal O-Ring | Fuller 10 Speed This transmission used approximately 1-1/2 gallons of Synthetic Lube. Used on 1603 and 1664 with Cat 3208 engine. Notes: There is a core charge added to new transmissions and Reman Advantage transmissions. The amount credited depends on the condition of the core. | Part | Description | | AG799647 | Reman Advantage Fuller 10 Speed Transmission | | AG705421 | Air Filter Manual Trans. (1) | | AG711023 | Transmission Lubricant | | AG707782 | Range Valve | Allison Auto Transmission This Transmission was used on 1603 and 1664 machines with Cat 3208 engines. Allison part number is E001469. Notes: There is a core charge added to new transmissions and Reman Advantage transmissions. The amount credited depends on the condition of the core. | Part | Description | | AG711135 | Auto Trans. Filter (Internal) | | AG725826 | Auto Trans Filter (1) Aus Trans Spin on | 18 Speed This transmission was used on 1844 with Cat 3208, 1803 (SN 1836415) and up, 2505 with L10 engine. This transmission requires approximately 3-1/2 gallons of transmission lube. Notes: There is a core charge added to new transmission and Reman Advantage transmissions. The amount credited depends on the condition of the core. | Part | Description | | AG516797 | Transmission Mechanical Speedo Drive | | AG606507 | Breather Fuller 10 and 18 - Speed | | AG711023 | Transmission Lubricant | Auto 643 Transmission This transmission was used on 1803 and 1844 with Cummings 6CTA engines and 1703. The AG717483 Pan filter kit is a screen mesh type filter used in approximately 1996 and up. This filter can be washed and replaced. AG711135 is a paper filter type and gasket kit and was used previously to the AG717483. There is no definite serial number break on their usages. Notes: There is a core charge added to new transmissions and Reman Advantage transmissions. The amount credited depends on the condition of the core. | Part | Description | | AG331219 | Pan Filter | | AG700104 | Filter Gasket, Auto Trans (Internal) (1) | | AG711135 | Auto Trans. Filter (Internal) | TerraShift 11 Speed This transmission is used on the 3104. Notes: There is a core charge added to new transmission and Reman Advantage transmissions. The amount credited depends on the condition of the core. | Part | Description | | AG520516 | TerraShift Transmission | | AG799800 | Reman Advantage TerraShift Transmission | | AG610114 | Filter, Transmission | | AG610342 | Switch, Oil Filter Bypass | RoGator/TerraGator 267
- Page 217 and 218: Raven 2" Stainless Steel On/Off But
- Page 219 and 220: Technical Pages Please Note: For a
- Page 221 and 222: Ace Model BAC-75-HYD-200 Series Mot
- Page 223 and 224: Ace Model FMC-CW-150-Mag AGCO Part
- Page 225 and 226: All 9306C Series Technical Pages Pl
- Page 227 and 228: Technical Pages Please Note: For a
- Page 229 and 230: Hypro Model 6500 Model 6500C: AGCO
- Page 231 and 232: Hypro Model 7560 Model 7560C: AGCO
- Page 233 and 234: Hypro 12-Volt Electric-Driven Rolle
- Page 235 and 236: Hypro Model 9401 AGCO No. AGCO No.
- Page 237 and 238: Hypro Model 9910-D50 AGCO Part No.
- Page 239 and 240: Hypro Model 9910-D60 AGCO Part No.
- Page 241 and 242: Hypro Model 9910-D100 Hypro Model 9
- Page 243 and 244: Banjo Wet Seal 3" Cast Iron Self-Pr
- Page 245 and 246: Hydraulic Drive Scot Transfer Pump
- Page 247 and 248: Scot Self-Priming Pedestal Pump Mod
- Page 249 and 250: A GUIDE TO CLEANING YOUR SPRAYERS S
- Page 251 and 252: Spray tips don’t last forever! To
- Page 253 and 254: Technical Pages Please Note: For a
- Page 255 and 256: Technical Pages Please Note: For a
- Page 257 and 258: Clean Sprayers Help Prevent Crop In
- Page 259 and 260: Self-Propelled Table of Contents Ta
- Page 261 and 262: Cab Controls 1998-2003 Air Spread S
- Page 263 and 264: Cab Controls 2004 Liquid System App
- Page 265 and 266: Cab Controls 2006/2007 Air Spreader
- Page 267: Miscellaneous Cab Components The fo
- Page 271 and 272: TerraShift Transmission with Tier l
- Page 273 and 274: 3104 Power Steering Control This co
- Page 275 and 276: Amber Rotating Beacon This amber be
- Page 277 and 278: Gauge Protector Protector has two 1
- Page 279 and 280: Pump/Electric Clutch - Tapered Shaf
- Page 281 and 282: Scot Pump Replacement Parts for AG5
- Page 283 and 284: Air Box 97-98 The air box is locate
- Page 285 and 286: Nozzle/Hose Shank Connectors Adapt
- Page 287 and 288: Fan Assembly The fan motor is bolte
- Page 289 and 290: Belt Over Chain Sealer (L20-20) New
- Page 291 and 292: G4 Spinner Blades 4 Blades required
- Page 293 and 294: Boom Pivot Arms The fastest way to
- Page 295 and 296: Conveyer Drive The AirMax 1000/2000
- Page 297 and 298: Injector Points Fruitland RCF 500 P
- Page 299 and 300: 1995-1996 Gauges Note: If replacing
- Page 301 and 302: 1995-96 844 & 854 Switches Notes: N
- Page 303 and 304: 2003-2008 864/1064/874/1074 Cab Con
- Page 305 and 306: 2000-2005 1254/1264 Mirrors Applica
- Page 307 and 308: 1996-1998 854 Air Conditioning Appl
- Page 309 and 310: ENGINE COMPONENTS Starters • 1996
- Page 311 and 312: Axle Wear Pads 1254/1264 Applicatio
- Page 313 and 314: Suspension 664, 93-94 Applications:
- Page 315 and 316: Suspension 854 99-02 Applications:
- Page 317 and 318: Suspension 864/1064/874/1074 Applic
2004-2005 Air Conditioning<br />
Applications: 2004-2005 Air Conditioning for TerraGators<br />
8103,8104,3104, and 6103. The AG516854 Relay is used for the<br />
HAVC on the '04 TerraGators and is located in the side panel between<br />
the PDM blocks and master module.<br />
Note: AG137459 includes the Schrader valve, o-ring cap, and port adapter.<br />
FORK ASSEMBLY<br />
Fork Asm (Bushing Style)<br />
The brass bushing style front<br />
fork was used on all 3-wheel<br />
TerraGators until 1996. Make<br />
sure you inspect this area of<br />
your machine regularly.<br />
Note: () = quantities<br />
required.<br />
| Part | Description |<br />
| AG512583 | Front Wheel Bearings |<br />
| AG300640 | Radial Bushing (2) |<br />
| AG200069 | Thrust Washer (1) |<br />
RoGator/TerraGator<br />
| Part | Description |<br />
| AG719144 | Air Conditioner Compressor |<br />
| AG519278 | Receiver Dryer |<br />
| AG420834 | Condenser Coil |<br />
| AG727102 | Evaporator Coil |<br />
| AG718801 | Expansion Valve |<br />
| AG262906 | High Pressure Switch |<br />
| AG727093 | Blower Motor 2004 and up |<br />
| AG607237 | Low Pressure Switch |<br />
| AG718798 | Thermostat Heater, A/C |<br />
| AG718805 | Pressure Fan and Blower Motor ASM |<br />
| AG718807 | 12 Volt Relay |<br />
| AG061196 | Resistor for fan blower motor 2004 and up |<br />
| AG718787 | Electronic Water Valve |<br />
| AG727097 | Heater Core |<br />
| AG137459 | Port Charge Asm |<br />
| AG328801 | Fitting/AMFM Drain (Duckbill 4 Per) |<br />
| AG516864 | Relay 75 AMP |<br />
2003-2008 864/1064/874/1074 Air Conditioning<br />
Applications: 2003-2004 864/1064 RoGator. 2005-2008 874/1074<br />
RoGator.<br />
Note: AG716988 water shutoff valve and AG713362 heater control<br />
are used on s/n 864010104 and below and 1064010704 and below<br />
.AG061184 water shutoff valve is used on s/n 864010204 and up and<br />
106401804 and up. For more information on the overhead controls for<br />
864010204 and up and 1064010804 and up please refer to the 2004-<br />
2006 8/1064 and 874/1074 Overhead Cab Controls section referred to<br />
earlier in this section.<br />
| Part | Description |<br />
| AG120976 | A/C Compressor |<br />
| AG519278 | Receiver Dryer |<br />
| AG607237 | Low Pressure Switch |<br />
| AG423598 | Condenser Coil |<br />
| AG262906 | High Pressure Switch |<br />
| AG713360 | Evaporator Coil |<br />
| AG713359 | Low Pressure Switch |<br />
| AG714552 | Expansion Valve |<br />
| AG058655 | Thermostat for Evaporator |<br />
| AG712815 | Pressurizer Motor |<br />
| AG712813 | Blower Motor |<br />
| AG713362 | Control Heater/ LOW Switch |<br />
| AG716988 | Water Shut off Valve |<br />
| AG061184 | Water Shut off Valve |<br />
Fork Asm (Bearing Style)<br />
This style fork assembly was<br />
used on the Generation 1<br />
TerraGator from 1997 and up.<br />
1603, 1803, 1903, & 2505.<br />
Note: () = Quantity required<br />
* AG510149 Bearings are for<br />
the 1903 and 2505<br />
machines.<br />
| Part | Description |<br />
| AG512583 | Front Wheel Bearings |<br />
| AG510149 | Front Wheel Bearings (2) * |<br />
| AG519695 | Spindle Seal (1) |<br />
| AG519693 | Bearing Cone (2) |<br />
| 700710370| Bearing Cup (2) |<br />
| AG234245 | Spindle Gasket (1) |<br />
Fork Asm Newer Style Cab<br />
This front fork assembly is used on<br />
the new style cab 3-wheel<br />
TerraGators. 6103, 8103, 9103, &<br />
9105.<br />
Note: () = Quantity required *<br />
AG510149 wheel bearings are for<br />
the 9103 and 9105 machines.<br />
| Part | Description |<br />
| AG512583 | Front Wheel Bearings |<br />
| AG510149 | Front Wheel Bearings (2) * |<br />
| AG520701 | Spindle Seal (1) |<br />
| AG520699 | Bearing Cone (2) |<br />
| AG520700 | Bearing Cup (2) |<br />
| AG237639 | Spindle Gasket (1) |<br />
266