I&O Manual - ECCS Control System - Categories On Thermal ...

More documents

Recommendations

Info

Section 4: Setting the Modbus Addresses 4.1 COMMUNICATION SETUP FOR BOILERS Each Modbus device in each boiler must be addressed to properly communicate with the ECCS system. The Temperature Controller must be addressed through the configuration level and the flame safeguard will be addressed according to the following instructions. Refer to Appendix A, system wiring, or individual component manuals. 4.2 SETTING THE ADDRESS OF THE HONEYWELL MODBUS MODULE Addressing for the HW Modbus Module correlates to the Temp Controllers Modbus addressing on the same unit. There are 2 dials on the bottom of the module that need to be set and a jumper that needs to be removed. Refer to Figure 4.1: Honeywell S7810M Modbus Module Mounting and 4.2: S7810M Address Switches and Baud Rate Jumper. 4.3 SETTING THE MODBUS ADDRESS OF THE FIREYE MICRO M Addressing for the Fireye correlates to the Temperature Controllers Modbus addressing on the same unit. Refer to MicroM manual for instructions. Fireye MicroM Fireye Temperature Parameter Controller Baud Rate @ (C113) 19,200 Unit Address Boiler 1 0160 11 Boiler 2 0260 12 Boiler 3 0360 13 Boiler 4 0460 14 Boiler 5 0560 15 Boiler 6 0660 16 Honeywell Temperature Controller (C113) S7810M Modbus Module Baud Rate @ 19,200 remove jumper 10"s Dial 1"s Dial Boiler 1 0160 1 1 Boiler 2 0260 1 2 Boiler 3 0360 1 3 Boiler 4 0460 1 4 Boiler 5 0560 1 5 Boiler 6 0660 1 6 16
Figure 4.1: Honeywell S7810M Modbus TM Module Mounting 17
Page 1 and 2: INSTALLATION, OPERATING AND SERVICE
Page 3 and 4: Parameter Limits and Factory Defaul
Page 5 and 6: Section 1: Component Description CO
Page 7 and 8: 2.3.3. When a boiler becomes availa
Page 9 and 10: Section 3: Installation 3.1 UNPACKI
Page 11 and 12: 3.3.ELECTRICAL NOTICE 3.3.1. Genera
Page 13 and 14: 13 Figure 3.3: System Wiring
Page 15: 15 Figure 3.5: Boiler Wiring Diagra
Page 19 and 20: Section 5: Touch Screen Programming
Page 21 and 22: SETTING THE TRIGGERS AND THE START
Page 23 and 24: Outdoor Reset Switch. Press and dra
Page 25 and 26: Figure 5.10: Warm Weather Shutdown
Page 27 and 28: Figure 5.14 Time/Date Screen In ord
Page 30 and 31: Section 7: Appendix A - Temperature
Page 32 and 33: NOTES
Page 34: THERMAL SOLUTIONS PRODUCTS, LLC. (

I&O Manual - ECCS Control System - Categories On Thermal ...

Create successful ePaper yourself

Delete template?

Save as template?