installation, operating and service instructions eva series boiler
installation, operating and service instructions eva series boiler installation, operating and service instructions eva series boiler
IMPORTANT INFORMATION - READ CAREFULLY NOTE: Post these instructions and maintain in ledgible condition. NOTE: The equipment shall be installed in accordance with those installation regulations required in the area where the installation is to be made. These regulations shall be carefully followed in all cases. Authorities having jurisdiction shall be consulted before installations are made. All wiring on boilers installed in the USA shall be in accordance with the National Electrical Code and/or local regulations. All wiring on boilers installed in Canada shall be in accordance with the Canadian Electrical Code and/or local regulations. The following terms are used throughout this manual to bring attention to the presence of hazards of various risk levels, or to important information concerning product life. DANGER Indicates an imminently hazardous situation which, if not avoided, will result in death, serious injury or substantial property damage. CAUTION Indicates a potentially hazardous situation which, if not avoided, may result in moderate or minor injury or property damage. WARNING Indicates a potentially hazardous situation which, if not avoided, could result in death, serious injury or substantial property damage. NOTICE Indicates special instructions on installation, operation, or maintenance which are important but not related to personal injury hazards. DANGER DO NOT store or use gasoline or other flammable vapors or liquids in the vicinity of this or any other appliance. If you smell gas vapors, DO NOT try to operate any appliance - DO NOT touch any electrical switch or use any phone in the building. Immediately, call the gas supplier from a remotely located phone. Follow the gas supplier's instructions or if the supplier is unavailable, contact the fire department.
WARNING the Follow safely. operate to service and maintenance regular requires boiler This manual. this in contained instructions property cause can maintenance or service alteration, adjustment, installation, Improper before manual entire the understand and Read life. of loss or injury personal damage, be must service and Installation service. or operation, start-up installation, attempting agency. service or installer skilled experienced, an by only performed vented. properly be must boiler This provisions are there so installed be must and operation safe for air fresh needs boiler This air. ventilation and combustion adequate for the before cleaned and inspected be must systems intake air and venting the of interior The heating the throughout periodically inspected be should and season heating the of start are systems intake air and venting unobstructed and Clean obstructions. any for season and safely vent to life of loss or injury cause could that fumes noxious allow to necessary efficiency. boiler's the maintaining toward contribute will the on installed is valve relief pressure supplied factory a unless complete not is Installation details. for manual this of Section Installation See - boiler not and down shut to boiler the cause may which devices safety with supplied is boiler This system heating the possibility, a is pipes frozen to due damage If - service without re-start should alarms and safeguards appropriate or weather; cold in unattended left be not should inoperative. is boiler the if damage prevent system to heating the on installed be fittings pipe any unscrew not Do pressure. high under water hot very contains boiler This the assuring positively without boiler this of components any disconnect to attempt nor when equipment and clothing protective wear Always pressure. no has and cool is water the on rely not Do injuries. scald prevent to boiler this servicing or up starting installing, boiler. the of pressure and temperature the determine to gauges temperature and pressure Do operating. is boiler the when hot very become which components contains boiler This cool. are they unless components any touch not alumina, contain fuel the and combustion of products construction, of materials Boiler or toxic other and/or aldehydes oxides, nitrogen monoxide, carbon metals, heavy silica, the to known are which and injury serious or death cause can which substances harmful use Always harm. reproductive other and defects birth cancer, cause to California of state the nearby working or servicing when equipment and respirators clothing, safety proper appliance. death. or injury personal cause can order proper the in instructions all follow to Failure manuals manufacturers component in contained those all including instructions, all Read or maintaining operating, up, starting installing, before boiler the with provided are which servicing. flammable other and gasoline materials, from combustible free and clear area boiler Keep liquids. or vapors times. all at place in be must guards and enclosures plates, cover All installed when fitter gas or plumber licensed a by installed be must product This Massachusetts. of Commonwealths the within NOTICE manual. this of back the on printed is which of copy a warranty, limited a has boiler This installed correctly are controls all that see to contractor installing the of responsibility the is It complete. is installation the when properly operating are and
- Page 1: INSTALLATION, OPERATING AND SERVICE
- Page 5 and 6: Supplemental Instructions: Figure 1
- Page 7 and 8: I. Pre-Installation WARNING Careful
- Page 9 and 10: III. Installation A. VENTING 1. Gen
- Page 11 and 12: Figure 2: Sidewall Pressurized Vent
- Page 13 and 14: e. Use appropriately designed thimb
- Page 15 and 16: Figure 7: Vertical Air Intake Pipin
- Page 17 and 18: BOILER MODEL TABLE 1 - EVA BOILER F
- Page 19 and 20: D. GAS PIPING WARNING Failure to pr
- Page 21 and 22: TABLE 6 - EQUIVALENT OF STANDARD PI
- Page 23 and 24: Figure 9a: Standard UL/FM/CSD-1 Wir
- Page 25 and 26: Figure 9c: Standard UL/FM/CSD-1 Wir
- Page 27 and 28: CAUTION Installing multiple vent te
- Page 29 and 30: 28 Figure 12: Modular System Vertic
- Page 31 and 32: 30 Figure 14: Modular System: Typ P
- Page 33 and 34: 32 Figure 16: Modular System: Typ R
- Page 35 and 36: 34 Figure 18: Modular System: Typ P
- Page 37 and 38: IV. System Start-up CAUTION Failure
- Page 39 and 40: EE. Verify that all safety and oper
- Page 41 and 42: DANGER This boiler requires periodi
- Page 43 and 44: 42 VI. Service DANGER water hot ver
- Page 45 and 46: Troubleshooting Guide 44
- Page 47 and 48: NORMAL SEQUENCE OF OPERATION Boiler
- Page 49 and 50: Air Filter: A. Perform a visual ins
- Page 51 and 52: Figure 19: Combustion Chamber Assem
IMPORTANT INFORMATION - READ CAREFULLY<br />
NOTE: Post these <strong>instructions</strong> <strong>and</strong> maintain in ledgible condition.<br />
NOTE: The equipment shall be installed in accordance with those <strong>installation</strong> regulations required in the area where the<br />
<strong>installation</strong> is to be made. These regulations shall be carefully followed in all cases. Authorities having jurisdiction<br />
shall be consulted before <strong>installation</strong>s are made.<br />
All wiring on <strong>boiler</strong>s installed in the USA shall be in accordance with the National Electrical Code <strong>and</strong>/or local regulations.<br />
All wiring on <strong>boiler</strong>s installed in Canada shall be in accordance with the Canadian Electrical Code <strong>and</strong>/or local regulations.<br />
The following terms are used throughout this manual to bring attention to the presence of hazards of various risk levels, or to<br />
important information concerning product life.<br />
DANGER<br />
Indicates an imminently hazardous situation<br />
which, if not avoided, will result in death,<br />
serious injury or substantial property<br />
damage.<br />
CAUTION<br />
Indicates a potentially hazardous situation<br />
which, if not avoided, may result in<br />
moderate or minor injury or property<br />
damage.<br />
WARNING<br />
Indicates a potentially hazardous situation<br />
which, if not avoided, could result in death,<br />
serious injury or substantial property<br />
damage.<br />
NOTICE<br />
Indicates special <strong>instructions</strong> on<br />
<strong>installation</strong>, operation, or maintenance<br />
which are important but not related to<br />
personal injury hazards.<br />
DANGER<br />
DO NOT store or use gasoline or other flammable vapors or liquids in the vicinity of this or any<br />
other appliance.<br />
If you smell gas vapors, DO NOT try to operate any appliance - DO NOT touch any electrical<br />
switch or use any phone in the building. Immediately, call the gas supplier from a remotely<br />
located phone. Follow the gas supplier's <strong>instructions</strong> or if the supplier is unavailable, contact<br />
the fire department.