lf1030 hydraulic patient lift lf1040 electric patient lift user manual

More documents

Recommendations

Info

8 TROUBLESHOOTING WARNING: If you experience a problem with your lift and are unable to service it yourself, contact your Lumex dealer. LF1030 HYDRAULIC PATIENT LIFT SYMPTOM POSSIBLE CAUSE ACTION Patient lift does not go up or down Air in the cylinder Bleed the cylinder by turning the release knob and push down on the mast. Pump up the lift again and turn the release knob again. Loss of hydraulic fluid (leaking Replace any leaking cylinder cylinder) Patient lift does not go Air in the cylinder See above Directions down Note: If the hydraulic cylinder begins leaking fluid, do not operate. Contact your Lumex dealer for a new cylinder. LF1040 ELECTRIC PATIENT LIFT SYMPTOM POSSIBLE CAUSE ACTION Control box is not responding and relay is not clicking Actuator does not run, but relay is clicking Actuator goes up or down, but not both Battery discharged Battery charger defective Battery defective Hand control defective Actuator plug not properly seated Actuator defective Control box defective Hand control defective Control box defective Charge battery Replace battery charger Replace battery Replace hand control Push actuator plug firmly into control box Replace actuator Replace control box Replace hand control Replace control box 9 SPECIFICATIONS * Note: All dimensions are given in inches unless otherwise specified. LF1030 HYDRAULIC PATIENT LIFT / LF1040 ELECTRIC PATIENT LIFT Base width Open: 39.4" Closed: 25.6" Base height Clearance 5-1/2" Base length 45.30" Lifting height range Note: As measured from point where spreader bar attaches to boom. Minimum: 27.4" Maximum: 77.7" Range: 50.3" Mast height 55.1" Weight capacity 400 lb (181 kg) Caster size 4.00" diameter, both locking and non-locking Product Weight 90 lb Shipping Weight 103.2 lb * Specifications are subject to change without notice. LF1030-INS-LAB-RevB10 20
10 LIMITED WARRANTY GF Health Products Inc. warrants this product to be free from manufacturing defects in material and workmanship for its period of warranty that is in accordance with industry standards. This warranty is extended only to the original purchaser/consumer or dealer/non-consumer of this new product and to no other purchaser or transferee. GF Health Products, Inc. warrants the Lumex ® LF1030 Hydraulic Patient Lift and its components to be free from defects in workmanship and materials as listed below: Frame / Parts: 1 Year Hydraulic Pump: 1 Year GF Health Products, Inc. warrants the Lumex ® LF1040 Electric Patient Lift and its components to be free from defects in workmanship and materials as listed below: Frame / Parts: 1 Year Electronics: 1 Year Actuator: 1 Year The Warranty period for the consumer commences on the first date a product is delivered to consumer by seller/dealer. If the product is rented or leased, the warranty period commences on the invoice date from GF Health Products, Inc. A copy of the invoice showing date of purchase must be provided when submitting warranty claims. When proof of purchase date is not provided, warranty coverage shall commence upon GF Health Products, Inc.’s invoice date to the dealer/purchaser. If within the warranty period, the product or component part is proven to GF Health Products, Inc.’s satisfaction to be defective, GF Health Products, Inc. shall provide, at its option, one of the following: (1) repair or replacement of any defective or nonconforming part or product or (2) a credit and/ or refund of the original selling price. GF HEALTH PRODUCTS, INC.’S SOLE OBLIGATION AND YOUR EXCLUSIVE REMEDY UNDER THIS WARRANTY SHALL BE LIMITED TO SUCH REPAIR, REPLACEMENT, CREDIT AND/OR REFUND. This warranty does not include any labor charges incurred in replacement part(s) installation or any associated freight or shipping charges to the manufacturer. For warranty service, please contact the authorized distributor from whom you acquired your GF Health Products, Inc. product. Upon receiving notice of an alleged defect in a product, GF Health Products, Inc. will issue a return authorization. The defective product or part(s) must then be returned, at the purchaser’s cost, for warranty inspection using the serial number as identification (or, if the product is not serialized, lot number and date code) within thirty (30) days of return authorization issue date. In the event you do not receive satisfactory warranty service, please contact GF Health Products, Inc. at the address below. DO NOT return products to our factory without prior authorization. LIMITATIONS AND EXCLUSIONS: The foregoing warranty excludes consumables, such as filters and tubing, as these require routine maintenance. The foregoing warranty shall not apply to serial numbered products if the serial number has been removed or defaced. Products subjected to negligence, abuse, misuse, improper operation, improper maintenance, improper cleaning, improper storage, or damages beyond GF Health Products, Inc.’s control are not covered by this warranty, and that evaluation shall be solely determined by GF Health Products, Inc. This warranty shall not apply to problems arising from normal wear and tear or failure to follow instructions. The warranty shall also not apply to products modified without GF Health Products, Inc.’s express written consent; nor shall it apply if parts not manufactured by GF Health Products, Inc., or if parts not complying with original equipment specifications are added to GF Health Products, Inc. products, or if the product or part is serviced by an entity not authorized by GF Health Products, Inc. LF1030-INS-LAB-RevB10 21
Page 1 and 2: LF1030 HYDRAULIC PATIENT LIFT LF104
Page 3 and 4: 1 INTRODUCTION Congratulations on y
Page 5 and 6: WARNING: Unauthorized modification
Page 7 and 8: 4 HANDLING PROCEDURES SHIPPING AND
Page 9 and 10: ASSEMBLY 1. Remove the locking pin
Page 11 and 12: Note: Steps 10-13 apply to LF1040 E
Page 13 and 14: 6 OPERATING INSTRUCTIONS LIFTING TH
Page 15 and 16: Removing the sling Gently pull the
Page 17 and 18: CLEANING Regular cleaning is recomm
Page 19: MAINTENANCE SCHEDULE Note: Only qua
Page 23 and 24: 11 INDEX A Assembly instructions 8

lf1030 hydraulic patient lift lf1040 electric patient lift user manual

Create successful ePaper yourself

Delete template?

Save as template?