technical report on the nechalacho deposit, thor lake project ...

More documents

Recommendations

Info

Table 18-9 Mine Ventilation Quantity at 2,000 TPD Avalon Rare Metals Inc. – Thor Lake Project Units CFM Total CFM Usage CFM LHD- Development 6 m 3 3 18,000 54,000 0.6 32,400 LHD- Production 6 m 3 3 18,000 54,000 0.6 32,400 Jumbo 2 boom 3 7,000 21,000 0.5 10,500 Bolting Jumbo 2 7,000 14,000 0.6 8,400 Haul Trucks 30 to 40 t 5 25,000 125,000 0.5 62,500 Long Hole Drill 1 7,000 7,000 0.2 1,400 Scissor Lift 3 7,000 21,000 0.5 10,500 Grader 1 7,000 7,000 0.5 3,500 Utility Truck 3 7,000 21,000 0.5 10,500 ANFO Loader 2 7,000 14,000 0.5 7,000 Man Carrier 2 5,000 10,000 0.5 5,000 Mechanic's Vehicle 1 5,000 5,000 0.5 2,500 Electrician’s Vehicle 1 5,000 5,000 0.5 2,500 Service Truck 1 5,000 5,000 0.5 2,500 Crusher/Conveyor Service 1 5,000 5,000 0.5 2,500 Light Vehicles 6 4,000 24,000 0.5 12,000 Tractor/Back Hoe 1 5,000 5,000 0.5 2,500 Bobcat 1 5,000 5,000 0.5 2,500 Tool Handler 1 7,000 7,000 0.5 3,500 Portable Compressors 3 3,000 9,000 0.5 4,500 Air Drills/Stopers Total 418,000 219,100 Losses 0.2 43,820 Requirement 262,920 Rounded To 300,000 The increase in ventilation flow would lead to an increase in the propane required for mine air heating to approximately 2 million litres per year. Technical Report 43-101 – March 13, 2011 Page 18-25 Prepared by Avalon Rare Metals Inc.
Mine Fan Horse Power Using the same formulas as noted above the head loss for 300,000 cfm air flow is estimated to be 6.2” WG and the air horse power is estimated to be 300 hp. As part of the mine expansion it will be necessary to install a larger motor on the main fan. Scott Wilson RPA recommends that further planning and analysis be completed to determine the optimum fan and motor combination for the initial ventilation and for the increased air flow at the expanded rate. DEWATERING The mine is not expected to be a “wet” mine and ground water inflows are expected to be low with a maximum estimated 50 gpm of groundwater inflow into the mine. The estimate of groundwater inflow has been based upon the observations of the numerous core drill programs and observations from the test mine previously developed at the Thor lake site. The estimated water inflow is: • Groundwater 50 gpm • Drilling – 2 gpm/ boom – 10 gpm • Diamond drilling 10 gpm • Mine dust suppression – carried on rock • Crusher dust control – 7 gpm (Melis) Excess water from backfill has not been considered as backfill plans call for the use of paste fill and the plan would be to use a fill which used all of the contained water for hydration of the binder. The total estimated water inflow is approximately 80 gpm. All water will be diverted to the base of the decline either along the decline or by boreholes specifically installed for mine drainage. At the base of the decline there will be two sumps each with a length of 50 m to provide time for settling. Clear overflow water will be pumped to a small sump adjacent to the main dewatering pumps using low head pumps. From the main dewatering sump the water will be pumped to surface to join the mill tailings stream. The two sumps will be used in an alternate fashion with one in operation and the other being drained and cleaned of slimes. Technical Report 43-101 – March 13, 2011 Page 18-26 Prepared by Avalon Rare Metals Inc.
Page 1 and 2:
TECHNICAL REPORT ON THE NECHALACHO
Page 3 and 4:
TABLE OF CONTENTS 1. SUMMARY ......
Page 5 and 6:
QUALITY ASSURANCE / QUALITY CONTROL
Page 7 and 8:
Warehouse..........................
Page 9 and 10:
LIST OF TABLES Table 1-1 Summary of
Page 11 and 12:
Table 18-9 Mine Ventilation Quantit
Page 13 and 14:
Table 18-54 Table 18-55 Pine Point
Page 15 and 16:
LIST OF APPENDICES APPENDIX A Block
Page 17 and 18:
Table 1-1 Summary of Mineral Resour
Page 19 and 20:
Royalties. The net revenue generate
Page 21 and 22:
• The products will be shipped in
Page 23 and 24:
• Income taxes and NWT mining roy
Page 25 and 26:
2. INTRODUCTION This report
Page 27 and 28:
Figure 2-2 Project Sites, Thor Lake
Page 29 and 30:
Table 2-1 Rare Earth Element Data A
Page 31 and 32:
LIST OF ABBREVIATIONS Units of meas
Page 33 and 34:
4. PROPERTY DESCRIPTION AND LOCATIO
Page 35 and 36:
The mining leases have a 21-year li
Page 37 and 38:
5. ACCESSIBILITY, CLIMATE, LOCAL RE
Page 39 and 40:
Fort Resolution is located on the s
Page 41 and 42:
producing a tantalum concentrate, b
Page 43 and 44:
Figure 7-2 Detailed Deposit Geology
Page 45 and 46:
The nepheline-sodalite syenite host
Page 47 and 48:
LATE TECTONIC FAULTS Faults are pre
Page 49 and 50:
8. DEPOSIT TYPES The mineral deposi
Page 51 and 52:
The Ore (Nechalacho) Nepheline Soda
Page 53 and 54:
from section to section - this may
Page 55 and 56:
Table 9-1 Average Percent of Ore Mi
Page 57 and 58:
The Nechalacho deposit alteration s
Page 59 and 60:
11. DRILLING Since 1977, diamond dr
Page 61 and 62:
Foraco drill rig was added in Febru
Page 63 and 64:
CORE LOGGING AND CORE RECOVERY The
Page 65 and 66:
A high R 2 (and all regressions had
Page 67 and 68:
12. SAMPLING METHOD AND APPROACH A
Page 69 and 70:
such as Illimausaq in Greenland, a
Page 71 and 72:
13. SAMPLE PREPARATION, ANALYSES AN
Page 73 and 74:
limited set of elements; however, s
Page 75 and 76:
CONCLUSIONS Avalon’s conclusions
Page 77 and 78:
Tb and Dy) were routinely monitored
Page 79 and 80:
As part of the QA/QC program, Avalo
Page 81 and 82:
Table 14-4: Comparison of Niobium,
Page 83 and 84:
shows more deviation, with ALS MS81
Page 85 and 86:
16. MINERAL PROCESSING AND METALLUR
Page 87 and 88:
In a typical test, for example CCr-
Page 89 and 90: 17. MINERAL RESOURCE AND MINERAL RE
Page 91 and 92: 9. TREO equivalent is estimated by
Page 93 and 94: Table 17-4 Sample Information Avalo
Page 95 and 96: Figure 17-1 Distribution of REO Com
Page 97 and 98: Assay Statistics for Upper Zone* *
Page 99 and 100: CUT-OFF GRADE A previous public res
Page 101 and 102: underneath for SG measurement purpo
Page 103 and 104: Figure 17-4 Density Measurements AL
Page 105 and 106: was equal to 60 m by 60 m by 30 m a
Page 107 and 108: Table 17-12 Detailed Resource Break
Page 109 and 110: Table 17-13 Indicated Mineral Resou
Page 111 and 112: Figure 17-7 Outline of Area of Indi
Page 113 and 114: The recoveries estimated for the fl
Page 115 and 116: grades were based upon the grades w
Page 117 and 118: Figure 18-1 Thor Lake Site Layout T
Page 119 and 120: Scott Wilson RPA recommends the use
Page 121 and 122: During discussions with the mine de
Page 123 and 124: Figure 18-4 Mine Layout Some of the
Page 125 and 126: Figure 18-5 Mine Development Schema
Page 127 and 128: Table 18-2 Development Tonnage Brea
Page 129 and 130: Until the crusher is in place and t
Page 131 and 132: Lateral Development The access decl
Page 133 and 134: Equipment will be selected based up
Page 135 and 136: Table 18-6 Estimated Electrical Loa
Page 137 and 138: VENTILATION The mine ventilation is
Page 139: for closing unused areas and for ch
Page 143 and 144: Paste Fill System A paste fill syst
Page 145 and 146: Communications Mine communications
Page 147 and 148: completion of the 30 m to 50 m long
Page 149 and 150: HEALTH AND SAFETY All crew will be
Page 151 and 152: The crushing plant is designed for
Page 153 and 154: Table 18-12 (Cont’d) Principal Pr
Page 155 and 156: Figure 18-9 Hydrometallurgical Plan
Page 157 and 158: The Pine Point hydrometallurgical f
Page 159 and 160: Decant pipeworks have been included
Page 161 and 162: • Development of pre-feasibility
Page 163 and 164: Design Basis The pre-feasibility le
Page 165 and 166: non-woven geotextile) to prevent da
Page 167 and 168: divert surface drainage away from r
Page 169 and 170: A high pressure (200 psi) compresse
Page 171 and 172: Fuel deliveries are assumed to be s
Page 173 and 174: Mill Supplies The key mill supplies
Page 175 and 176: Table 18-15 Surface Equipment Fleet
Page 177 and 178: Figure 18-10 Thor Lake Temporary Ba
Page 179 and 180: • Together with the unloading log
Page 181 and 182: it will be necessary to upgrade the
Page 183 and 184: Table 18-16 Hydrometallurgical Plan
Page 185 and 186: Table 18-17 Surface Mobile Equipmen
Page 187 and 188: Rare Earth FOB China* FOB China** P
Page 189 and 190: • loparite and eudialyte in alkal
Page 191 and 192:
Table 18-18 Rare Earth supply - 200
Page 193 and 194:
Table 18-20 Rare Earth Demand by Ap
Page 195 and 196:
Table 18-22 Proposed New REO Projec
Page 197 and 198:
in China. On this basis, Avalon is
Page 199 and 200:
Determine Prices for Avalon’s Pro
Page 201 and 202:
The balance of niobium supply is co
Page 203 and 204:
epresenting about 18% of total zirc
Page 205 and 206:
Table 18-25 Historic Chinese Export
Page 207 and 208:
Figure 18-16 Tantalum Markets - 200
Page 209 and 210:
the price for tantalum chemicals in
Page 211 and 212:
Surface Hydrology The Thor Lake dra
Page 213 and 214:
seven) have occurred more frequentl
Page 215 and 216:
elative to uranium, the overall eff
Page 217 and 218:
interviews conducted for the nearby
Page 219 and 220:
Wildlife Early science-based wildli
Page 221 and 222:
Other environmental permits/approva
Page 223 and 224:
TAXES The NWT diesel tax has been i
Page 225 and 226:
Table 18-31 Mine Capital Cost Estim
Page 227 and 228:
Table 18-33 Surface Infrastructure
Page 229 and 230:
Table 18-36 Indirect Cost Estimate
Page 231 and 232:
Table 18-37 Contingency Allowance A
Page 233 and 234:
Operating Cost Exclusions The opera
Page 235 and 236:
Table 18-40 Underground Mine Cost S
Page 237 and 238:
Table 18-41 Mine Cost Details Avalo
Page 239 and 240:
Thor Lake Surface The Thor Lake sur
Page 241 and 242:
Table 18-45 Sales and Marketing Cos
Page 243 and 244:
Table 18-47 Rail Car Load Limits Av
Page 245 and 246:
there will be no overhauls in the i
Page 247 and 248:
Other supplies and freight will be
Page 249 and 250:
Table 18-55 Hydrometallurgical Plan
Page 251 and 252:
Table 18-56 Cash Flow Summary Techn
Page 253 and 254:
The sensitivity of the base case 8%
Page 255 and 256:
19. INTERPRETATION AND CONCLUSIONS
Page 257 and 258:
• The Mineral Reserves, which hav
Page 259 and 260:
20. RECOMMENDATIONS The authors of
Page 261 and 262:
21. REFERENCES BCC Research (2009):
Page 263 and 264:
MDN Inc (2010): News Release Melvil
Page 265 and 266:
Wardrop Engineering Inc. (2009): Th
Page 267 and 268:
23. CERTIFICATES OF QUALIFIED PERSO
Page 269 and 270:
CERTIFICATE OF QUALIFIED PERSON I,
Page 271 and 272:
CERTIFICATE OF QUALIFIED PERSON I,
Page 273 and 274:
Section 416000 Section 416100 Secti
Page 275 and 276:
Page 277 and 278:
Page 279 and 280:
Technical Report 43-101 - March 13,
Page 281 and 282:
Page 283 and 284:
Page 285 and 286:
Page 287 and 288:
Page 289:
show all

technical report on the nechalacho deposit, thor lake project ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?