NW.P.PC.L - Delhi Pollution Control Committee

a. ~
- '---
I'
-
"\
OFFICE OF THE: DELHI POLLUTION CONTROL COMMITTEE
4thFLOOR, IS8T BUILDING, KASHMERE GATE, DELHI-110006
~ ""'.., For Ornce Use Only
FORM NO.. ,. ..,...........-....-.....
Received by ,.-. ..- .-. ., ....-
Date of Receillino .,- "'-"-" ."... ....-
Common Applicationfor Consent
UnderWater(Preventionand Control of Pollution) Act, 1974and
UnderAir (Preventionand Control of Pollution) Act, 1981,as amended
ORANGE
From:
MIs Pragati Power Corporation Ltd.
IP Estate, Ring Road,
New Delhi - 110002
Dated: '2. '&- 01.-0..(,.
To,
The Member Secretary,
Delhi Pollution Control Committee,
4thFloor, I.S.8.T. Building,
Kashmere Gate, Delhi - 110006.
SirlMadam,
We herebyapply for
(Q Consent to Esta~lish'Operate'Renewal of Consent under section 25 and 26 of the Water
(Preventionand Control of Pollution)Act, 1974, as amended.
(ii) Consentto Establ'h/OperatelRenewal of Consent under section 21 of the Air (Prevention and
Controlof Pollution)Act, 1981, as amended.
Part A: General
1. Name, designation office address with
Telephone: fax numbers, e-mail of the
applicant!occupier'Institution' Local Body
Rajinder Tiku, DGM (I/C)-Projects,
Pragati Power CorporationLimited, I.P.
Estate, Ring Road, New Delhi - 110002
Tel:23370346
Fax:23378947
Email:r~tiku@hotmail.com
2. (a) Name and address of the industrial
unit/premises: for which the application is
made. (withtelephoneand fax number)
(b) Status ofthe Unit
Rent
(c) Name and address of the premises owner (with:
telephone and fax number)
Proposed 350 MW (nominal) Pragati II
Gas based CombinedCycle Power
Project,New Delhi.
Tel:23370346
Fax:23378947
~Owned
Don
Premises
Pragati Power CorporationLimited, I.P.
Estate, Ring Road, New Delhi - 110002
Tel:23370346
Fax~117R947

-
(d) Name & Designation of the person authorized to :
sign this application form (The original
authorization except in case of individual
proprietary concern to be enclos~)
3. Names, residence address with telephone and fax:
number of Managing Director/Managing Partner and
officer responsible for matters connected with
pollution control
4. (a) Are you registered as a small scale Industrial Unit:
(b) If yes, give the number and date of registration
5. Gross capital investment (in Rs.) of the Unit without :
depreciation till date of application (cost of building,
land, plant and machinery) (To be supported by an
affidavit and: Certificate form a Charted Accountant.
For proposed unit(s), give estimated figure)
Ra.jinder Ti1.l.1. DGM (IIC )-Pfl)jects.
I A., "" Anne"." .r
Yes
GJNO
Tlus is a proposed project.
Estimated Cost=Rs.1 388.66 cr.
6. (a) Location of the Unit
:~ IndustrialDNon Industrial
~ Area Area
(b) If situated in industrial Area, details of CETP:
Society membership thereof (Enclose copy of I NOTAPPLIClillLE
CETP membership)
7. (a) Total plot area ofthe unit (in sq. meter)
(b) Built-up area ofthe unit (in sq. meter)
95.000 sq. meter
70,000 sq. meter
(c) Sanction Power Load (in HP)
8. Month and Year of Commencement of Production
I
N.A.
I 2008-09
(a) Proposed
Unit
Gas based combined cycle power pf(~iect
comprising Gas Tm-bine. Heat Recoyen
Steam Generator and Steam Turbine
(b) Existing Unit
9. (a) Number of workers
(b) Number of employees (including workers and
office staff)
10. List of products and by-products manufactured in
tones/month, KI/month or numbers/month (Give
figure corresponding to maximum installed
production capacity (Separate sheet may be
enclosed)
11. List of raw materials and process chemicals with
annual consumption corresponding to above stated
production figures, in tones/month or KUmonth or
numbers/month (Separate sheet may be enclosed)
12. Description of process of manufacture for each of the
products (showing illput, output, quality and quantity
Nil
J\1ax. 350 nos. during construction
175 persons
(9{)staff+ 85 contractor's employee)
350 MW Electrical Po\\er ( Nominal)
MaXlll.capacity 385 MW depending on
clmtif.,.uration
Refer page no. 3. Chapter I ofRELA.
report / Annexure- n
Refer page no. 16-18. Chapter 2 of REIA
report

.,J#
of solid, liquid and gaseous wastes, if any from each
unit process)
(To be supported by flow sheet and/or water balance
sheet)
Part B: Waste Water Aspects
13. Water consumption for different users (Iitreslday)
(a) Domestic
purpose
(b) Industrial cooling or boiler feeds
(c) Processing whereby water get polluted and the
pollutants are easily biodegradable.
(d) Processing whereby water gets polluted and the
pollutants are not easily biodegradable and are
toxic.
(e) Service water, Gardening etc.
: Refer water balance diagram
~
111.856 KL/day (494 m'/hr)
5.880 KL/day (245 m'/hr)
[N.A.
[ 120 KL /day (5 m'/hr)
Total: 17,856 Kilo-litre/day (744 m%r)
14. Source of water supply.
(a) Municipal Authority
(b) Ground Water
Treated sewage from Okhla STP of DJB
18000 KUday process water from STP
7.0 KUday potable water
Nil
15. Quantity of waste (effluent) generated
(i) Domestic (sewage)
(ii) IndustriallTrade Effluent
(a) Cooling Tower Blowdown
(b) Power Cycle Blow down
Nil
5,400 KUday (225 m31hr)
480 KUday (20 m31hr)
(g) TotallndustriallTrade
Effluent
5880 KUDay (245 m31hr)
16. Present treatment of trade effluent (Give sizes
/capacities of treatment units). (A schematic diagram
of the treatment scheme with inleUoutlet
characteristics of each unit operation/process is to
be provided. Include details of residue management
systems (ETP sludges)
17. Mode of disposal of treated effluents, with
Respective quantity, Litres/Day
i. Into public sewer/open drainlland for irrigation/
inland surface water.
ii. Quantity of treated effluent reused/Recyded,
(Iitres/day)
iii. Provide a location map of disposal Arrangement
clearly indicating the outlet(s) for sampling
18. (a) Quality of Untreatedltreated effluents (Specify
pH, SS, BOD and specific pollutant relevant to
The proposed treatment
details for proposed unit is
giyen in chapter 4. pnge no.
101-1m of REIA report.
Around 20% of treated etlluent
\yiH be recycled back in to
system. 5% \yiH be used fix
green belt deye1opment and
remaining \yiH be discharge in
to riyer Yamuna through near
by drain after appropriate
treatment.
Quality of treated eft1uent shaH
be \\ithin prescribed limit
3
....

~
j",
the industry. Refer Schedule-I for industry
specific standards and Schedule-VI for General
effluent standards of Environment Protection
Rules, 1986, as amended to date)
(b) Enclose a copy of the latest report of Analysis
from the laboratory approved by Delhi Pollution
Control Committee for proposed unit furnish
expected characteristics of the Untreatedltreated
effluent.
Within stipulated limit jJrescribed
by MoEF/CPCBIDPCC
part - C: Air Emission Aspects
19. Details of Stack (Process & Fuel Stacks)
(a) Stack number(s)
(b) Number of operational Stacks
(b) Attached to
(c) Capacity
(d) Fuel Type
(e) Fuel Quantity (Kg/hr or litlhr)
(f) Materialof construction
(g) Shape (round/rectangular)
(h) Height, m (above ground level)
(i) Height, m (above roof level)
U>Sampling facilityprovided
(k) Diameter/size, in meters
(I)Gas Quantity, Nm3/hr.
(m) Gas temperature, °c
(n) Exitgas velocity, m/sec.
(0) Control equipment
:4
:2
: Heat Recovery Steam Generator (HRSG)
: Natural GaslRe-gasified LNG
: 1.86 MSCMD
: steel
: round
: 70m
: depends on HRSG design (to be furnished later)
: Yes, continuous stack monitoring facilitywillbe
installed
:5m
2x1150841Nm3/hr
: 100
: 20
: Dry Low NOx(DLN)burners in Gas turbine
combustion system.
20. Details of D.G. Set(s) : One diesel generator set for emergency power has been envisaged.
Further details shall be provided during detail engineering stage.
stack Height Acoustic Month & Year
Noise Noise
Month & Stack Height above roof of the enclosure of instaUation
s. Monitoring level
Capacity Year of above Ground building where installed of acoustic
No. report within the
(in KVA) installation level D.G. Set
(Yes/No)
enclosure!
submitted limit
of D.G. Set (in meters) instaUed acoustic
(in meters)
treatment
(Yes/No) (Yes/No)
1. 1300KVA Along with - - Yes Before - Yes
the proiect
commissioning
21. Quality of treated fuel gas emissions and process
emissions (Enclose a copy of the latest report of
analysis from the approved laboratory by Delhi
Pollution Control Committee. For proposed units
furnish the expected characteristic of the emissions).
These are proposed units. Oilly NOx
wiH be emitted from proposed
actiyity (lnd the concentration \yiH be
\yith in prescribed limit.
Part - D : Hazardous Waste Aspects
22. (a) Whether the unit is generating hazardous waste as defined in the Hazardous Waste
(Management and Handling) Rules, 1989, as amended.
(b) Ifso, the category No.
No hazardous
\yaste generation
4
l

f
I
.
I
I!Iw.
23. Quantity of hazardous waste generated (kgIdays) or (MT/month): N. A
24. We further declare that the information furnished above is correct to the best of our knowledge.
25. We hereby submit that in case of any change from what is stated in this application in respect of
raw materials, products, process of manufacture and treatment and/or disposal of effluent,
emissions, hazardous wasted etc. in quality and quantity; a fresh application for
ConsenUAuthorization no change shall be made.
26. We undertake to furnish any other information within one month of its being called by the
Committee.
27. We agree to submit to the Committee an application for renewal of consenUauthorization in two
months in advance before the date of expiry of the consenUauthorization validity period.
28. We hereby declare that the provisions of Master Plan of Delhi shall not be violated at any stage.
29. We enclose herewith a Demand Draft No.021272 Dated-27.2.2006 Drawn on State Bank of India,
Rajghat Power House, New Delhi-110002 for Rs.4400/- (Rupees four thousand four hundred
only)Drawnin favour of DelhiPollutionControlCommitteeasthe fee of consent.
Yours faithfully,
Dated..2~..
................ 2..0 b
Signature....~~~. ~~~. .'..
Name: Rajinder Tiku
Designation: DGM(YC),PPCL
Documents enclosed: Proposed unit
1. CertifioGtefrom Charted /\oOOl:mtaRt
2. List of raw materials used, product manufactured and by-products
generated during the process with maximum quantityper day.
3. Manufacturing Process in Detail (included in EIA report)
4. Layout Plan of the Unit( included in FR)
5. Proof of CETP Membership (Attested by Gazetted Officer)
6. Staok/Chimney monitoring report
7. Effluent analycic report
8. Noise Monitoring Report (included in the EIA report)
9. Affidavit in the prescribed form:::!tmentioning dGte of Establishment of
the Unit.
10. Adequacy report of ETP
11. Adequacy report of ECS
12. Copy of MCDiLooal Body (Factory Lioenoe) duly attested by
Gazetted offioer, 00 a proof of existenoe of the unit
13. Copy of eleotrioity/power cupply canotion by Delhi Vidyut Board
14. Copy of Water Supply sanction by Delhi Jal Board
15.GtRers
- Annex.-II
- Annex.III
I
,
I
.
Signature... ... ...%~~.~~~... .....
Name: Rajinder Tiku
Designation: DGM (IIC),PPCL
5
~
-