MDD Parts Manual.book - Walker Mowers

More documents

Recommendations

Info

ITEM PART DESCRIPTION NO. NO. NO. REQ’D OPTIONAL LIGHT BLK/WHT YEL RED FUEL PUMP BLK BLK/WHT BLK POWERFIL R MOTOR BLK/WHT BLK RED ORG BLK/WHT BLK/WHT RED YEL/GRN OIL PRESSURE SWITCH GRA ORG ORG RED/BLK BLK WIRING SCHEMATIC - HORN + PUR BLU/RED WATER TEMP GAUGE SENDER WHT RED BLK YEL RED STARTER STARTER SOLENOID BLK BLK GLOW PLUGS FUEL SOLENOID GRASS PAK SWITCH ALTERNATOR WALKER MODEL MDD ITEM PART DESCRIPTION Beginning S/N 2001-49370 NO. NO. NO. REQ’D R WATER GRN GRN WATER GRN TEMP TEMP SWITCH 1/4" SWITCH 3/8" ENGINE GRN GRA RELAY - D YEL 30 GRN 85 86 BRN BLK 87 87A FAN BLK BLK RESISTOR OFF GLOW PLUG START RUN IGNITION SWITCH CIRCUITS RELAY - A FUEL SOLENOID START RELAY (PULL) OFF 30 + 87A GLOW PLUG 30 + 87 START 30 + 87 RUN 30 + 87 RELAY - B WARNING RELAY OFF 30 + 87A GLOW PLUG OPEN START 30 + 87A RUN 30 + 87A ALL OPEN 30 + 19 + AC 30 + 17 + 50 + AC 30 + AC 30 = BATTERY 17 = START / REVERSING MODULE 19 = GLOW PLUGS 50 = START AC = FUEL PUMP, FUEL SOLENOID GAUGES, AND FAN RELAY - C FUEL SOLENOID RUN RELAY (HOLD) OFF OPEN GLOW PLUG 30 + 87 START 30 + 87A RUN 30 + 87A RELAY - D FAN SPEED CONTROL OFF 30 + 87A RUN (LOW) 30 + 87A RUN (HIGH) 30 + 87 RELAY - E START/TIME DELAY RELAY OFF 30 + 87A START 30 + 87A PTO ON OPEN RED OPTIONAL LIGHT RED BLK YEL/GRN GRA YEL ORG/WHT BLU/RED PUR RED BLK YEL/GRN YEL/GRN GRA YEL BLU/RED PUR PUR RED VOLTAGE METER RED RED GRA GRA G I RED LIGHTS PTO INTERLOCK SWICH BLK/WHT HOUR METER + - RED BLK BLK BLK BLU/RED WATER TEMP G S I RED RED Use only genuine Walker ® replacement parts. Effective Date 03-01-03 72 GRN BLK RED TIME DELAY MODULE 87 GRN 85 86 30 RELAY - C BATTERY BLK + _ ORG RED RED BLK RED BLK YEL RED BLK BRN GRN 30 AMP CIRCUIT BREAKER 40 AMP CIRCUIT BREAKER CHASSIS GROUND GRN SEAT SWITCH RED RED YEL RED RED/BLK BRN GRN REVERSING MODULE BLK YEL BLK GRA BRN ORG/WHT FSC NEUTRAL INTERLOCK SWITCH ORG/GRN RED 10 AMP CIRCUIT BREAKER ORG/WHT RED 5 AMP CIRCUIT BREAKER RED BLK/WHT YEL/GRN PUR PUR - WARNING HORN + GRA RED YEL BLU RED RED RED RED RED YEL/RED 30 BLK 85 86 87 BLU 87A RELAY - A RED 30 BRN 86 85 ORG 87 87A YEL/RED RELAY - B BRN RELAY - E 30 BRN 87A 85 86 ORG BLK GRA RED RED ORG IGNITION OIL PRESSURE LIGHT WATER TEMP LIGHT BLU 50 17 AC RED 19 30 RED YEL/GRN RED PUR RED FOR TAIL WHEEL LOCK
LIMITED WARRANTY FOR WALKER COMMERCIAL RIDER MOWER 1. WHAT THIS WARRANTY COVERS, AND FOR HOW LONG: Walker Manufacturing company will, at its option, repair or replace, without charge, any part covered by this warranty which is found to be defective in material and/or workmanship within one (1) year* after date of sale to the original retail purchaser unless the product is used for rental purposes, in which case this warranty is limited to ninety (90) days. At Walker's request, customer will make the defective part available for inspection by Walker and/or return the defective part to Walker, transportation charges prepaid. All parts and components of the Walker Mower are covered by this warranty except the following components which are warranted separately by their respective manufacturers: Kohler Engine Kubota Engine Kawasaki Engine Eaton Hydraulic Transmission Peerless Gearboxes Battery Tires The available warranties covering these items are furnished with each mower. Walker does not assume any warranty obligation, liability or modification for these items, which are covered exclusively by the stated warranty of the respective manufacturers noted above. * An extended three (3) year warranty is offered on the Walker P/N 6200-8 Gear Axle Assembly. 2. WHAT THIS WARRANTY DOES NOT COVER: A. This warranty does not cover defects caused by depreciation or damage caused by normal wear, accidents, improper maintenance, improper use or abuse of the product, alterations, or failure to follow the instructions contained in the Owner’s Manual for operation and maintenance. B. The customer shall pay any charges for making service calls and/or for transporting the mower to and from the place where the inspection and/or warranty work is performed. 3. HOW TO OBTAIN SERVICE UNDER THIS WARRANTY: Warranty service can be arranged by contacting the dealer where you purchased the mower or by contacting Walker Manufacturing Company, 5925 East Harmony Road, Ft. Collins, CO 80528. Proof of the date of purchase may be required to verify warranty coverage. 4. WARRANTY LIMITATION: A. THERE IS NO OTHER EXPRESS WARRANTY. ANY WARRANTY THAT MAY BE IMPLIED FROM THIS PURCHASE INCLUDING MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE IS HEREBY LIMITED TO THE DURATION OF THIS WARRANTY AND TO THE EXTENT PERMITTED BY LAW ANY AND ALL IMPLIED WARRANTIES ARE EXCLUDED. Some states do not allow limitations on how long an implied warranty lasts, so the above limitations may not apply to you. B. WALKER WILL NOT BE LIABLE FOR ANY INCIDENTAL, CONSEQUENTIAL, OR SPECIAL DAMAGES AND/OR EXPENSES IN CONNECTION WITH THE PURCHASE OR USE OF THE MOWER. Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation(s) or exclusion(s) may not apply to you. C. Only the warranty expressed in this limited warranty shall apply and no dealer, distributor, or individual is authorized to amend, modify, or extend this warranty in any way. Accordingly, additional statements such as dealer advertising or presentations, whether oral or written, do not constitute warranties by Walker, and should not be relied upon. D. This warranty gives you specific legal rights, and you may also have other rights which vary from state to state. 73
Page 1 and 2:
ILLUSTRATED PARTS MANUAL Model MDD
Page 3 and 4:
ILLUSTRATED PARTS LIST Section of M
Page 5 and 6:
TRACTOR DECALS 6 23 1 25 12 9 15 26
Page 7 and 8:
BODY / CHASSIS ASSEMBLY (GHS MODELS
Page 9 and 10:
REAR BODY ASSEMBLY (GHS MODELS) Ref
Page 11 and 12:
BODY ASSEMBLY (SD MODELS) 1 F009 F0
Page 13 and 14:
MAIN COMPONENT POWER TRANSMISSION (
Page 15 and 16:
MAIN COMPONENT POWER TRANSMISSION (
Page 17 and 18:
ENGINE GROUP Refer to Air Intake &
Page 19 and 20:
AIR INTAKE AND EXHAUST GROUP 5 5 18
Page 21 and 22:
RADIATOR GROUP Refer to Engine Grou
Page 23 and 24: HYDROSTATIC GROUND DRIVE ASSEMBLIES
Page 25 and 26: STEERING CONTROL ASSEMBLIES 1 37 Re
Page 27 and 28: THROTTLE CONTROL ASSEMBLIES Refer t
Page 29 and 30: PARKING BRAKE ASSEMBLY 1 19 20 F111
Page 31 and 32: GHS GROUP F025 Refer to Electrical
Page 33 and 34: GHS POWERFIL ® ASSEMBLY 15 F025 F0
Page 35 and 36: GHS 7.0 BUSHEL CATCHER & EXHAUST DE
Page 37 and 38: GHS 9.5 BUSHEL CATCHER ASSEMBLY Ref
Page 39 and 40: INSTRUMENT PANEL ASSEMBLY 1 F228 2
Page 41 and 42: ELECTRICAL ASSEMBLY F031 30 10 GRA
Page 43 and 44: ELECTRICAL ASSEMBLIES (GHS 7.0 / 9.
Page 45 and 46: ELECTRICAL CONNECTORS 1 14 26 35 43
Page 47 and 48: POWER DECK LIFT KIT 28 F134 1 F068
Page 49 and 50: ARMREST KIT / TOUCH-UP PAINT 1 2 F3
Page 51 and 52: COMFORT SEAT / ARMREST KIT 9 1 10 8
Page 53 and 54: SUSPENSION SEAT KIT 1 6 2 3 4 5 7 F
Page 55 and 56: LIGHT KIT 1 F134 2 1 3 1 4 1 F134 2
Page 57 and 58: CASE-HARDENED BLOWER KIT Refer to
Page 59 and 60: SPEED UP KIT 1 F171 2 F067 F171 Eff
Page 61 and 62: POWER DUMP KIT (7.0 BUSHEL GHS MODE
Page 63 and 64: POWER DUMP KIT (9.5 BUSHEL GHS MODE
Page 65 and 66: NO CATCH DEFLECTOR KIT (7.0 BUSHEL
Page 67 and 68: TAIL WEIGHT KIT 1 2 F285 F175 F175
Page 69 and 70: TAIL WHEEL LOCK KIT 1 F026 F134 2 3
Page 71 and 72: WIDE TAIL WHEEL / ALL-TERRAIN TIRE
Page 73: LUBRICATION POINTS 1 2 3 2 1 4 4 5
show all

MDD Parts Manual.book - Walker Mowers

Create successful ePaper yourself

Delete template?

Save as template?