maintenance - Polaris

More documents

Recommendations

Info

OPERATION All Wheel Drive (AWD) Locking the Differential NOTICE: Damage to the differential can occur if it is engaged while the vehicle is traveling at high speeds or while the rear wheels are spinning. Slow the vehicle to nearly stopped before engaging the differential. Locking the differential in slippery or low traction conditions helps improve traction. Move the rocker switch to the center position (2WD) to lock the differential and operate in rear wheel drive. Press the bottom of the switch to unlock the differential and allow the rear drive wheels to operate independently. This mode of operation is well suited to turf driving or whenever aggressive traction is not required. 46
EMISSION CONTROL SYSTEMS Noise Emission Control System Do not modify the engine, intake or exhaust components, as doing so may affect compliance with U.S.A. EPA noise control requirements (40 CFR 205) and local noise level requirements. Operation on Public Lands in the U.S.A. Your Polaris vehicle has a spark arrestor that was tested and qualified to be in accordance with the USFS standard 5100-1c. Federal law requires that this spark arrestor be installed and functional when the vehicle is operated on public lands. Operation of off-road vehicles on public lands in the U.S.A. is regulated by 43 CFR 420. Violations are subject to monetary penalties. Federal regulations can be viewed online at www.gpoaccess.gov/ecfr/. Crankcase Emission Control System This engine is equipped with a closed crankcase system. Blow-by gases are forced back to the combustion chamber by the intake system. All exhaust gases exit through the exhaust system. Exhaust Emission Control System The emissions from the exhaust of this vehicle are controlled by engine design, including factory-set fuel delivery and ignition. The engine and related components must be maintained at Polaris specifications to achieve optimal performance. Engine idle speed is the only adjustment Polaris recommends that the operator perform. Any other adjustments should be performed by an authorized Polaris dealer. The emissions label is located on the frame under the seat. Electromagnetic Interference This spark ignition system complies with Canadian ICES-002. This vehicle complies with the EMC requirements of European directives 97/24/EC and 2004/108/EC. 47
Page 2 and 3: Pantone 426C Improper vehicle use c
Page 4 and 5: The text is printed on 100% recycle
Page 6 and 7: POLARIS, THE WAY OUT and RANGER are
Page 8 and 9: INTRODUCTION The RANGER is an off-r
Page 10 and 11: INTRODUCTION Vehicle Identification
Page 12 and 13: SAFETY Safety Labels and Locations
Page 14 and 15: SAFETY Operator Safety WARNING Seri
Page 16 and 17: SAFETY Operator Safety • Never op
Page 18 and 19: SAFETY Operator Safety WARNING Fail
Page 20 and 21: SAFETY Operator Safety Operating on
Page 22 and 23: FEATURES AND CONTROLS Component Loc
Page 24 and 25: FEATURES AND CONTROLS Console Indic
Page 26 and 27: FEATURES AND CONTROLS Gear Selector
Page 28 and 29: FEATURES AND CONTROLS Seat Belts Th
Page 30 and 31: FEATURES AND CONTROLS Roll-Over Pro
Page 32 and 33: OPERATION Break-In Period Engine an
Page 34 and 35: OPERATION Starting the Engine 1. Al
Page 36 and 37: OPERATION Driving Procedure 1. Wear
Page 38 and 39: OPERATION Driving Uphill Whenever t
Page 40 and 41: OPERATION Driving Through Water You
Page 42 and 43: OPERATION Driving in Reverse Follow
Page 44 and 45: OPERATION Hauling Cargo WARNING Hau
Page 46 and 47: OPERATION Dumping the Cargo Box 1.
Page 48 and 49: OPERATION Parking the Vehicle 1. Ap
Page 52 and 53: MAINTENANCE Periodic Maintenance Ch
Page 58 and 59: MAINTENANCE Engine Oil Always check
Page 60 and 61: MAINTENANCE Engine Oil Oil and Filt
Page 62 and 63: MAINTENANCE Engine Oil Oil and Filt
Page 64 and 65: MAINTENANCE Gearcases Transmission
Page 66 and 67: MAINTENANCE Spark Plugs Spark Plug
Page 68 and 69: MAINTENANCE Cooling System The engi
Page 70 and 71: MAINTENANCE Cooling System Overflow
Page 72 and 73: MAINTENANCE Polaris Variable Transm
Page 74 and 75: MAINTENANCE Vehicle Immersion NOTIC
Page 76 and 77: MAINTENANCE Filter Systems Breather
Page 78 and 79: MAINTENANCE Spark Arrestor WARNING
Page 80 and 81: MAINTENANCE Throttle System WARNING
Page 82 and 83: MAINTENANCE Brakes The front and re
Page 84 and 85: MAINTENANCE Suspension Adjustments
Page 86 and 87: MAINTENANCE Tires Wheel Removal 1.
Page 88 and 89: MAINTENANCE Lights Headlight Beam A
Page 90 and 91: MAINTENANCE Battery WARNING Battery
Page 92 and 93: MAINTENANCE Battery Battery Install
Page 94 and 95: MAINTENANCE Battery Battery Chargin
Page 96 and 97: MAINTENANCE Cleaning and Storage Wa
Page 98 and 99: MAINTENANCE Cleaning and Storage Ch
Page 100 and 101:
MAINTENANCE Cleaning and Storage St
Page 102 and 103:
SPECIFICATIONS RANGER 400 HO Maximu
Page 104 and 105:
POLARIS PRODUCTS Part Number Descri
Page 106 and 107:
TROUBLESHOOTING Engine Doesn't Turn
Page 108 and 109:
TROUBLESHOOTING Engine Stops or Los
Page 110 and 111:
WARRANTY LIMITED WARRANTY Polaris S
Page 112 and 113:
WARRANTY LIMITATIONS OF WARRANTIES
Page 114 and 115:
WARRANTY U.S.A. EPA Emissions Limit
Page 116 and 117:
MAINTENANCE LOG Use the following c
Page 118:
MAINTENANCE LOG DATE MILES (KM) OR
show all

maintenance - Polaris

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?