Water Pump Catalogue - Repco Trade Zone

2007 

Water Pump 

Catalogue

Catalogue Department 

362 Wellington Road, 

Mulgrave, Victoria, 3170 

Telephone: (03) 9566 5444 

Facsimile: (03) 9566 0878 

E-mail: catalogue@repco.com.au 

This catalogue has been prepared by Repco Limited as a general reference guide only for its own use and for the use by certain customers. This 

catalogue does not imply that any such parts are available for supply by Repco. 

Enquiries regarding supply of such parts should be made to your nearest Repco store on 133 227. 

In preparing the catalogue, Repco has made reference to various trade publications. Repco has taken care to ensure the accuracy of the 

information contained in this catalogue. Repco does not accept any responsibility or liability whatsoever for any inaccuracy of any information 

contained in this catalogue. 

Where reference is made to parts that may be substituted for other parts, Repco does not intend to imply that the substituted parts are 

necessarily of the same standard and quality. Repco makes no representation that one product may be used to replace the other. Repco only 

represents that each of the substituted parts mentioned are intended by the respective manufacturer thereof to be used for the same purpose. 

This catalogue is protected by copyright and may not be reproduced in whole or in part without the prior written consent of Repco. This 

catalogue is supplied on the condition that it may not be lent, sold, copied or otherwise circulated to any person without the prior written 

consent of Repco. E. & O.E. Copyright Repco.

REPCO GUARANTEE OF QUALITY 

Repco warrant all Water Pump products bearing the brand names Silverline which within 12 months of sale 

or 20,000km and GMB which within 24 months of sale or 40,000km whichever shall occur first, are, upon 

delivery of such product to the seller, found to be defective will, on the return to the place of purchase, be 

replaced by Repco free of charge. 

This guarantee does not extend to damage caused by mis-use, improper installation or operations, lack of 

maintenance or other cause beyond the control of Repco. 

The guarantee is additional to any conditions or warranties applying by virtue of the Trade Practices Act or 

applicable state legislation and to all other rights and remedies available to a consumer or goods or services 

in law. 

Where reference is made to parts that may be substituted for other parts, Repco does not intend to imply 

that the substituted parts are necessarily of the same standard and quality. Repco makes no representation 

that one product may be used to replace the other. Repco only represents that each of the substituted parts 

mentioned are intended by the respective manufacturer thereof to be used for the same purpose. 

This catalogue has been prepared by Repco Limited as a general reference guide only for its own use and 

for the use by certain customers. This catalogue does not imply that any such parts are available for supply 

by Repco. 

Enquiries regarding supply of such parts should be made to your nearest Repco store on 133 227. 

REPCO LIMITED 

362 Wellington Road, Mulgrave, Victoria, 3170 

Telephone: (03) 9566 5444 

Page

INDEX 

Section 1 The Heart Of The Cooling System................................................................................................. 3 

Section 2 The Complete Cooling Offer.......................................................................................................... 4 

Section 3 Water Pump Applications............................................................................................................... 6 

Section 4 Water Pump Product Guide ........................................................................................................ 38 

Section 5 Hints On Over Heating................................................................................................................. 62 

Section 6 Quick Coolant Summary Points................................................................................................... 63 

Section 7 Electrocution & Stray Current...................................................................................................... 64 

Section 8 Coolant pH Readings................................................................................................................... 65 

Section 9 Trouble Shooting - Common water pump failures and their causes......................................... 66 

Page

Water Pumps - the HEART 

of the Cooling System 

The HEART of the Cooling System 

Repco is pleased to offer the automotive trade a comprehensive water pump program comprising of almost 

400 part numbers servicing most vehicles in the Australian car parc. The range is constantly in expansion as 

Repco recognises the need for the introduction of water pumps for new applications. 

The Repco water pump program offers customers the choice of two brands, the world renowned GMB brand 

and our Silverline brand, built to the high quality levels of Repco by reputable automotive component 

manufacturers. The GMB product is fully backed with a 2 year manufacturers warranty with the Silverline product 

offering a 1 year warranty period. 

This Quick Reference Water Pump Catalogue is designed to give the user more information than simply 

“which water pump suits which car”. It also contains some useful information regarding the installation 

of a water pump and a trouble shooting section explaining common cooling system issues. 

When fitting a water pump the following items must be checked and replaced if required: 

• Radiator 

• Radiator Cap 

• Thermostat Housing 

• Thermostat 

• Fan Belt 

• Radiator 

• Heater/Radiator Hose 

• Hose Clips 

A comprehensive range of these parts are stocked by Repco Auto Parts. 

Contact your nearest branch to place your order. 

WARNING: 

The most frequent cause of premature water pump failure is excessive belt tension. 

This type of failure is not covered by the manufacturer’s warranty. 

Please see that the OEM tension specifications are used when adjusting the belts. 

Another common cooling system problem is that of chemical and stray current corrosion. Necessary checks 

should be conducted during the fitting process to ensure that the possibility of premature corrosion is minimised. 

Please refer to page 64 for information on chemical corrosion and stray current corrosion prevention. 

Page

The Complete Cooling Offer 

Repco has, over a period of many years developed a reputation for providing the automotive aftermarket 

with the most outstanding and expansive range of quality automotive replacement parts. 

With the addition of the Repco radiator program, the cooling category has now evolved into a range that offers 

our customers a total cooling solution. 

The extensive range of cooling products currently comprises of the most demanded components supplied by 

the most trusted names in the industry. 

WATER PUMPS 

Repco water pumps are manufactured by the world leaders 

in aftermarket and OEM water pumps. 

All our water pumps are backed by the Repco quality guarantee 

and our extensive range covers all popular makes and models. 

AIR CONDITIONING COMPONENTS 

Repco are the experts in automotive air conditioning. 

Our extensive range comprises of compressors, clutches, 

condensers, receiver driers, accumulators, evaporators, 

refrigerant gas, valves, hoses, switches, relays and much more. 

DRIVE BELTS 

OEM suppliers of drive belts also supply Repco with our 

extensive range of drive belts. We cater for all popular 

passenger cars, light commercial and 4WDs. 

We stock an extensive range of v-belts and polyrib belts for 

all cooling requirements. 

ELECTRIC FANS AND SWITCHES 

Repco electric fans can offer an efficient and economical method 

of automotive cooling. Our electric fans will provide your vehicle 

with constant air flow which will increase cooling performance 

and fuel economy. 

FAN CLUTCHES 

Repco fan clutches are produced of die-cast aluminium 

which provide for a tight fit and the production of precision 

performance. Top quality bearings guarantee prolonged life 

and quieter operation. 

Page

The Complete Cooling Offer 

HOSE CLAMPS AND FITTINGS 

Repco hose clamps and fittings are manufactured to OEM standards, 

using the best possible materials and designs. An extensive range 

of hose clamping and connecting products is available from your 

Repco network. 

RADIATOR CAPS 

Repco’s range of radiator caps have moulded rubber 

sealing elements specifically shaped to allow for superior 

sealing characteristics under large amounts of negative 

and positive pressure. 

RADIATORS 

Repco’s impressive range of radiators are sourced from 

a number of well credentialed radiator manufacturers and 

carry full factory warranty and support. 

Repco radiators meet, and in many cases exceed the original 

equipment specifications. 

THERMOSTATS AND HOUSINGS 

Our range of thermostats are world class and are available in various 

types of packaging including blister packs and bulk packs. Blister packs 

are supplied with gaskets or o-rings. Repco housings are manufactured 

from the most appropriate metals to meet automotive needs. 

COOLING SYSTEM HOSE PACKS 

Repco is proud to offer specific packs to service the entire cooling 

system of popular vehicles. The packs contain upper and lower 

radiator hoses together with heater and bypass hoses. 

RADIATOR AND SMALL BORE HOSES 

Repco purchase radiator and small bore hoses from 

world class OEM suppliers. The specially designed 

hoses are offered as factory moulded or universal 

variants accommodating for the needs of the Australian 

market. All Repco hoses are engineered to resist 

electrochemical degradation. 

COOLANTS 

Repco stocks a diverse range of coolants and cooling 

system additives to meet the demands of your vehicle. 

Our coolants are guaranteed to perform in your engine 

and are certified to comply with all the relevant standards 

and test methods for coolants and corrosion inhibitors. 

Page

Water Pump Applications 

Audi 

MODEL SERIES CYL CAPACITY 

(LITRES) 

80 SERIES 

A3 

A4 

A6 

TT 

BMW 

316i 

318i 

318i/is 

320i 

323i 

325i 

330i 

525i 

528i 

530i 

540i 

730iL 

740iL 

X5 

ENGINE CODE DATES GMB 

PART NO 

SILVERLINE 

PART NO 

4WD 4 1.8 10/88-06/89 WP2453SL 

4 1.6 05/97-12/05 WP8132SL 

4 1.8 05/97-12/05 WP8131SL 

B5 6 2.6, 2.8 09/95-06/01 WP4762SL 

COMMENTS 

B5 4 1.8 08/95-01/06 WP4829 Including turbo 

6 2.6, 2.8 12/94-02/02 WP4762SL 

4 1.8 05/99-01/04 WP8131SL 

E36 4 1.6 03/95-04/99 WP3130SL 

E21 4 1.8 05/83-12/87 WP2358 WP2358SL 

E21, 30 4 1.8 03/80-04/83 WP990 

E30, 36 4 1.8 11/88-08/91 WP2671SL 

E30, 36, 46 4 1.8, 1.9 04/91-12/05 WP3130SL 

E30, 36 6 2.0 SOHC 02/88-02/95 WP2646 

E36, 46 6 2.0, 2.2 

DOHC 

04/91-12/05 WP2735SL 

E46 6 2.5 08/98-10/00 WP2735SL 

6 2.3 06/79-12/85 WP2154 With disengaging 

fan 

6 2.3 06/79-12/85 WP1559 WP1559SL With fixed fan 

E36 6 2.5 05/91-05/95 WP2735SL 

E46 6 3.0 09/00-12/05 WP2735SL 

E39 6 2.5 12/00-12/05 WP2735SL 

E28 6 2.8 01/82-12/85 WP2477 WP2477SL 

E39 6 2.8 04/96-12/00 WP2735SL 

E34 8 3.0 04/93-03/96 WP8124SL 

E34 8 4.0 05/93-03/96 WP8124SL 

E32, 38 8 3.0 10/92-02/97 WP8124SL 

E32, 38 8 4.0 02/95-06/96 WP8124SL 

8 4.4 11/00-12/05 WP8124SL 

Page



(LITRES) 

Chrysler 

NEON 

Citroen 

C5 

XANTIA 

XSARA 

Daewoo 

1.5I 

CIELO 

ESPERO 

LANOS 

LEGANZA 

MATIZ 

NUBIRA 

Daihatsu 

APPLAUSE 

CHARADE 


PART NO 

4 2.0 07/96-07/02 WP4102 

SILVERLINE 

PART NO 

COMMENTS 

4 2.0 06/01-12/05 WP8137SL Turbo diesel 

4 2.0 SOHC 09/94-10/98 WP4028SL 

4 2.0 DOHC 11/96-06/01 WP8101SL 

4 2.0 08/98-12/06 WP8101SL 

4 1.5 07/94-10/95 WP3071 WP3071SL Without dust shield 

4 1.5 07/94-10/95 WP3074 With dust shield 

4 1.5 06/96-02/98 WP4117 DOHC with heat 

shield 

4 1.5 06/96-02/98 WP3071 SOHC without heat 

shields 

4 1.5 10/95-07/97 WP4116 SOHC with heat 

shield 

4 2.0 LE4 03/95-07/97 WP2189 WP2189SL Without dust shield 

4 1.5 08/97-04/03 WP3071 WP3071SL 

4 1.5 08/97-04/03 WP3074 With dust shield 

4 1.6 08/97-04/03 WP4045 WP4045SL With heat shield 

4 2.0, 2.2 08/97-12/05 WP2800SL 

3 0.8 F8CV 10/99-12/05 WP8113SL 

4 2.0 C20SED 05/98-05/03 WP2800SL 

4 1.6 07/97-11/99 WP4045 WP4045SL 

A101 4 1.6 10/89-11/99 WP3009 WP3009SL 

CENTRO 3 0.7 3C12V 03/95-12/97 WP3059 

G10, 11 3 1.0 CB 01/83-12/85 WP2017 Without heater 

outlet 

G10, 11 3 1.0 CB 01/86-05/87 WP2027 With heater outlet 

G10, 11 3 1.0 CB 04/80-12/82 WP853 

G100, 200, 

200B, 202, 

202B, 203 

G100, G200, 

G202 

G102, 200, 

200B, 202B, 

203, 203B 

3 1.0 06/87-06/00 WP2027 With heater outlet 

3 1.0 06/87-04/96 WP2017 Without heater 

outlet 

4 1.3, 1.5 10/88-06/00 WP3009 WP3009SL 

Page



(LITRES) 

Daihatsu (continued) 

CUORE 

FEROZA 

HANDIVAN 

HI-JET 

MIRA 

PYZAR 

ROCKY 

SIRION 

TERIOS 

YRV 

Ford 

CAPRI 

CORSAIR 

CORTINA 


PART NO 

SILVERLINE 

PART NO 

2D HATCHBACK 3 1.0 07/00-03/03 WP8211SL 

COMMENTS 

F300 4WD 4 1.6 10/88-12/92 WP3009 WP3009SL With round hub 

F300, 310 4WD 4 1.6 10/88-01/99 WP3122 With square hub 

L701 2D VAN 3 1.0 05/99-03/03 WP8211SL 

L80M/VK 3 0.8 03/86-06/90 WP3059 

S60 2 0.5 09/77-07/81 WP863 

S65T 2 0.5 08/81-06/82 WP1070 

S70, 75, 76, 85 3 1.0 CB 08/82-06/90 WP2027 With heater outlet 

S70T, 70V 3 0.8 06/82-05/84 WP2017 

L200, 201 3 0.7, 0.8 10/90-04/95 WP3059 

F70, 75, 73M, 

77P, 77PC 

F70VGT, 

75VBGT 

F70VGT, 

75VBGT, 78B 

4 1.5, 1.6 02/97-07/00 WP3009 WP3009SL 

4 2.8 DL52 09/87-01/99 WP3111 

4 2.8 DL52T 01/85-09/87 WP3008 

4 2.8 DL52T 01/92-01/99 WP3111 

F73M 4 2.8 DL52 08/93-01/99 WP3008 

F80, 85, 80V, 

85V, 87P, 87PC 

4 2.0 3YC, 3YE 07/84-01/89 WP894 WP894SL 

M100 HATCH 3 1.0 08/98-12/05 WP8211SL 

M101 GTV-I 4 1.3 K3-VE 09/00-12/05 WP8261SL 

J100 DX/SX 

WAGON 

J102 DX/SX 

WAGON 

4 1.3 HCEJ 07/97-11/00 WP3122 With square hub 

4 1.3 K3-VE 11/00-12/05 WP8261SL 

4D WAGON 4 1.3 K3-VE 07/01-12/05 WP8261SL 

SA 4 1.6 B6 8V 02/90-09/90 WP1020 WP1020SL 

SA, SC, SE 4 1.6 B6, B6T 16V 10/90-09/94 WP3010 

UA 4 2.0 CA20E 11/89-12/92 WP3023 WP3023SL 

UA 4 2.4 KA24E 11/89-12/92 WP3022 

TC 4 1.6 08/70-09/74 WP730 

TC, TD 6 3.3, 4.1 08/70-06/76 WP800 

TC, TD, TE, TF 4 2.0 08/70-08/82 WP746 

TD, TE 6 3.3, 4.1 06/76-05/80 WP804 WP804SL With air conditioner 

TD, TE 6 3.3, 4.1 06/76-05/80 WP805 WP805SL Without air conditioner 

TF 6 3.3, 4.1 11/80-08/82 WP804 WP804SL 

Page



(LITRES) 

Ford (continued) 

COUGAR 

COURIER 

ECONOVAN 

ESCAPE 

ESCORT 

EXPLORER 

F100/BRONCO 

F250 

FAIRLANE 


PART NO 

SILVERLINE 

PART NO 

V6 2D COUPE 6 2.5 10/99-12/05 WP8202SL 

B1800 4 1.8 VC 11/78-10/82 WP824 

COMMENTS 

B2000 4 2.0 FE 06/85-04/87 WP893 WP893SL 22mm wide belt 

round tooth 

B2000 4 2.0 MA 11/82-05/85 WP756 

B2000, B2200 4 2.0, 2.2 FE, F2 04/87-06/93 WP2032 WP2032SL 

B2200 4 2.2 S2 04/81-05/85 WP1028 

B2200 4 2.2 R2 07/85-04/96 WP1018 

B2500 4 2.5 05/96-11/98 WP4059 

B2600 4 2.6 4G54 05/87-12/92 WP1009 WP1009SL 

B2600 4 2.6 G6 12/92-02/06 WP3123 

E1400 4 1.4 UC/D4 03/84-12/85 WP2051 

E1600 4 1.6 NA 06/79-04/84 WP824 

E1800 4 1.8 F8 04/84-02/88 WP893 WP893SL 22mm wide belt 

round tooth 

E1800 4 1.8 F8 02/88-05/97 WP2032 WP2032SL 

E2000 4 2.0 FE 01/85-04/87 WP895 WP895SL 19mm wide belt 

square tooth 

E2000 4 2.0 FE 04/87-02/03 WP2032 WP2032SL 

E2000 4WD 4 2.0 FE 01/85-04/87 WP893 WP893SL 22mm wide belt 

round tooth 

E2200 4 2.2 R2 06/84-05/97 WP1018 

E2200 4 2.2 S2 07/81-04/84 WP1028 

AWD WAGON 6 3.0 03/01-12/05 WP8183SL 

MARK 1, 2 4 1.1, 1.3, 1.6 05/70-03/81 WP730 

MARK 2 4 2.0 10/75-03/81 WP746 

US, UT 6 4.0 10/96-02/03 WP4103 WP4103SL 

F100 6 4.1 01/70-12/77 WP800 

F100 6 4.1 01/78-09/85 WP804 WP804SL With air conditioner 

F100 6 4.1 01/78-09/85 WP805 WP805SL Without air 

conditioner 

F100 8 4.9 07/74-12/77 WP809 WP809SL 

F100 8 5.8 01/78-09/85 WP809 WP809SL 

F100, 150 8 4.9 09/85-12/90 WP2953 Cast iron 

F100, 150 8 4.9 09/85-12/90 WP3069 Alloy 

F150 8 5.8 01/90-12/92 WP3069 

XL/XLT 8 7.3 07/01-12/02 WP8186SL 

AU 6 4.0 02/99-05/03 WP3079 

AU, TL50 8 5.0 02/99-05/03 WP4002 

BA 6 4.0 11/03-12/05 WP2079 

BA 8 5.4 05/03-12/05 WP8208SL 

Page



(LITRES) 


FALCON 


PART NO 

SILVERLINE 

PART NO 

NA, NC 6 3.9, 4.0 06/88-03/95 WP1040 WP1040SL 

NC, NF, NL 8 5.0 07/91-02/99 WP3070 

COMMENTS 

NF, NL 6 4.0 03/95-02/99 WP3079 WP3079SL Pulley may be 

required (EP009) 

use OE bolt to fit 

NF, NL 6 4.0 03/95-02/99 WP3079PSL 

ZA, ZB, ZC 6 3.3, 3.6 03/67-10/70 WP564 

ZA, ZB, ZC, ZD 8 4.8, 5.0, 5.8 03/67-03/72 WP807 With RH side outlet 

ZC, ZD, ZF, ZG, 

ZH, ZJ, ZK 

ZC, ZD, ZF, ZG, 

ZH, ZJ, ZK 

8 4.9, 5.8 07/69-09/84 WP809 WP809SL 

8 4.9, 5.8 07/69-09/84 WP809C 

ZD, ZF 6 4.1 11/70-04/76 WP800 

ZG 6 4.1 11/73-04/76 WP800 Without air 

conditioner 

ZG 6 4.1 11/73-04/76 WP805 WP805SL With air conditioner 

ZJ 6 4.1 12/80-02/82 WP804SL 

ZJ 6 4.1 06/80-12/80 WP805 WP805SL 

ZK, ZL 6 4.1 03/82-05/88 WP804 WP804SL 

AU 6 4.0 09/98-10/02 WP3079 WP3079SL 

AU, TE50, TS50 8 4.9, 5.6 09/98-12/02 WP4002 

BA 6 4.0 10/02-11/03 WP3079 WP3079SL 

BA 6 4.0 11/03-12/05 WP2079 

BA 8 5.4 10/02-12/05 WP8208SL 

EA, EB, ED 6 3.2, 3.9, 4.0 03/88-07/94 WP1040 WP1040SL 

EB, ED, EF, EL 8 5.0 08/91-09/98 WP3070 

EF, EL, AU 6 4.0 08/94-10/02 WP3079PSL 

EF, EL, AU 6 4.0 08/94-12/05 WP3079 WP3079SL Pulley may be 



XB 6 3.3, 4.1 11/73-07/76 WP800 Without air 

conditioner 

XB 6 3.3, 4.1 11/73-02/79 WP805 WP805SL With air conditioner 

XC 6 3.3, 4.1 Iron 08/76-02/79 WP804 WP804SL With air conditioner 

XC 6 3.3, 4.1 11/73-02/79 WP805 WP805SL Without air 

conditioner 

XD 6 3.3, 4.1 12/80-02/82 WP804 WP804SL 

XD 6 3.3, 4.1 03/79-12/80 WP805 WP805SL 

XE, XF 6 3.3, 4.1 03/82-03/93 WP804 WP804SL 

XG UTE/VAN 6 4.0 04/93-03/96 WP3079 WP3079SL May fit some late 

models 

XG UTE/VAN 6 4.0 04/93-03/96 WP1040 WP1040SL 

XH UTE/VAN 6 4.0 04/96-06/99 WP3079 WP3079SL Pulley may be 



XH UTE/VAN 8 4.9 04/96-06/99 WP3070 

XM, XP, XR, XT, 

XW 

6 2.8, 2.8, 3.1, 

3.3, 3.6 

02/64-10/70 WP564 

XR, XT, XW 8 4.8, 5.0, 5.8 WINDSOR 09/66-02/72 WP807 With RH side outlet 

XW, XY 8 5.0 WINDSOR 06/69-02/72 WP2953 With LH side outlet 

XW, XY, XA, XB, 

XC, XD, XE 

8 4.9, 5.8 CLEVELAND 06/69-09/84 WP809 WP809SL 

XY, XA 6 3.3, 4.1 11/70-10/73 WP800 

Page 10



(LITRES) 


FESTIVA 

FOCUS 

KA 

LASER 

LTD 

MAVERICK 

METEOR 

MONDEO 

PROBE 

RAIDER 

SPECTRON 

WA, WB, WBII, 

WF 

LR SEDAN/ 

HATCH 


PART NO 

SILVERLINE 

PART NO 

4 1.3, 1.5 10/91-12/00 WP1020 WP1020SL 

4 1.8, 2.0 11/02-12/05 WP8181SL 

2 DOOR HATCH 4 1.3 10/99-12/05 WP8255SL 

KA, KB, KC, KE 4 1.3, 1.5 12/82-09/87 WP817 WP817SL 

KC, KE, KEII, 

KF, KH 

4 1.6, 1.8 B6, BP SOHC 03/90-10/94 WP1020 WP1020SL 

KE 4 1.6 B6T TURBO 10/87-02/90 WP3010 

KF, KH 4 1.8 DOHC inc 

Turbo 

03/90-10/94 WP3010 

KF, KH 4 1.8 BP DOHC 03/90-10/94 WP3081 

KJ, KJII, KJIII 4 1.6, 1.8 B6, BP 10/94-01/99 WP4115 

KN, KQ 4 1.8 FP 02/99-10/02 WP3082 WP3082SL 

KN, KQ 4 1.6 B6, BP 02/99-10/02 WP4112SL 

AU 6 4.0 07/99-05/03 WP3079 WP3079SL 

AU 8 5.0 07/99-05/03 WP4002 

DA, DC 6 3.9, 4.0 06/88-03/95 WP1040 WP1040SL 

DC, DF, DL 8 5.0 04/92-07/99 WP3070 

COMMENTS 

DF, DL 6 4.0 03/95-07/99 WP3079 WP3079SL Pulley may be 



DF, DL, AU 6 4.0 03/95-05/03 WP3079PSL 

FC, FD 8 4.9, 5.8 CLEVELAND 07/73-03/83 WP809 WP809SL 

FC, FD, FE 6 4.1 06/80-05/88 WP804 WP804SL 

DA 6 4.2 TD42 02/88-09/93 WP6056 WP6056SL 

DA 6 4.2 TB42E, TB42S 02/88-09/93 WP5010 

GA, GB 4 1.5 04/82-09/85 WP817 WP817SL 

GC 4 1.6 10/85-10/87 WP1020 WP1020SL 

HA, HB, HC, 

HD, HE 

HE V6 ST24 

SEDAN 

4 2.0 07/95-12/00 WP2990 Check sample (not 

small round type) 

6 2.5 02/00-12/00 WP8202SL 

ST, SU, SV 6 2.5 KL 07/94-01/98 WP3076 Stepped flange 

p.c.d. 55mm 

4WD 4 2.6 G6 08/91-07/97 WP3123 

VAN 4 1.6 NA 01/83-05/84 WP824 

VAN 4 1.8 F8 05/84-12/84 WP895 WP895SL 19mm wide belt 

square tooth 

VAN 4 1.8 F8 12/84-12/86 WP893 WP893SL 22mm wide belt 

round tooth 

Page 11



(LITRES) 


TAURUS 

TELSTAR 

TRADER 

TRANSIT 


PART NO 

SILVERLINE 

PART NO 

COMMENTS 

VAN 2WD 4 2.0 FE 03/86-04/87 WP893 WP893SL 22mm wide belt 

round tooth 

VAN 2WD 4 2.0 FE 04/87-04/90 WP2032 WP2032SL 

GHIA 6 3.0 02/96-09/98 WP8184SL 

AR 4 2.0 FE 05/83-06/84 WP895 WP895SL 19mm wide belt 

square tooth 

AR, AS 4 2.0 FE, FE-T 05/83-09/87 WP893 WP893SL 22mm wide belt 

round tooth 

AT, AV 4 2.0, 2.2 FE, F2 10/87-12/91 WP2032 WP2032SL 

AX, AY 4 2.0 FS 01/92-11/96 WP3082 

AX, AY 6 2.5 KL 01/92-11/96 WP3075 Flat flange p.c.d. 

50mm 

AX, AY 6 2.5 KL 01/92-11/96 WP3076 Stepped flange 

p.c.d. 55mm 

0409 4 2.0 VA 06/79-12/81 WP2014 WP2014SL 

0409, 0509 4 3.0 HA 07/79-12/84 WP1150 WP1150SL 

0409, 0509, 

0812 

4 3.5 SL, SLT 05/84-09/95 WP3013 

VF, VG 4 2.0 05/96-11/00 WP4498SL 

VF, VG, VH, VJ 4 2.4, 2.5 05/96-12/05 WP2565 

Holden 

ADVENTRA 

APOLLO 

ASTRA 

BARINA 

CALIBRA 

4WD WAGON 8 5.7 09/03-12/05 WP4013SL 

JK, JL, JM 4 2.0, 2.2 3SFC, 3SFE, 

5SFE 

08/89-05/97 WP3047 WP3047SL 

JM-JP 6 3.0 3VZFE 02/93-05/97 WP3040 

AH 4 1.8 Z18XE, 

XZ18XE 

09/98-12/06 WP4042 WP4042SL 

LB, LC 4 1.5, 1.6 E15, E16S 08/84-07/87 WP888 WP888SL 

LD 4 1.6, 1.8 16LE, 18LE 07/87-07/89 WP2512 WP2512SL With dust shield 

under hub 

TR 4 1.6, 2.0 C16SE, 

C20SED 

09/96-08/98 WP2800SL 

TS & SRI 4 2.2 10/01-12/05 WP8259SL 

MB, ML 4 1.3 G13A 02/85-01/89 WP2008 With pitch circle 

diameter 40mm 

MF, MH 4 1.3 G13A 01/89-04/94 WP3037 WP3037SL 

ML 4 1.3 09/86-01/89 WP3037 WP3037SL Automatic 

transmission 

SB 4 1.2, 1.4 C12NZ 04/94-04/01 WP3071 WP3071SL 

SB 4 1.6 04/94-09/98 WP3072SL 

XC, XC-SRI 4 1.4 C14XE 04/01-12/05 WP3072SL 

YE 4 2.0 LE4 10/91-07/95 WP2512 WP2512SL With dust shield 

under hub 

YE95 4 2.0 8YE77, 8YE77T 08/95-07/98 WP2800SL 

Page 12



(LITRES) 

Holden (continued) 

CAMIRA 

COMBO VAN 

COMMODORE 

CREWMAN 

DROVER 

FRONTERA 

GEMINI 


PART NO 

SILVERLINE 

PART NO 

YE95 6 2.5 08/95-07/98 WP8111SL 

COMMENTS 

JB, JD 4 1.6, 1.8 L16, LJ9, LV6 08/82-04/87 WP2189 WP2189SL Without dust shield 

JE 4 2.0 LE4 04/87-08/89 WP2512 WP2512SL With dust shield 

under hub 

SB 4 1.4 03/96-08/02 WP3071 WP3071SL 

VB 6 2.8, 3.3 11/78-02/80 WP814 WP814SL Long shaft 20mm 

from top of hub face 

VB, VC 6 2.8, 3.3 11/78-09/81 WP726 WP726SL Short shaft 10mm 


VB, VC 8 4.2, 5.0 11/78-09/81 WP808 WP808SL 

VC 4 1.9 03/80-09/81 WP814 WP814SL 

VC 6 2.8, 3.3 03/80-09/81 WP814 WP814SL Long shaft 20mm 


VH 8 4.2, 5.0 10/81-02/84 WP808 WP808SL Mounting face to 

pulley face 94mm 

overall height 

VH, VK 4,6 1.9, 2.8, 3.3 10/81-02/86 WP815 WP815SL 

VH, VK, VL, VN, 

VP, VR, VS, VT 

8 4.2, 5.0, 5.7 10/81-06/99 WP1000 WP1000SL Mounting face to 



VL 6 3.0 RB30E 03/86-07/88 WP898 WP898SL 

VN, VG 6 3.8 01/91-10/91 WP3000 WP3000SL Timing cover cast 

No 25534687 

VN, VG 6 3.8 08/88-12/90 WP1039 WP1039SL Timing cover 

cast No 

25532382/25533496 

VN, VG 6 3.8 08/88-10/91 WP1039MF Multi fit design 

VP 6 3.8 11/91-06/93 WP3000 WP3000SL Timing cover cast 

No 25534909 

VR 6 3.8 07/93-04/95 WP3000 WP3000SL To engine No 

VH1414581 

VR 6 3.8 07/93-04/95 WP4000 WP4000SL From engine No 

VH1414582 on 

VS 6 3.8 05/95-12/00 WP4000 WP4000SL To engine No 

VH515478 

VS 6 3.8 05/95-12/00 WP4001 WP4001SL From engine No 

VH515479 on 

VT, VX, VY 6 3.8 09/97-08/04 WP4001 WP4001SL 

VT, VX, VY, VZ 8 5.7 GEN3 06/99-12/05 WP4013SL 

8 5.7 GEN3 08/03-12/05 WP4013SL 

DROVER 4 1.3 G13A 03/85-12/87 WP2008 With pitch circle 

diameter 40mm 

2D WAGON 4 2.0 LE4 10/95-12/98 WP2800SL 

MX 6 3.2 6VD1 02/99-12/05 WP3112 

MX 6 3.2 6VD1 02/99-12/05 WP4113 

RB 4 1.5 4CX1 05/85-07/87 WP5019 

TE, TF, TG 4 1.8 4FB1 10/79-06/85 WP5014 WP5014SL 

TX, TC, TD, TE, 

TF, TG 

4 1.6 G161Z 03/75-06/85 WP827 WP827SL 

Page 13



(LITRES) 


JACKAROO 

MONARO 

NOVA 

RODEO 

EH, HD, HR 6 2.4, 2.6, 2.9, 

3.0 


PART NO 

SILVERLINE 

PART NO 

08/63-02/68 WP587 WP587SL 

HK, HT 8 5.0 307ci Chev 02/68-08/70 WP2593 

HT 6 2.6, 3.0 05/69-08/70 WP726 WP726SL 

HT 8 4.2, 5.0 05/69-08/70 WP808 WP808SL 

COMMENTS 

HT 8 5.7 05/69-08/70 WP812 Deck height 176mm 

HG 6 2.6, 3.0 08/70-06/71 WP726 WP726SL 

HG 8 4.2, 5.0 08/70-06/71 WP808 WP808SL 

HJ 6 2.8, 3.3 10/74-06/76 WP814 WP814SL Long shaft 20mm 


HJ 6 2.8, 3.3 10/74-06/76 WP726 WP726SL Short shaft 10mm 


HQ 6 2.6, 3.3 07/71-09/74 WP726 WP726SL 

HQ 8 5.7 08/70-09/74 WP812 Deck height 176mm 

HQ, HJ, HZ, HZ 8 4.2, 5.0 07/71-12/80 WP808 WP808SL 

HX, HZ 6 3.3 07/76-12/80 WP814 WP814SL Without air 

conditioner 

HX, HZ, WB 8 4.2, 5.0 07/76-12/85 WP1000 WP1000SL Mounting face to 



HZ 6 3.3 07/76-12/80 WP726 WP726SL With air conditioner 

WB 8 4.2, 5.0 04/80-12/85 WP808 WP808SL Mounting face to 



WB UTE/VAN 6 3.3 04/80-12/85 WP726 WP726SL 80mm overall height 

mounting face to 

pulley front 

WB UTE/VAN 6 3.3 04/80-12/85 WP815 WP815SL 100mm overall 

height mounting 

face to pulley front 

UBS13 4 1.9 G200Z 11/81-07/85 WP827 WP827SL 

UBS16 4 2.3 4ZD1 08/85-12/87 WP1022 

UBS17 4 2.6 4ZE1 01/88-04/92 WP6380 WP6380SL 

UBS25 6 3.2 6VD1S 05/92-01/98 WP3112 

UBS26, 73 6 3.5 6VE1 02/98-12/05 WP4113 

UBS26, 74 4 3.0 4JX1 02/98-12/05 WP8263SL 

UBS52, 16 4 2.2 C223, C223T 12/81-12/87 WP5013 Diesel 

UBS55, 69 4 2.8, 3.1 4JBI-T, 

4JG2TC 

02/88-12/97 WP1100 Diesel inc Turbo 

CV6/8 GTO/S 6 3.8 12/01-12/05 WP4001 WP4001SL 

CV6/8 GTO/S 8 5.7 12/01-12/05 WP4013SL 

LE, LF 4 1.4, 1.6 4AFC, 4AFE, 

6AFC 

LF, LG 4 1.8 09/91-06/97 WP3083 

LG 4 1.6 4AFE 10/94-06/97 WP3084 

KB29/44/49, 

TFR16, 17, 54, 

55, R7 

4 1.6, 1.8, 2.0 G161Z, G180Z, 

G200Z 

08/89-09/94 WP3039 WP3039SL 2 x O-rings required 

not supplied - 

source OE 

01/78-06/88 WP827 WP827SL 

4 2.3 4ZD1 03/87-03/93 WP1022 

KBD26 4 2.0 C190 01/81-12/82 WP864 Diesel 

Page 14



(LITRES) 


SCURRY 

SHUTTLE 

STATESMAN 

SUNBIRD 

TORANA 

VECTRA 

ZAFIRA 


PART NO 

SILVERLINE 

PART NO 

4 2.2 C223 01/83-06/88 WP5013 Diesel 

RA, R9 6 3.5 6VE1 02/98-12/05 WP4113 

TFR16/17/54/55, 

R7 

TFR16/17/54/55, 

R7 

4 2.6 4ZE1 06/88-06/98 WP6380 WP6380SL 

4 2.5, 2.5 4JA1, 4JB1-T 06/88-07/99 WP1100 Diesel 

WAGON/VAN 4 1.0 F10A 07/85-01/87 WP2003 

WAGON/VAN 4 1.0 F10A 07/85-01/87 WP2011 

VAN 4 1.9 4ZC1 09/83-12/91 WP3048 

WFR11-51 4 1.8 4ZB1 03/82-03/87 WP5023 

WFR11-51 4 2.0 4FC1 03/82-03/87 WP5020 

COMMENTS 

VQ 6 3.8 03/90-03/94 WP3000 WP3000SL Timing cover cast 

No 25534909 


VH1414581 


VH1414582 on 


VH515478 


VH515479 on 

WB 8 5.0 04/80-12/85 WP808 WP808SL Mounting face to 



WB-VS 8 5.0 04/80-06/99 WP1000 WP1000SL Mounting face to 



WH, WK 6 3.8 06/99-12/05 WP4001 WP4001SL 

WH, WK 8 5.7 06/99-12/05 WP4013SL 

LX, UC 4 1.9 11/76-09/78 WP555 

UC 4 1.9 09/78-12/80 WP814 WP814SL 

LC, LJ 6 2.3, 2.6, 2.8 01/70-03/74 WP726 WP726SL 

LC, LJ, TA 4 1.2, 1.3 01/70-03/75 WP786 

LH, LX 4 1.9 03/74-02/78 WP555 

LH, LX 8 4.2, 5.0 03/74-02/78 WP808 WP808SL 

LH, LX, UC 6 2.8, 3.3 03/74-09/79 WP814 WP814SL Long shaft 20mm 


LH, LX, UC 6 2.8, 3.3 03/74-09/79 WP726 WP726SL Short shaft 10mm 


LX 6 2.8, 3.3 03/76-02/78 WP726 WP726SL Short shaft 10mm 


JR, JS 4,6 2.0, 2.2, 2.5, 

2.6 

C20SEL, 

Z22SE, X25XE, 

Y26SE 

06/97-12/05 WP8112SL 

ZC SERIES 6 3.2 Z32SE 03/03-12/05 WP8111SL 

ZC SERIES 4 2.2 Z22SE 03/03-12/05 WP8259SL 

TT 4D WAGON 4 2.2 Z22SE 06/01-12/05 WP8259SL 

Page 15


Honda 


(LITRES) 

ACCORD 

CITY 

CIVIC 


PART NO 

AD 4 1.8 ET 01/84-01/86 WP818 

CA 4 2.0 A20A, A20A4 01/86-11/89 WP2007 

CA, CB, CD 4 2.2, 2.3 F22A1, F22B3, 

F22B1, F23A1 

11/89-08/03 WP3016 

SILVERLINE 

PART NO 

COMMENTS 

SJ 4 1.6 EF, EG 03/77-01/79 WP854 Most models 

SJ, SV, SY 4 1.6 EF, EG, EL 03/77-01/84 WP1854 Small hub 35mm to 

engine No 1200000 

SJ, SV, SY 4 1.6 EF, EG, EL 03/77-01/84 WP855 Large hub 45mm 


on 

VTI/V6/V6-L 6 3.0 J30A1, J30A4 12/97-12/06 WP8159SL 

3D VAN 4 1.2 01/84-06/86 WP907 

CXI/GLI/VTI/ 

VTI-R 

CXI/GLI/VTI/ 

VTI-R 

4 1.5 EW Carb 12V 01/84-11/87 WP1120 

4 1.6 D16Y4 10/95-11/00 WP4114 

4 1.6 B16A2 VTEC 10/95-11/00 WP4109SL 

GLI & VI(VTEC) 4 1.7 11/00-12/05 WP8161SL 

4 1.2 EB1 01/74-12/79 WP1008WP 

4 1.3 EJ 01/74-12/83 WP907 

4 1.2 EB2 01/78-12/80 WP828 

4 1.3 EN 01/74-12/83 WP843 

4 1.3, 1.5, 1.6 D13A, D15B, 

D15B7, D16A8 

16V 

01/84-09/95 WP1130 

CONCERTO 

CR-V 

HR-V 

INTEGRA 

JAZZ 

LEGEND 

ODYSSEY 

4 1.5, 1.6 D15Z1, D15Z2, 

D16A8, D16Y1 

10/91-09/95 WP1132 WP1132SL 

HATCHBACK 4 1.6 D16Z2 11/88-01/93 WP1130 

4X4 WAGON 4 2.0 B20B3 10/97-12/01 WP4003 

4X4 WAGON 4 2.4 K24A1 12/01-12/05 WP8162SL 

COUPE 4 1.6 D16A8 11/87-05/92 WP1130 

4WD SPORT/ 

HARDTOP 

4 1.6 D161W1 01/99-07/02 WP4114 

2.0/TYPE R 4 2.0 K20A3 09/00-12/05 WP8162SL 

GSI/VTI-R/LS 4 1.8 B18A, B18B2 06/89-07/01 WP3018 

SX 4 1.6 D16A8 01/86-05/89 WP3017 

4D HATCH 4 1.3, 1.5 10/02-12/05 WP8164SL 

KA3, 4, HS 6 2.5, 2.7 C25, C27 01/86-03/91 WP2025 

KA7, 8 6 3.2 CA32A 04/91-04/96 WP3063 WP3063SL 

5 DR WAGON 6 3.0 J30A1 04/00-12/05 WP8159SL 

5 DR WAGON 4 2.2 F22A1, F22B3, 

F22B1, F23A1 

06/95-12/97 WP3016 

Page 16



(LITRES) 

Honda (continued) 

PRELUDE 

Hyundai 

ACCENT 

COUPE 

ELANTRA 

EXCEL 

GETZ 

GRANDEUR 

LANTRA 

SANTA FE 

SONATA 

TERRACAN 

TIBURON 

TRAJET 


PART NO 

AB 4 1.8 ET 01/83-12/85 WP818 

AB 4 2.0 A20A4 01/86-10/87 WP2007 

BA 4 2.0 B20A5 10/87-12/91 WP3019 

S, SI 4 2.2 F22A1, F22B3 12/91-12/94 WP3016 

S, SI 4 2.3 H23A1 12/91-12/94 WP3087 

SILVERLINE 

PART NO 

SI/VTI-R 4 2.2 H22A1, H22A4 02/94-07/02 WP8155SL 

COMMENTS 

SN 4 1.6 EL 05/79-12/82 WP1854 Small hub 35mm to 


SN 4 1.6 EL 05/79-12/82 WP855 Large hub 45mm 


on 

SEDAN/HATCH 4 1.5 G4ECX 06/00-03/03 WP4040SL 

S/LS/GLS/ 

TURBO 

4 1.5 G4DJ, TURBO 07/90-07/96 WP877 WP877SL 

SFX/SX/FX 4 1.8, 2.0 07/96-12/00 WP4043 WP4043SL 

XD SEDAN/ 

HATCH 

4 1.8, 2.0 10/00-12/05 WP4043 

X1, X2, X3 4 1.5 G4AJ, G4DJ, 

G4EK 

02/86-04/98 WP877 WP877SL 

X3 4 1.5 G4FK 01/98-06/00 WP4040SL 

HATCH 4 1.5 G4ECX 10/02-12/05 WP4106 

4 DOOR SEDAN 6 3.0 09/99-12/05 WP4105 WP4105SL 

GL/GLS 4 1.6 05/91-10/92 WP3020 

GL/GLS 4 1.8 G4CN 10/92-08/95 WP1133 

SE/GL/GLS 4 1.8, 2.0 08/95-10/00 WP4043 WP4043SL 

GL/GLS 4,6 2.4, 2.7 G6BA 12/00-12/05 WP4104 

EF SERIES 4 2.0 04/98-03/00 WP4104 

EF-B SERIES 6 2.5, 2.7 G6BA 04/98-12/05 WP8175SL 

GL/GLS 4 2.4 G4CS 03/89-10/93 WP1027 

GLS/E/LEVANT 4 2.0 10/93-08/98 WP1133 

6 3.0 6G72 04/90-08/98 WP2040 WP2040SL With spring loaded 

tensioner: without 

backing plate 

6 3.0 6G72 04/90-08/98 WP3114 O-ring not supplied. 

Please source OEM 

with backing plate 

4WD WAGON 6 3.5 G6CU 11/01-12/05 WP8176SL 

2D LIFTBACK 4,6 2.0, 2.7 G6BA 03/02-12/05 WP8175SL 

GL/GLS 4D 

WAGON 

6 2.7 G6BA 07/00-12/05 WP8175SL 

Page 17


Isuzu 


(LITRES) 

N SERIES 

Jaguar 

XJ6 

Jeep 

CHEROKEE 

GRAND 

CHEROKEE 

WRANGLER 

Kia 

CARENS 

CARNIVAL 

CERES 

MENTOR 

OPTIMA 

PREGIO 

RIO 

SHUMA 

SORENTO 

SPECTRA 


PART NO 

NKR 57 4 3.3 4BC2 01/85-11/87 WP3002 

4.2 SER 1&2 6 4.2 01/76-08/79 WP840 

4.2 SER 3 6 4.2 01/81-03/87 WP880 

4.2 SER 3 6 4.2 08/79-12/80 WP840 

SILVERLINE 

PART NO 

KJ SPORT/LTD 6 3.7 PB 09/01-12/05 WP8109SL 

6 4.0 VL, MX 04/94-09/01 WP3133 WP3133SL 

WJ, WG SERIES 6 4.0 07/99-12/05 WP4101 

WJ, WG SERIES 8 4.7 07/99-12/05 WP8109SL 

ZG SERIES 6 4.0 MX 04/96-07/99 WP4100 

SPORT/ 

RENEGADE 

SPORT/ 

RENEGADE 

6 4.0 02/00-12/05 WP4101 

6 4.0 MX 10/96-01/00 WP4100 

4D WAGON 4 1.8 07/00-12/01 WP8192SL 

4 DOOR 

WAGON 

TRAY, C/ 

CHASSIS 

TRAY, C/ 

CHASSIS 

5 DR 

HATCHBACK 

HATCHBACK/ 

SEDAN 

HATCHBACK/ 

SEDAN 

6 2.5 09/99-12/05 WP8196SL 

4 2.4 02/97-05/00 WP1028 

4 2.4 02/97-05/00 WP1028 

4 1.5 12/96-03/98 WP1020 WP1020SL 

4 1.5 04/98-06/00 WP3010 

4 1.5, 1.8 04/98-06/00 WP4004 

4D SEDAN 6 2.5 05/01-02/03 WP8175SL 

VAN 4 2.7 J2 07/02-12/05 WP8194SL 

4D HATCH/ 

SEDAN 

4 1.5 07/00-12/05 WP8193SL 

5DR HATCH 4 1.8 01/00-04/01 WP8192SL 

4WD WAGON 6 3.5 G6CU 02/03-12/05 WP8176SL 

4D HATCH 4 1.8 05/01-12/05 WP8192SL 

COMMENTS 

Page 18


Lada 

NIVA 


(LITRES) 

Land Rover / Rover 

DEFENDER 

DISCOVERY 

FREELANDER 

RANGE ROVER 


PART NO 

2DCAB/WAGON 4 1.6 07/83-09/92 WP972 

SILVERLINE 

PART NO 

WAGON 5 2.5 02/99-12/05 WP8230SL 

WAGON 4 2.5 TURBO 

DIESEL 

03/92-03/99 WP8199SL 

WAGON 5 2.5 02/99-12/05 WP8230SL 

WAGON 8 3.5, 3.9 37D, 38D 04/91-01/99 WP2614 WP2614SL 

WAGON 4 2.5 TURBO 

DIESEL 

3 & 5 DR 

WAGON 

LAND ROVER SER.111 

LAND ROVER SER.11A 

Lexus 

ES300 

IS200 

LS400 

LS430 

LX470 

Mazda 

323 

626 

4 1.8, 2.0 TURBO 

DIESEL 

04/91-01/99 WP8199SL 

03/98-10/00 WP8182SL 

WAGON 8 3.9 37D, 38D 02/89-04/95 WP2614 WP2614SL 

88IN/109IN 4 2.3 05/72-12/83 WP216 WP216SL 

88IN/109IN 4 2.3 01/61-04/72 WP216 WP216SL 

4 DOOR SEDAN 6 3.0 3VZFE 06/92-10/96 WP3040 

4 DOOR SEDAN 6 3.0 1MZ-FE 10/96-12/05 WP9092SL 

GXE10R SEDAN 6 2.0 1G-FE 03/99-12/05 WP8148SL 

UCF10/20R 

SEDAN 

8 4.0 1UZ-FE 05/90-11/00 WP8143SL 

UCF30R SEDAN 8 4.3 3UZ-FE 12/00-12/05 WP8143SL 

4X4 WAGON 8 4.7 2UZ-FE 05/98-12/05 WP8143SL 

COMMENTS 

ASTINA 6 2.0 KF 08/94-09/98 WP3076 Stepped flange 

p.c.d. 55mm 

R.W.D 4 1.3, 1.4, 1.5 D4, D5, TC, UC 03/77-09/85 WP2051 

SERIES 1&2 4 1.6 B6T TURBO 10/87-10/89 WP3081 

4 2.0 FS 02/01-12/05 WP3082 WP3082SL 

4 1.6, 1.8 BP, B6 DOHC 

16V 

08/94-09/98 WP3081 

4 1.6 B6 09/98-06/02 WP4112SL 

4 1.8 FP 09/98-12/05 WP3082 WP3082SL 

4 1.3, 1.5 E3, E5 10/80-10/85 WP817 WP817SL 

4 1.6, 1.8 B6, BP SOHC 10/85-05/96 WP1020 WP1020SL 

4 1.6, 1.8 BP, B6T DOHC 10/87-08/94 WP3010 

CB2 RWD 4 2.0 MA 12/78-02/83 WP756 

GC SERIES 4 2.0 FE, FE-T 02/83-10/87 WP893 WP893SL 22mm wide belt 

round tooth 

Page 19


Page 20 


(LITRES) 

Mazda (continued) 

808 

929 

1300 

121 LATE 

1600(CAPELLA) 

B SERIES 

E SERIES 

EUNOS 


PART NO 

SILVERLINE 

PART NO 

COMMENTS 

GC SERIES 4 2.0 FE 02/83-12/84 WP895 WP895SL 19mm wide belt 

square tooth 

GD, GE 4 2.2 F2, TURBO 10/87-08/97 WP2032 WP2032SL 

GE SERIES 6 2.5 KL 01/92-08/97 WP3075 Flat flange p.c.d. 

50mm 

GE SERIES 6 2.5 KL 01/92-08/97 WP3076 Stepped flange 

p.c.d. 55mm 

GE, GF 4 2.0 FS 01/92-08/02 WP3082 

SAVANNA 808 4 1.3 TC 03/72-06/77 WP2051 

HBES 4 2.0 FE-FE-T 02/84-06/87 WP893 WP893SL 22mm wide belt 

round tooth 

HBES 4 2.0 FE 02/84-07/86 WP893 WP893SL Where fitted with 

round tooth timing 

belt 

HBES 4 2.0 FE 02/84-07/86 WP895 WP895SL Where fitted with 

square tooth timing 

belt 

HC V6 SOHC 6 3.0 JE 03/87-07/91 WP3015 

LA2-LA4/HB 4 1.8 VC 01/74-06/78 WP824 

LA2-LA4/HB 4 2.0 MA 06/78-06/87 WP756 

1300 4 1.3 TC 07/70-02/77 WP2051 

4 1.3, 1.5 B3, M1 01/87-12/02 WP1020 WP1020SL 

CAPELLA 4 1.6 NA 10/70-12/78 WP824 

B1600, B1800 4 1.6, 1.8 NA, VC 01/71-12/82 WP824 


round tooth 


square tooth 

B2000 4 2.0 MA 12/82-05/85 WP756 

B2200 4 2.2 S2 01/81-05/85 WP1028 

B2200 4 2.0, 2.2 FE, F2 01/87-02/93 WP2032 WP2032SL 

B2200 4 2.2 R2 DIESEL 06/85-04/96 WP1018 

B2600 (4X4) 4 2.6 4G54 03/87-10/91 WP1009 WP1009SL 

BRAVO B2500 4 2.5 04/96-11/98 WP4059 

BRAVO B2600 4 2.6 G6 12/91-12/05 WP3123 

E1300, E1400 4 1.3, 1.4 TC, UC, D4 01/71-12/83 WP2051 

E1400 4 1.5 D5 01/84-07/86 WP817SL 

E1600 4 1.6 NA 01/79-12/83 WP824 

E1800, E2000 4 1.8, 2.0 F8, FE 04/87-12/05 WP2032 WP2032SL 

E1800, E2000 4 1.8, 2.0 F8, FE 12/84-04/87 WP893 WP893SL 22mm wide belt 

round tooth 

E1800, E2000 4 1.8, 2.0 F8, FE 02/84-12/84 WP895 WP895SL 19mm wide belt 

square tooth 

E2200 4 2.2 S2 03/80-12/83 WP1028 

E2200 4 2.2 R2 04/84-08/97 WP1018 

500 6 2.0 KF 11/92-09/99 WP3075 Flat flange p.c.d. 

50mm



(LITRES) 

Mazda (continued) 

MAZDA2 

MPV WAGON 

MX-5 

MX-6 

RX7 

T SERIES 

TRIBUTE 

Mercedes 

100 SERIES 

200 SERIES 


PART NO 

SILVERLINE 

PART NO 

COMMENTS 

500 6 2.0 KF 11/92-09/99 WP3076 Stepped flange 

p.c.d. 55mm 

30X 6 1.8 K8 11/92-10/97 WP3075 Flat flange p.c.d. 

50mm 

30X 6 1.8 K8 11/92-10/97 WP3076 Stepped flange 

p.c.d. 55mm 

4D HATCHBACK 4 1.5 12/02-12/05 WP8262SL 

RWD 3.0L 6 3.0 JE 09/93-10/95 WP3015 OEM No: 

8AH3-15-010A/B/C 

6 2.5, 3.0 GY 09/99-12/05 WP8183SL 

MX-5 4 1.6 B6 10/89-11/93 WP3010 

MX-5 4 1.8 BP 11/93-03/98 WP3081 

MX-6 4 2.2 F2 10/87-10/91 WP2032 WP2032SL 

MX-6 6 2.5 KL 11/91-09/97 WP3075 Flat flange p.c.d. 

50mm 

MX-6 6 2.5 KL 11/91-09/97 WP3076 Stepped flange 

p.c.d. 55mm 

RX7 1.1, 1.3 12A, 13B 03/79-02/92 WP851 

T2000 4 2.0 VA 05/81-12/82 WP2014 WP2014SL 

T2600 4 2.6 4G54 04/85-12/88 WP1009 WP1009SL 

T3000 4 3.0 HA 06/81-10/84 WP1150 WP1150SL 

T3500 4 3.5 SL, SL-T 05/85-04/97 WP3013 

AWD WAGON 6 3.0 03/01-12/05 WP8183SL 

180E, C180 4 1.8 10/91-10/00 WP4035 

190D 5 2.5 01/86-12/88 WP8121SL 

190E 4 1.8, 20., 2.3 12/84-01/94 WP1408SL 

A140, A160, 

A190 

220E, C200, 

C200T, E220, 

E220T, E220CA, 

E220C 

230, 234, 230, 

236, 240D, 250, 

250C, 280C, 

280S, 280CE, 

280E, 280SL, 

280SLC, 280SE, 

280SEL 

230E, 230TE, 

230GE 

250, 280CE, 

280SE, 280TE 

4 1.4, 1.6, 1.9 M166 10/98-12/05 WP8120SL 

4 2.0, 2.2 03/93-10/00 WP4035 

4,6 2.3, 2.4, 2.7, 

2.8 

09/72-12/82 WP995 

4 2.3 01/85-02/93 WP1408SL 

6 2.5, 2.7 10/76-03/86 WP1550SL 

260E 6 2.6 08/88-03/91 WP8114SL 

Page 21



(LITRES) 


PART NO 

SILVERLINE 

PART NO 

COMMENTS 

Mercedes (continued) 

300 SERIES 

4/500 SERIES 

VITO VAN 

MG 

MGB 

MGF 

Mini 

NEW MINI 

C230, CLK200, 

SLK200, 

CLK230 

C240, C240T, 

C280, E240 

4 2.0, 2.3 11/96-12/05 WP8117SL 

6 2.4, 2.8 08/97-12/05 WP8119SL 

C250D 5 2.5 10/94-11/96 WP8121SL 

C280, E280, 

E280T, SL280 

6 2.8 10/93-04/99 WP3124SL 

300CE, E 6 3.0 02/90-02/93 WP8114SL 

300D 5 3.0 11/76-08/79 WP995 

300D, TD, GD 5 3.0 09/80-12/89 WP8121SL 

CLK230, E320, 

E320T, ML320 

6 3.2 08/97-12/05 WP8119SL 

E300D 6 3.0 09/93-10/94 WP8121SL 

ML430 8 4.3 M113 03/99-12/05 WP8119SL 

108CDI, 112CDI, 

108D 

4 2.2, 2.3 01/98-12/05 WP8121SL 

113/P PETROL 4 2.0 02/98-03/04 WP8118SL 

MK11/L 4 1.8 01/70-07/72 WP738 

2D ROADSTER 4 1.8 03/97-08/02 WP8182SL 

COOPER, 

COOPER S 

OLD MINI 850, 100, 011, 

001, 275 

Mitsubishi 

380 

CANTER 

CHALLENGER 

COLT 

CORDIA 

GALANT 

4 1.6 04/02-12/05 WP8260SL 

4 0.8, 1.0, 1.1, 

1.3 

04/61-12/78 WP3709 

SEDAN 6 3.8 10/05-12/06 WP4014SL 

FC432 4 2.6 4D54 02/84-10/92 WP2799 

FE44E, 214, 

334, 444F 

4 3.3 4D03, 4D31, 

4D31T 

01/84-12/93 WP1160 Without fan clutch 

PA 6 3.0 6G72-S4 02/98-12/05 WP4014 WP4014SL 

RA 4 1.4 4G12B 11/80-09/82 WP877 WP877SL 

RB, RC, RD, RE 4 1.4, 1.6 10/82-06/90 WP878 WP878SL 

AA, AB, AC 4 1.8 4G62B 04/83-07/89 WP1027 Turbo 

AA, AB, AC 4 1.6, 1.8 4G32, 4G37 04/83-07/89 WP878 WP878SL 

GA, GB, GC, GD 4 1.3, 1.4, 1.5, 

1.6 

4G30, 4G31, 

4G32, 4G33 

08/71-12/77 WP822 

HG, HH 4 2.0 4G63 16V 05/89-03/93 WP3060 

HG, HH 4 2.0 4G62 8V 05/89-03/93 WP3061 

HJ 4 2.0 4G63 04/93-10/96 WP3094 

Page 22



(LITRES) 

Mitsubishi (continued) 

L200 EXPRESS 

L300 EXPRESS 

LANCER 

MAGNA 

MIRAGE 

NIMBUS 

PAJERO 


PART NO 

HJ 6 2.0 6A12 04/93-10/96 WP4012 

SILVERLINE 

PART NO 

MA, MB 4 2.0 4G52 06/81-09/82 WP1009 WP1009SL 

MA, MB, MC 4 1.6 4G32 03/80-08/84 WP1014 

MC, MD 4 2.3 4D55 10/82-10/86 WP1032 WP1032SL 

MC, MD 4 2.0 4G63 10/82-10/86 WP3117 WP3117SL 

SA, SB, SC, SD, 

SE 

SB, SC, SD, SE, 

SF, SG, SH 

4 1.6 4G32 04/80-09/86 WP1014 

4 1.8, 2.0, 2.4 G62B, 4G63, 

4G64 

10/82-09/94 WP3117 WP3117SL 

SF, SG, SH, SJ 4 2.5 4D56 10/86-08/03 WP1032 WP1032SL 

COMMENTS 

SH 4 2.0 4G63 09/91-04/92 WP3117 WP3117SL 5/92 on OE No 

MD972051 not 

serviced 

SJ, WA 4 2.0, 2.4 4G63, 4G64 09/94-12/05 WP4008 

LA, LB 4 1.4, 1.6 4G32, 4G33 09/74-02/78 WP822 

LB, LC 4 1.4, 1.6 4G32, 4G33 01/78-08/81 WP1014 

CA, CB, CC 4 1.5 4G15 09/88-06/96 WP877 WP877SL 

CB 4 1.6 4G61 09/90-08/92 WP3020 

CC 4 1.6, 1.8 4G92, 4G93, 

4G93T 

09/90-12/05 WP3092 WP3092SL 

CE 4 1.8 4G93 07/96-12/05 WP3092 WP3092SL Wagon 

CE 4 1.8 4G93 07/96-12/05 WP4065 Except wagon 

CE 4 1.5 4G15 07/96-12/05 WP4108 

CG 4 2.0 4G94 07/02-08/03 WP4065 

TE, TF 4 2.4 4G64-S4 04/96-03/99 WP8187SL 

TE, TF, TH, TJ 6 3.0 6G72-S4 04/96-08/02 WP4014 OE No MD973025 

TH, TJ, TL 6 3.5 6G74-S4 03/99-12/05 WP4014 

TM, TN, TP, TR, 

-TS 

TM, TN, TP, TR, 

-TS 

4 2.6 4G54 04/85-03/96 WP1025 WP1025SL 

4 2.6 04/85-03/96 WP1025BSL With backing plate 

TR, TS 6 3.0 6G72 04/91-03/96 WP2040 WP2040SL With spring loaded 


backing plate 

CE 4 1.5 4G15 07/96-12/05 WP4108 

UA, UB 4 1.8 4G37 05/84-08/87 WP878 WP878SL 

UC 4 2.0 4G63 09/87-01/92 WP1027 

UF 4 2.4 4G64 8V 02/92-05/92 WP3061 

UF 4 2.4 4G64 8V 06/92-11/98 WP3094 

UF 4 2.4 4G64 16V 02/92-11/98 WP3094 

UG 4 2.4 4G64 11/98-12/05 WP8187SL 

IO 4 1.8, 2.0 4G93, 4G94 03/99-09/03 WP4065 

IO (QA SERIES) 4 1.6 4G18 03/99-10/01 WP4108 

NA, NB, NC, ND, 

NE, NF, NG 

4 2.3, 2.5 4D55T, 4D56T 01/83-04/91 WP1032 WP1032SL For 4 bolt 

thermostat flange 

type use WP3144 

Page 23



(LITRES) 


SCORPION 

SIGMA 

STARWAGON 

TRITON 

VALIANT 


NE, NF, NG 


NE, NF 

NF, NG, NH, NJ, 

NK 

NF, NG, NH, NJ, 

NK 


PART NO 

SILVERLINE 

PART NO 

COMMENTS 

4 2.3, 2.5 4D55T, 4D56T 01/83-12/93 WP3144 Has large 4 bolt 


parallel to pump 

body 

4 2.6 4G54 01/83-12/93 WP1009 WP1009SL 

6 3.0 6G72 08/88-09/97 WP2040 WP2040SL With spring loaded 


backing plate 

6 3.0 6G72 08/88-09/97 WP3114 With backing plate 

o-ring not supplied. 


NH 4 2.5 4D56T 05/91 WP1032 WP1032SL 

NJ, NK 6 3.5 6G74-D4 12/93-09/97 WP4007 

NJ, NK, NM, NP 4 2.8, 3.2 4M40, 4M40T, 

4M41 


NL 6 3.5 6G74-S4 09/97-06/00 WP4014 WP4014SL 

GE, GH, GJ, 

GK, GL 

4 2.0, 2.6 4G52, 4G54 03/78-09/85 WP1009 WP1009SL 

GE 4 1.6 4G32 Chain 

driven 

GE 4 1.6 4G32 Belt 

driven 

GE, GH, GJ, GK, 

GN 

4 1.9, 2.0, 2.6 4G51, 4G52, 

4G54 

10/77-02/78 WP822 

10/77-06/85 WP1014 

10/77-12/87 WP1009 WP1009SL 

SF 4 2.0 4G63 10/86-05/90 WP3117 WP3117SL 

SF, SG 4 2.0 4G63 06/90-08/91 WP3094 

SF, SG, SH 4 2.4 4G64 10/86-09/94 WP3117 WP3117SL 

SH 4 2.0 4G63 09/91-04/92 WP3117 WP3117SL 5/92 on OE No 

MD972051 not 

serviced 

SJ, WA 4 2.0, 2.4 4G63, 4G64 09/94-12/05 WP4008 

ME, MF, MG, 

MH, MJ 

ME, MF, MG, 

MH, MJ 

4 2.6 4G54 10/86-10/96 WP1009 WP1009SL 

4 2.5 4D56.4D56T 10/86-10/96 WP1032 WP1032SL Diesel inc Turbo 

MH, MJ 6 3.0 6G72 09/90-10/96 WP2040 WP2040SL With spring loaded 


backing plate 

MH, MJ 6 3.0 6G72 09/90-10/96 WP3114 With backing plate 



MH, MJ 4 2.5 4D56T 09/90-10/96 WP3144 Has large 4 bolt 


parallel to pump 

body 

MK 4 2.8 4M40 10/96-03/03 WP3115 

MK 4 2.4 4G64-S4 10/96-12/05 WP4008 

MK 6 3.0 6G72-S4 10/96-12/05 WP4018 

CH, CJ, CK 6 3.5, 4.0, 4.3 06/71-10/76 WP802 

CH, CJ, CK, CL, 

CM 

8 5.2, 5.6, 5.9 06/71-12/81 WP806 Without air 

conditioner or 

thermal drive 

CL, CM 6 4.0, 4.3 11/76-12/81 WP802 

Page 24



(LITRES) 


VERADA 

Nissan 

1600 

1200 INC UTE 

120Y 

180B 

200B 

200SX 

260 SERIES 

280ZX 

300ZX 

720 UTE 

BLUEBIRD 


PART NO 

VC, VE, VF 6 3.7 04/66-04/70 WP578 

VF, VG, VH, VJ, 

VK 

VF, VG, VH, VJ, 

VK 

6 3.5, 4.0, 4.3 03/69-10/76 WP802 

SILVERLINE 

PART NO 

COMMENTS 

8 5.2, 5.6, 5.9 03/69-10/76 WP806 Without air 

conditioner or 

thermal drive 

VG 6 3.5, 4.0 05/70-05/71 WP802 

VH, CH 6 3.5, 4.0, 4.3 06/71-03/73 WP802 

VJ, CJ 6 3.5, 4.0, 4.3 04/73-09/75 WP802 

VK, CK 6 3.5, 4.0, 4.3 10/75-10/76 WP802 

KE, KF, KH, KJ, 

KL 

6 3.5 6G74-S4 10/96-12/05 WP4014 

KR, KS 6 3.0 6G72 07/91-10/96 WP2040 WP2040SL With spring loaded 


backing plate 

KR, KS 6 3.0 6G72 07/91-10/96 WP3114 With backing plate 



1600 4 1.6 L16 01/68-10/72 WP752 WP752SL 

1200 4 1.2 A12 06/70-12/85 WP788 

B210 SERIES 4 1.2 A12 03/74-03/79 WP788 Without clutch fan 

B210 SERIES 4 1.2 A12 03/74-03/79 WP3011 WP3011SL 

SED/WAG/ 

COUPE 

SED/WAG/ 

COUPE 

SED/WAG/ 

COUPE 

SED/WAG/ 

COUPE 

4 1.8 L18 01/72-10/77 WP752 WP752SL Without air 

conditioner 

4 1.8 L18 01/72-10/77 WP845 With air conditioner 

& with clutch fan 

4 2.0 L20B 10/77-05/81 WP752 WP752SL Without air 

conditioner 

4 2.0 L20B 10/77-05/81 WP845 With air conditioner 


2DOOR COUPE 4 2.0 SR20DE-T 10/94-12/05 WP3097SL 

260C, 260Z 6 2.6 L26 01/73-01/78 WP754 WP754SL 

2D COUPE 6 2.8 L28E 03/79-05/84 WP754 

Z31 6 3.0 VG30E, 

VG30ET 

05/84-11/89 WP2191 

2WD 4WD 4 2.3, 2.5 SD23, SD25 01/83-12/85 WP833 

2WD 4WD 4 2.2 SD22 09/79-03/83 WP857 

2WD 4WD 4 1.8 L18 09/79-12/85 WP752 WP752SL 

4WD 4 2.2 Z22 04/83-12/85 WP754 WP754SL 

SERIES 1&2 4 2.0 L20B 05/81-03/85 WP752 WP752SL Without air 

conditioner 

Page 25


Page 26 


(LITRES) 

Nissan (continued) 

CABSTAR 

GAZELLE 

MAXIMA 

MICRA 

NAVARA 

NOMAD 

NX COUPE 

PATHFINDER 

PATROL 


PART NO 

SILVERLINE 

PART NO 

COMMENTS 

SERIES 1&2 4 2.0 L20B 05/81-03/85 WP845 With air conditioner 


SERIES 3 4 2.0 CA20S 05/85-06/86 WP3023 WP3023SL 

U13 FWD 4 2.4 KA24 09/93-12/97 WP3099 

KAH40/AF22 4 2.7 05/87-09/92 WP3025 

KUH40/UH40 4 2.2 Z22 10/84-12/87 WP754 WP754SL 

MGH40 4 3.3, 3.5 ED33, FD35 08/84-12/93 WP3026 WP3026SL 

PF22 4 2.0 Z20 11/84-12/87 WP752 WP752SL 

S12 4 2.0 CA20E 01/84-11/88 WP3023 WP3023SL 

J30 6 3.0 VG30E 05/90-01/95 WP3024 WP3024SL 

K11 4 1.3 CG13DE 06/95-12/97 WP3101 WP3101SL 

D21 DIESEL 4 2.5 SD25 02/86-01/88 WP3027 

D21 DIESEL 4 2.5, 2.7 TD25, TD27 02/88-02/97 WP3028 Non turbo (fan 

clutch 135mm 

between bolt hole 

centres) 

D21 PETROL 4 2.0 Z20 01/86-02/97 WP3058 With air conditioner 

to 12/90: with clutch 

fan 1/91 on 

D21 PETROL 4 2.0, 2.4 Z20, Z24S 01/86-12/90 WP752 WP752SL Without air 

conditioner 

D21 PETROL 4 2.4 Z24S 01/91-05/92 WP3058 With clutch fan 

D21 PETROL 4 2.4 Z24S 01/86-12/90 WP754 WP754SL With air conditioner 

D21 PETROL 4 2.4 KA24E 06/92-02/97 WP3118 WP3118SL 

D21/D22 

DIESEL 

D21/D22 

DIESEL 

4 2.7 TD27 02/88-08/99 WP3119 Turbo (fan clutch 

135mm between 

bolt hole centres) 

4 2.7 TD27 02/88-08/99 WP4130 All models with 

143mm between 

bolt hole centres 

D22 DIESEL 4 2.7 TD27 03/97-08/99 WP3028 Non turbo (fan 

clutch 135mm 

between bolt hole 

centres) 

D22 PETROL 6 3.3 VG33E 03/03-12/05 WP4011 

D22 DIESEL 4 3.2 QD32E 03/97-12/01 WP3119 

D22 PETROL 4 2.4 KA24DE 03/97-12/05 WP3099 

D22 PETROL 6 3.0 VG30E 06/92-12/97 WP2191 2WD 

D22 DIESEL 4 3.0 ZD30 12/01-12/05 WP8221SL Turbo 

WSC22 4 2.4 Z24S 12/86-10/87 WP754 WP754SL 

WSC22 4 2.4 Z24S 11/87-10/92 WP3030 

NX 4 2.0 SR20DE 10/91-01/96 WP3050 

RX/TI/ST 6 3.3 VG33E 11/95-12/05 WP4011 

WHYD21 6 3.0 VG30E 10/92-11/95 WP3120 

WYND21 4 2.4 Z24S 12/86-09/92 WP754 WP754SL 

G60, 61 6 4.0 P 01/70-12/79 WP834



(LITRES) 


PINTARA 

PULSAR 

SERENA 

SILVIA 

SKYLINE 

STANZA 

SUNNY 

TERRANO 

URVAN 


PART NO 

SILVERLINE 

PART NO 

COMMENTS 

GQ/RX (Y60) 6 4.2 TB42E, TB42S 01/88-12/97 WP5010 Diesel and petrol 

GQ/RX (Y60) 6 3.0 RB30 10/88-12/97 WP6071 

GQ/RX(Y60)- 

GU/11(Y61) 

GQ/RX(Y60)- 

GU/11(Y61) 

6 2.8 RD28T, 

RD28ET-I 


6 4.2 TD42, TD42T 11/87-12/05 WP6056 WP6056SL Diesel inc Turbo 

GU/11 (Y61) 4 3.0 ZD30 04/00-12/05 WP8221SL 

GU/11 (Y61) 6 4.8 TB48DE 10/01-12/05 WP8223SL 

GU/11 (Y61) 6 4.5 TB45E 12/97-10/01 WP4064SL 

MQ/MK (160) 6 4.0 P40 01/80-12/85 WP4021 

MQ/MK (160) 6 2.8 L28 01/81-12/87 WP754 WP754SL 

MQ/MK (160) 6 3.3 SD33, SD33T 06/80-12/87 WP913 

R31, U12 4 2.0 CA20E 06/86-10/92 WP3023 WP3023SL 

U12 (FWD) 4 2.4 KA24E 11/89-10/92 WP3022 

EXA 4 1.6, 1.8 CA18DE, 

CA18DE 

02/87-10/91 WP1170 Do not fit to ‘silvia/ 

180sx/gazelle’ grey 

imports 

M10, ET 4 1.5 E15, E15T 12/82-07/87 WP888 WP888SL 

N10 4 1.4 A14 10/80-10/82 WP788 

N10, N12 4 1.3, 1.5, 1.6 E13, E15, E16S 10/80-06/87 WP888 WP888SL 

N13 4 1.6, 1.8 16LF, 18LE 07/87-09/91 WP2189 WP2189SL Without dust shield 

N13 4 1.6, 1.8 16LF, 18LE 07/87-09/91 WP2512 WP2512SL With dust shield 

under hub 

N14, N15 4 2.0 SR20DE 10/91-09/00 WP3050 

N14, N16 4 1.6 GA16DE 10/91-09/00 WP3053 

N16 4 1.6, 1.8 QG16DE, 

QG18DE 

07/00-12/05 WP8168SL 

WAGON 4 2.0 SR20DE 09/92-11/95 WP3050 

S13 SER-1 4 1.8 CA18DE, 

CA18DE-T 

01/88-12/91 WP3023 WP3023SL 

S13 SER-11 4 2.0 SR20DE-T 01/91-12/94 WP8169SL 

C210, R30 6 2.4 L24, L24E 03/78-07/86 WP754 WP754SL 

R31 6 3.0 RB30E 07/86-05/91 WP898 WP898SL 

PA10 4 1.6 L16 10/78-09/83 WP752 WP752SL Without air 

conditioner 

PA10 4 1.6 L16 10/78-09/83 WP845 With air conditioner 


B310 SERIES 4 1.2, 1.4, 1.5 A12, A14, A15 03/79-10/81 WP788 

R20 4WD 

WAGON 

R20 4WD 

WAGON 

4 2.4 KA24E 03/97-04/00 WP3022 

4 2.7 TD27T 03/97-06/00 WP4130 All models with 

143mm between 


E23 4 2.2, 2.3 SD22, SD23 09/80-02/87 WP857 

Page 27



(LITRES) 


VANETTE 

XFN UTE 

Peugeot 

205 

306 

307 

406 

Proton 

PERSONA 

SATRIA 

WIRA 

Saab 

900 

9000 


PART NO 

E23 4 1.6 J16 09/80-08/82 WP837 

E23 4 2.0 H20 09/80-08/82 WP846 

SILVERLINE 

PART NO 

E23, 24 4 2.0, 2.4 Z20, Z24S 09/82-09/93 WP754 WP754SL 

COMMENTS 

E24 4 2.7 TD27 03/87-09/93 WP3119 Turbo (fan clutch 

135mm between 

bolt hole centres) 

E24 4 2.7 TD27 03/87-09/93 WP4130 All models with 

143mm between 


C20 4 1.2 A12 07/82-10/84 WP788 

C20, 120 4 1.2, 1.5 A12, A15 07/82-11/86 WP3011 WP3011SL 

C22 4 2.0 Z20 12/86-09/93 WP754 WP754SL 

XFN 6 4.1 07/88-09/90 WP804 WP804SL 

GTI, SI 4 1.6, 1.9 10/87-04/94 WP4028SL 

2 & 4 DOOR 4 2.0 SOHC 04/94-10/00 WP4028SL 

2 & 4 DOOR 4 2.0 DOHC 07/97-12/01 WP8101SL 

4 DOOR HATCH 4 2.0 12/01-12/05 WP8137SL Turbo diesel 

ST 4DR SEDAN 4 2.0 DOHC 16V 09/96-08/99 WP8101SL 

ST HDI SED/ 

WAG 4DR 

4 2.0 08/99-10/04 WP8137SL Turbo diesel 

GLI, XLI 4 1.6 4G92 11/96-12/00 WP3092 WP3092SL 

GLI, XLI 4 1.3, 1.5 4G13, 4G15, 

S3 

GL/I, XLI, GTI 

H/BACK 

GL/I, XLI, GTI 

H/BACK 

4 1.3, 1.5 4G13, 4G15, 

S3 

11/96-12/05 WP877 WP877SL 

02/97-12/05 WP877 WP877SL 

4 1.6, 1.8 4G92, 4G93 02/97-12/05 WP3092 WP3092SL 

GL, GLI, XLI 4 1.5 S3, 4G15 05/95-11/96 WP877 WP877SL 

GL, GLI, XLI 4 1.6 4G92 05/95-11/96 WP3092 WP3092SL 

2.0I, 16, EMS, GLE, 

S, SE, 2.5, V6 

2.0I, 16, EMS, 

GLE, SE, TURBO 

16, AERO 

4 2.0 8V 01/97-06/98 WP8111SL 

4 2.0 DOHC16V inc 

turbo 

03/85-06/98 WP2663 WP2663SL 

2.3I, S 4 2.3 03/94-06/98 WP2962SL 

GLE, GLI, I, S, 

TURBO 

16, GLE, CS, 

TURBO, CD, 

CS, CSE 

4 2.0 SOHC inc 

turbo 

03/79-02/91 WP2180 

4 2.3 05/90-06/98 WP2962SL 

Page 28



(LITRES) 

Saab (continued) 

9-3 

9-5 

Seat 

CORDOBA 

IBIZA 

TOLEDO 

Ssangyong 

MUSSO 

Subaru 

BRUMBY 

FORESTER 

IMPREZA 

LEONE 2/4WD 

LEONE 4WD 

LIBERTY 

OUTBACK 

VORTEX 

Suzuki 

ALTO 


PART NO 

SILVERLINE 

PART NO 

CDE, GRIFFIN 6 3.0 02/95-02/97 WP8111SL 

GLE, TURBO 4 2.0 05/86-02/91 WP2663 WP2663SL 

2.0 TURBO 4 2.0 11/98-12/05 WP8248SL 

4 CYL 4 2.0 07/99-12/05 WP8248SL 

V6 6 3.0 03/99-12/05 WP8111SL 

CORDOBA 4 1.8 ADZ 12/94-11/99 WP2453SL 

CORDOBA 4 1.6 AEE 12/94-11/99 WP8128SL 

IBIZA 4 1.4 ABD 12/94-01/97 WP2453SL 

TOLEDO 4 2.0 ABF 10/95-01/97 WP2453SL 

4X4 5 DOOR 

WAGON 

5 2.9 07/96-07/98 WP8205SL 

4 X 4 4 1, 6, 1.8 01/79-03/94 WP848 WP848SL 

4 X 4 4 1.6 EA71 05/78-12/78 WP820 

AWD WAGON 4 2.0 EJ20 Turbo 08/97-06/02 WP3091 

X, XS WAGON, 

AWD WAGON 

4 2.0, 2.5 EJ20E, EJ25D 08/97-12/05 WP3035 WP3035SL 

2/4WD 4 1.6, 1.8, 2.0, 

2.5 

EJ16, EJ18, 

EJ20E, EJ25D 

04/93-12/05 WP3035 WP3035SL 

4WD.GX.W/RX 4 2.0 EJ20 Turbo 02/94-12/05 WP3091 

DL/GF/GL 4 1.6 EA71 01/79-12/80 WP849 

DL, GL, GLF 4 1.8 EA81 11/79-11/84 WP848 WP848SL 

DL/GF/GL/GSR 4 1.6 EA71 07/73-12/78 WP820 

DL, GL, 4 1.8 EA82 06/82-12/95 WP3033 WP3033SL 

LEONE SEDAN 4 1.8 EA82T 08/87-06/88 WP3034 WP3034SL 

LX, GX, 

HERITAGE, RX 

4 2.0, 2.2, 2.5 EJ20E, EJ22, 

EJ25D 

10/89-09/03 WP3035 WP3035SL 

COMMENTS 

RX 4X4 4 2.5 EJ25 11/96-10/98 WP3035 Single hose outlet 

RX 4X4 4 2.5 EJ25 11/96-10/98 WP3091 

4WD WAGON 4 2.5 EJ25D 10/98-09/03 WP3035 WP3035SL 

XT 4 1.8 EA82T 01/86-09/89 WP3034 WP3034SL 

XT 4 1.8 EA82 09/85-09/89 WP3033 WP3033SL 

VAN 3 0.8 01/87-02/89 WP2003 

Page 29



(LITRES) 

Suzuki (contined) 

BALENO 

HATCH 

JIMNY 

MIGHTY BOY 

SIERRA 

ST80/90 

SWIFT 

VITARA 

X-90 

Toyota 

4 RUNNER 

AVALON 

AVANTE 

SEDAN/HATCH/ 

WAGON 

SEDAN/HATCH/ 

WAGON 


PART NO 

SILVERLINE 

PART NO 

4 1.8 J18A 03/96-04/01 WP8153SL 

4 1.6 G16B 04/95-11/01 WP3036 

VAN 3 0.5, 0.8 02/80-12/85 WP2003 

COMMENTS 

VAN 3 0.3, 0.8 02/80-12/85 WP2011 From Eng No 

270001 

JX/JLX 2D 

HARDTOP 

4 1.3 G13BB 11/98-09/02 WP2008 With pitch circle 

diameter 40mm 

UTE 3 0.5 07/85-10/88 WP2003 

UTE 3 0.5 07/85-10/88 WP2011 From Eng No 

270001 

V, JX, VX 4 1.0 F10A 07/81-09/00 WP2003 

V, JX, VX 4 1.0 F10A 07/81-09/00 WP2011 From Eng No 

270001 

V, JX, VX 4 1.3 G13BA 08/91-05/99 WP3037 WP3037SL 

V, JX, VX 4 1.3 G13A, G13BA 10/84-05/99 WP3012 Suits some models, 

with fan clutch 

(check) 

4 0.8 G13A, G13B, 

G13BA 

06/78-07/85 WP2003 

1.5L 4 1.5 M15A 02/05-12/06 WP8266SL 

SA, SF 3,4 1.0, 1.3 G10, G13A 01/85-05/95 WP2008 With pitch circle 

diameter 40mm 

SA, SF 3,4 1.0, 1.3 01/85-12/99 WP3037 WP3037SL With pitch circle 

diameter 60mm 

SF 4 1.6 G16B 10/89-05/95 WP3036 

SE416, SZ416 4 1.6 G16A, G16B 01/88-09/02 WP3036 

SQ625, SV620, 

XL-7 

6 2.0, 2.5, 2.7 H20A, H25A, 

H27A 

03/95-12/05 WP4118 WP4118SL Including Grand 

SV/SQ420 4 2.0 J20A 05/97-12/05 WP8153SL 

4X4 2R WAGON 4 1.6 G16B 04/96-05/98 WP3036 

LN60, 61 4 2.4 2L 08/84-09/89 WP1061 Diesel 

LN61, 130 4 2.8 3L 05/85-06/96 WP3046 Diesel 

RN130, YN63 4 2.4 22R 05/89-06/96 WP3045 WP3045SL 

VZN130 6 3.0 3VZ-E 10/90-08/92 WP3049 

VZN130 6 3.0 3VZ-E 09/92-06/96 WP3105 

YN60, 63, 130 4 2.0, 2.2 3YC, 4Y, 4Y-E 07/84-12/90 WP894 WP894SL 

MCX10R, MK3 6 3.0 1MZ-FE 07/00-12/05 WP9092 WP9092SL 

RTI42 4 2.4 22R-EC 11/84-04/87 WP3045 WP3045SL 

Page 30



(LITRES) 

Toyota (continued) 

AVENSIS 

BUNDERA 

CAMRY 

CELICA 

COASTER 

COROLLA 


PART NO 

SILVERLINE 

PART NO 

ST141 4 2.0 2S-C 08/84-04/87 WP1053 WP1053SL 

4D WAGON 4 2.0, 2.4 1AZ-FE, 2AZ- 

FE 

12/01-12/05 WP8227SL 

LJ70 4 2.4 2LT/E 01/86-12/91 WP3046 

RJ70 4 2.4 22R 01/85-12/91 WP3045 WP3045SL 

ACV36R 4 2.4 2AZ-FE 10/02-12/05 WP8227SL 

MCV20R 6 3.0 1MZ-FE 08/97-02/03 WP9092 WP9092SL 

MCV36R 6 3.0 1MZ-FE 10/02-12/05 WP9092SL 

SDV10, SXV10, 

SXV20R 

COMMENTS 

4 2.2 5SFE 03/93-02/03 WP3047 WP3047SL Does not contain top 

bypass pipe o-ring 

(small) OE only 

SV11, 20 4 1.8, 2.0 1S-E, 2S-EC 04/83-08/89 WP1053 WP1053SL 

SV21, 22 4 2.0 3SFE, 3SFC 06/87-06/91 WP3047 WP3047SL 

VDV10, VZV21 6 2.5, 3.0 2VZFE, 3VZFE 06/88-08/97 WP3040 

RA23, 28, 40 4 2.0 18RC 06/76-07/81 WP1836HO Rear housing twin 

pulley pump 

RA23, 28, 40 4 2.0 18RC 06/76-07/81 WP759 Single pulley pump 

only 

RA23, 28, 40 4 2.0 18RC 06/76-07/81 WP836 Twin belt pulley with 

fan clutch 

RA23, 28, 40 4 2.0 18RC 06/76-07/81 WP836A Twin pulley pump 

only without clutch 

fan 

RA40 4 2.0 18RC 11/77-07/81 WP836A Twin belt pulley 

without fan clutch 

RA60 4 2.0 21RC 09/81-10/83 WP842 

RA65 4 2.4 22R 10/84-12/85 WP3045 WP3045SL 

SA63 4 2.0 2S-C 09/83-10/84 WP1053 WP1053SL 

ST162, 184, 

204R 

ST162, 185R, 

205R 

4 2.0, 2.2 3SFE, 5SFE 08/86-11/99 WP3047 WP3047SL 

4 2.0 3SGE, 3SGTE 

TURBO 

11/85-12/94 WP1090 

TA22, 23 4 1.6 2T 11/71-05/76 WP798 

ZZT231R SX/ZR 4 1.8 2ZZ-GE 11/99-12/05 WP8228SL 

BB10 4 3.2 2B 06/78-07/82 WP9075 Diesel with oil 

cooler 

BB10 4 3.2 2B 06/78-07/82 WP885 Diesel without oil 

cooler 

HB30 6 4.0 2H, 12HT 

TURBO 

01/87-12/89 WP896 

HZB30, 50 6 4.2 1HZ DIESEL 01/90-12/02 WP3106 

RB11, 13 4 2.2, 2.4 20R, 22R 10/80-06/92 WP842 

RB20 4 2.4 22R 07/82-06/92 WP3045 WP3045SL 

RB20 4 2.4 22R 07/82-12/82 WP842 

RU18, 19 4 2.0 5R 01/75-12/77 WP847 

RU18, 19 4 2.0 5R 01/71-12/74 WP858 

AE101R 4 1.6 4AFE 09/94-11/99 WP3084 

AE112R 4 1.8 7AFE 09/98-12/01 WP4015 WP4041SL 

Page 31



(LITRES) 


CORONA 

CRESSIDA 

CROWN 

AE71, 86 

SPRINTER 


PART NO 

4 1.6 4AC 07/83-12/85 WP5003 

SILVERLINE 

PART NO 

AE80, A2 4 1.3, 1.6 2ALC, 4ALC 04/85-09/89 WP1058 WP1058SL 

AE82, 92, 93 4 1.6 4AGEL 01/86-09/94 WP1063 

AE90, 92, 94, 

95(4WD) 

4 1.4, 1.6 6AFC, 4AFC, 

4AFE 

COMMENTS 

06/89-07/95 WP3039 WP3039SL 2 x orings required 

not supplied - 

source OE 

AE92 4 1.6 4AFC 06/89-09/94 WP1058 Early models 

AE93, 94, 102R, 

SPRINTER 

4 1.8 7AFE 08/91-09/98 WP3083 

KE10, 11, 15, 16 4 1.1 K4 06/67-05/69 WP757 

KE20, 25, 26, 30 4 1.2 3K 02/70-10/74 WP797 

KE30, 35, 36, 

38, 50, 55 

4 1.2, 1.3 3KC, 4KC 04/78-11/81 WP859 WP859SL 

KE30, 35, 36, 50 4 1.2 3KC 11/74-04/78 WP835 

KE70 4 1.3 4KC 10/81-04/85 WP859 WP859SL Early models-58mm 

hub diameter 

KE70 4 1.3 4KC 10/81-04/85 WP897 Later models- 

’hicam’engines- 

70mm hub diameter 

ZZE122R, 

SPORTIVO 

4 1.8 1ZZ-FE, 2ZZ- 

GE 

12/01-12/05 WP4048 

RT104 4 2.0 18R 03/74-04/76 WP1836HO Rear housing twin 

pulley pump 

RT104 4 2.0 18R 03/74-04/76 WP759 To engine No 

18R1343529 single 

pulley pump only 

RT104 4 2.0 18R 03/74-04/76 WP836 From engine No 

18R1343530 twin 

pulley with clutch 

fan 

RT104 4 2.0 18R 03/74-04/76 WP836A From engine No 

18R1343530 twin 

pulley pump only 

RT104 4 2.0 18R 03/74-04/76 WP890 To engine No 

18R1343529 single 

pulley with clutch 

fan 

RT104, 18, 32 4 2.0 18RC 05/76-01/82 WP1836HO Rear housing 

RT104, 18, 32 4 2.0 18RC 05/76-01/82 WP836 With clutch fan 

RT104, 18, 32 4 2.0 18RC 05/76-01/82 WP836A Without clutch fan 

RT133 4 2.0 21RC 02/82-07/83 WP842 

RT142 4 2.4 22R-EC 11/84-04/87 WP3045 WP3045SL 

RT80 4 1.5 2R 06/70-06/71 WP579 

RT81 4 1.6 12R 07/71-02/74 WP959 

ST141 4 2.0 2S-C 08/83-04/87 WP1053 WP1053SL 

XT130 4 1.9 10/79-07/83 WP814 WP814SL Long shaft 20mm 


XT130 4 1.9 10/79-07/83 WP726 WP726SL Short shaft 10mm 


MX32, 36 6 2.6 4M 01/77-01/81 WP841 

MX62, 73 6 2.8 5ME 02/81-08/85 WP1055 

MX73 6 2.8 5MGE 08/85-10/88 WP816 

MX83 6 3.0 7MGE 10/88-01/93 WP3042 

MS112, 123 6 2.8 5ME 10/80-12/85 WP1055 

Page 32



(LITRES) 


DYNA 

ECHO 

HI-ACE 

HI-LUX 


PART NO 

MS123 6 2.8 5MGE 12/85-05/88 WP816 

MS65 6 2.6 4M 01/71-04/75 WP020 

MS83, 85, 111 6 2.6 4M 05/75-10/80 WP841 

BU20, 32, 36 4 3.0, 3.4 B, 3B 02/80-09/84 WP9075 

BU61, 65, 85 4 3.0, 3.4 11B, 13B 12/84-06/95 WP3038 

BU88, 91 4 3.7 14B 08/88-06/95 WP3078 

HU15, 30 6 3.6 H 01/72-06/81 WP887 

HU40, 50 6 4.0 2H 07/82-09/84 WP896 

SILVERLINE 

PART NO 

COMMENTS 

LH80 4 2.4 2L DIESEL 08/88-04/91 WP3046 150 Series 

LH80 4 2.4 2L DIESEL 12/85-08/88 WP1061 100 Series 

LY60, 61 4 2.4 2L DIESEL 10/85-06/95 WP1061 

LY61 4 2.8 3L 09/88-06/95 WP3046 

RU10, 12, 15 4 2.0 5R 01/70-11/77 WP858 

RU20, 30 4 2.0 5R 12/77-12/83 WP847 

YU60, 62, 81, 

100 

4 1.8, 2.0, 2.2 2YC, 3YC, 4Y 10/84-09/01 WP894 WP894SL 

SEDAN/HATCH 4 1.3, 1.5 2NZ-FE, 1NZ- 

FE 

LH103R, 113R, 

125 

LH11, 20, 30, 

50, 51, 60, 61, 

70, 71 

10/99-12/05 WP4010 WP4010SL 

4 2.8 3L DIESEL 10/89-10/00 WP3046 

4 2.2, 2.4 L, 2L 11/82-09/89 WP1061 

LH11.20, 30 4 2.2 L 03/81-12/82 WP819 

RCH12R, 22R, 

RZH103, 113, 

125 

4 2.4 2RZ 10/95-12/05 WP3131 WP3131SL 

RH11, 16.20 4 1.6, 1.8 12R 01/77-12/85 WP826 

RH11, 16 4 1.6 12R 05/72-12/76 WP959 

RH22, 32, 42 4 2.0 18RC 06/77-12/82 WP1836HO Rear housing 

RH22, 32, 42 4 2.0 18RC 06/77-12/82 WP836 With clutch fan 

RH22, 32, 42 4 2.0 18RC 06/77-12/82 WP836A Without clutch fan 

RZH103R, 113, 

125 

YH50, 51, 53, 

61, 63, 71, 73 

4 2.4 2RZ-E 10/89-08/95 WP3131 WP3131SL 

4 2.0, 2.2 2YC, 3YC, 4Y 01/83-09/89 WP894 WP894SL 

KZN165 4WD 4 3.0 1KZ-TE 12/99-12/05 WP4124 WP8144SL 

LN40, 46, 55 4 2.2 L 05/80-12/84 WP819 

LN56, 65 4 2.4 2L DIESEL 08/83-09/88 WP1061 

LN85 2WD 4 2.4 2L 10/88-09/91 WP3046 

LN86, 106, 107, 

111, 147, 167, 

172 

4 2.4, 2.8, 3.0 2L, 3L, 5L 11/88-12/05 WP3046 

RN20, 25, 30, 40 4 1.6 12R 11/75-10/83 WP826 

RN20, 25, 2WD 4 1.6 12R 01/70-11/75 WP959 

RN31, 36, 41, 46 4 2.0 18RC 03/79-10/83 WP1836HO Rear housing 

RN31, 36, 41, 46 4 2.0 18RC 09/78-10/83 WP2044 WP2044SL Models with clutch 

fan (pump only) 

RN31, 36, 41, 46 4 2.0 18RC 09/78-10/83 WP836 With clutch fan 

Page 33



(LITRES) 


KLUGER 

LAND CRUISER 

LEXCEN 


PART NO 

SILVERLINE 

PART NO 

COMMENTS 

RN31, 36, 41, 46 4 2.0 18RC 09/78-10/83 WP836A Without clutch fan 

RN85, 90, 105, 

106, 110 

4 2.4 22R 08/88-10/97 WP3045 WP3045SL 

RZN147 2WD 4 2.0 1RZ 10/97-11/02 WP3131 WP3131SL 

RZN149, 154, 

169, 174 

4 2.7 3RZFE 10/97-12/05 WP4005 

VZN167R 4WD 6 3.4 5VZFE 11/02-12/05 WP4006 

YN55, 56, 57, 

58, 65, 67, 85 

4 1.6, 1.8, 2.0, 

2.2 

1YC, 2YC, 

3YC, 4Y 

11/83-10/97 WP894 WP894SL 

4WD WAGON 6 3.3 3MZ-FE 10/03-12/05 WP9092SL 

BJ40 (B) 4 3.0 B 06/77-05/79 WP885 With aluminium 

body 

BJ42, 70, 73, 74 4 3.4 3B, 13BT 08/80-02/90 WP3068 

FJ40, 45 6 3.9 F 01/69-09/75 WP829 From engine No 

F243298 on 

FJ40, F5 6 3.9 F 01/69-09/75 WP825 To engine No 

F243297 

FJ40, 45, 55 6 4.2 2F 01/75-07/80 WP856 Models without fan 

clutch or oil cooler 

FJ40, F5, 55 6 4.2 2F 01/79-12/80 WP938 Models with fan 

clutch and oil cooler 

FJ40, 45, 60 6 4.2 2F 08/80-11/84 WP3055 With clutch fan 

FJ55 (F) 6 3.9 F 01/69-09/75 WP829 

FJ62, F0, 73, 75 6 4.0 3F 11/84-10/92 WP1220 With manual 

transmission 

FJ70, 80 6 4.0 3F 11/84-10/92 WP3051 Models with auto 

transmission 

without oil cooler 

FJ70, 80 6 4.0 3F, 3FE 11/84-10/92 WP3052 Models with auto 

transmission & oil 

cooler 

FJ80 6 4.0 3F 05/90-10/92 WP3051 

FJ80 6 4.0 3F 05/90-10/92 WP3052 Suits models with 

fan clutch & engine 

oil cooler 

FZJ70, 75, 78, 

79, 80, 105R 

HDJ78R, 79R, 

80, 100R, 

HZJ70, 73, 75, 

78, 79, 80 

6 4.5 1FZFE 08/92-12/05 WP4009 

6 4.2 1HDT, 1HDFT, 

1HZ 

02/90-12/05 WP3106 

HJ45 (H) 6 3.6 H 04/72-03/80 WP887 Use OE pump 

4/80 on 

HJ47, 60, 61, 75 6 4.0 2H, 12HT 

TURBO 

08/80-04/90 WP896 

PZJ70, 73 5 3.5 1PZ 03/90-02/91 WP3106 

UZJ100R 8 4.7 2UZ-FE 03/98-12/05 WP8143SL 

VN 6 3.8 01/91-10/91 WP3000 WP3000SL Timing cover cast 

No 25534687 

VN 6 3.8 09/89-12/90 WP1039 WP1039SL Timing cover 

cast No 

25532382/25533496 

VP 6 3.8 11/91-07/93 WP3000 WP3000SL Timing cover cast 

No 25534909 


VH1414581 

Page 34



(LITRES) 


LITE ACE 

MR2 

PASEO 

PRADO 

RAV4 

SOARER 

SPACIA 

STARLET 

STOUT 

SUPRA 

SURF 

T18 

TARAGO 


PART NO 

SILVERLINE 

PART NO 

COMMENTS 


VH1414582 on 


VH515478 


VH515479 on 

CM20, 35, 36 4 1.8, 2.0 1C, 2C 01/83-03/92 WP1200 

KM20 4 1.3 4KC 02/80-12/85 WP859 WP859SL 50mm hub flange 

KM20, 36 4 1.3, 1.5 4KC, 5K 02/80-03/92 WP1069 WP1069SL 57mm hub face dia 

KM36 4 1.5 5K 02/86-03/92 WP1210 77mm hub face dia 

YM21, 30, 35, 

40, 41 

4 1.8, 2.0 2YC, 3YC 01/84-03/92 WP894 WP894SL 

AW11R 4 1.6 4AGEL 10/87-02/90 WP1063 

SW20R 4 2.0 3SGE 03/90-12/99 WP1090 

ZZW30R 4 1.8 1ZZ-FE 10/00-12/05 WP4048 

EL44R, 54R 4 1.5 5EFE 07/91-12/99 WP3085 Without pulley 

KZJ120R 4 3.0 1KZ-TE 02/03-12/05 WP8144SL 

KZJ95R 4 3.0 1KZ-TE 04/00-02/03 WP4124 WP8144SL 

RZJ95, 120R 4 2.7 3RZFE 07/96-12/05 WP4005 

VZJ95 6 3.4 5VZFE 08/96-02/03 WP4006 

ACA20R, 21R, 

22R, 23R 

4 2.0, 2.4 1AZ-FE, 2AZ- 

FE 

07/00-12/05 WP8227SL 

SXA10R/11R 4 2.0 3SFE 07/94-07/00 WP3047 WP3047SL 

UZZ31 COUPE 8 4.0 1UZ-FE 01/90-12/97 WP3104SL 

SR40 4 2.0 3SFE 02/98-08/01 WP3047 WP3047SL 

YR22 4 2.2 4Y 10/93-01/98 WP894 WP894SL 

EP91R 4 1.3 4EFE 03/96-10/99 WP3085 Without pulley 

EP91R 4 1.3 4EFE 03/96-10/99 WP4131 

RK101 4 2.0 5R 01/70-12/83 WP858 

MA61 6 2.8 5ME 10/83-02/86 WP1055 

MA61 6 2.8 5MGE 10/83-02/86 WP816 

MA70, 71 6 3.0 7MGE, 7M- 

GTE 

03/86-04/93 WP3042 

4WD WAGON 4 2.4 2L-TE 01/87-12/94 WP1061 Check sample 

4WD WAGON 4 2.4 2L-TE 01/87-12/94 WP3046 Check sample 

4WD WAGON 4 3.0 1KZ-TE 01/92-12/97 WP8144SL 

TE72 4 1.8 3TC 10/79-07/83 WP1031A Without clutch fan 

ACR30R FWD 4 2.4 2AZ-FE 06/00-12/04 WP8227SL 

Page 35



(LITRES) 


TERCEL 

TOWNACE 

VIENTA 

Volkswagen 

BEETLE 

BORA 

CARAVELLE 

GOLF 

PASSAT 

POLO 

TRANSPORTER 

Volvo 

360 

440 

740 

760 

850 


PART NO 

CR21 4 2.0 2C 07/83-09/88 WP1200 

TCR10, 11, 20, 21 4 2.4 2TZ-FE 09/90-10/93 WP3132 

SILVERLINE 

PART NO 

YR20, 21, 22, 31 4 1.8, 2.0, 2.2 2YC, 3YC, 4Y-E 01/83-10/90 WP894 WP894SL 

COMMENTS 

AL25 4 1.5 3AC 10/83-04/88 WP5002 3 bolt pulley 

AL25 4 1.5 3AC 10/83-04/88 WP5003 4 bolt pulley 

KR42 4 1.8 7K-E 12/98-12/04 WP1210 77mm hub face dia 

YR39 4 2.0 3YC 01/92-01/97 WP894 WP894SL 

MCV20R 6 3.0 1MZ-FE 08/97-10/00 WP9092 WP9092SL 

VDV10 6 3.0 3VZFE 02/93-08/97 WP3040 

NEW BEETLE 4 1.8, 2.0 01/00-12/05 WP8131SL Including turbo 

SEDAN 4 2.0 12/99-12/05 WP8131SL 

3/4D WAGON 5 2.5 01/93-06/05 WP8134SL 

CL, GTI, 

CABRIOLET 

GL 5D 

HATCHBACK 

GTI 5D 

HATCHBACK 

4 1.8 09/90-12/01 WP2453SL 

4 1.6 10/98-12/05 WP8132SL 

4 1.8 04/99-12/05 WP8131SL Turbo 

HATCHBACK 4 1.5, 1.6 02/74-12/82 WP952 Including diesel 

GLS 4 1.3, 1.5, 1.6 02/74-12/82 WP952 Including diesel 

5 DOOR 

HATCHBACK 

4 1.6 10/96-09/00 WP8128SL 

4CYL 2.0L 4 2.0 01/93-12/05 WP2453SL 

5CYL MODELS 5 2.4 09/94-04/99 WP4034 Check sample 

5CYL MODELS 5 2.5 12/94-12/05 WP8134SL Including turbo 

diesel 

360 4 2.0 B19E 01/84-12/87 WP969 

GL/GLT 4 2.0 B20F 11/93-09/96 WP2661 

740 4 2.3 B230E, B230F 06/85-12/91 WP1551 

760 6 2.8 B28E, B28F 02/83-12/90 WP1553 

GLE, GLT, S, SE, 

T5, R 

5 2.4 B5252F, 

B5254F 

10/92-02/97 WP4674 

Page 36



(LITRES) 

Volvo (continued) 

940 

140 SERIES 

240 SERIES 

S40 & V40 

S70 & V70/XC 


PART NO 

940 4 2.3 B230E, B234E 11/90-10/95 WP1551 

144 4 2.0 4C 01/71-01/75 WP976 

240 4 2.3 B230E, B230F 01/87-12/92 WP1551 

240, 242, 244, 

245 

SEDAN & 

WAGON 

4 2.1, 2.3 03/75-12/86 WP969 

4 1.9 02/97-12/05 WP4674 

SED/WAG/AWD 5 2.4 B5254F, 

B5254T 

02/97-12/05 WP4674 

SILVERLINE 

PART NO 

COMMENTS 

Page 37

WP216 WP555 WP564 

WP578 WP579 WP587 

WP726 WP730 WP738 

WP746 WP752 WP754 

WP756 WP757 WP759 

Page 38

WP786 WP788 WP797 

WP798 WP800 WP802 

WP804 WP805 WP806 

WP807 WP809C WP812 

WP814 WP815 WP816 

Page 39

WP817 WP818 WP819 

WP820 WP822 WP824 

WP826 WP827 WP828 

WP829 

WP833 

WP834 

WP835 

WP836 

WP836A 

Page 40

WP837 

WP840 

WP841 

WP842 

WP843 

WP845 

WP846 

WP847 

WP848 

WP849 

WP851 

WP853 

WP854 

WP855 

WP856 

Page 41

WP857 

WP858 

WP859 

WP863 

WP864 

WP877 

WP878 

WP880 

WP885 

WP887 

WP888 

WP890 

WP893 

WP894 

WP895 

Page 42

WP896 

WP897 

WP898 

WP907 

WP913 

WP938 

WP952 

WP959 

WP969 

WP972 

WP976 

WP995 

WP1000 

WP1009 

WP1014 

Page 43

WP1018 

WP1020 

WP1022 

WP1025 

WP1027 

WP1028 

WP1031A 

WP1032 

WP1039 

WP1040 

WP1053 

WP1055 

WP1058 

WP1061 

WP1063 

Page 44

WP1069 

WP1070 

WP1090 

WP1100 

WP1120 

WP1130 

WP1132 

WP1133 

WP1150 

WP1160 

WP1170 

WP1200 

WP1210 

WP1220 

WP1408 

Page 45

WP1550 WP1551 WP1553 

WP1559 WP2003 WP2007 

WP2008 WP2011 WP2014 

WP2017 WP2025 WP2027 

WP2032 WP2040 WP2044 

Page 46

WP2051 WP2154 WP2180 

WP2189 WP2191 WP2358 

WP2453 WP2477 WP2512 

WP2565 WP2593 WP2614 

WP2646 WP2663 WP2671 

Page 47

WP2735 

WP2799 

WP2800 

WP2953 

WP2962 

WP2990 

WP3000 

WP3008 

WP3009 

WP3010 

WP3011 

WP3012 

WP3013 

WP3015 

WP3016 

Page 48

WP3017 

WP3018 

WP3019 

WP3020 

WP3022 

WP3023 

WP3024 

WP3025 

WP3026 

WP3027 

WP3028 

WP3030 

WP3033 

WP3034 

WP3035 

Page 49

WP3036 

WP3037 

WP3038 

WP3039 

WP3040 

WP3042 

WP3045 

WP3046 

WP3047 

WP3048 

WP3049 

WP3050 

WP3051 

WP3052 

WP3053 

Page 50

WP3055 

WP3058 

WP3059 

WP3060 

WP3061 

WP3063 

WP3068 

WP3069 

WP3070 

WP3071 

WP3072 

WP3074 

WP3075 

WP3076 

WP3078 

Page 51

WP3079 

WP3081 

WP3082 

WP3083 

WP3084 

WP3085 

WP3087 

WP3091 

WP3092 

WP3094 

WP3097 

WP3099 

WP3101 

WP3104 

WP3105 

Page 52

WP3106 

WP3111 

WP3112 

WP3114 

WP3115 

WP3117 

WP3118 

WP3119 

WP3120 

WP3122 

WP3123 

WP3124 

WP3130 

WP3131 

WP3132 

Page 53

WP3133 

WP3144 

WP3709 

WP4000 

WP4001 

WP4002 

WP4003 

WP4004 

WP4005 

WP4006 

WP4007 

WP4008 

WP4009 

WP4010 

WP4011 

Page 54

WP4012 

WP4013 

WP4015 

WP4018 

WP4021 

WP4028 

WP4034 

WP4035 

WP4040 

WP4042 

WP4043 

WP4045 

WP4059 

WP4064 

WP4065 

Page 55

WP4100 

WP4101 

WP4102 

WP4103 

WP4104 

WP4105 

WP4106 

WP4108 

WP4112 

WP4113 

WP4115 

WP4116 

WP4130 

WP4498 

WP4674 

Page 56

WP4762 

WP4829 

WP5002 

WP5003 

WP5010 

WP5013 

WP5014 

WP5019 

WP5020 

WP5023 

WP6056 

WP6071 

WP6090 

WP6380 

WP8101 

Page 57

WP8109 

WP8111 

WP8112 

WP8113 

WP8114 

WP8117 

WP8118 

WP8119 

WP8120 

WP8121 

WP8124 

WP8128 

WP8131 

WP8132 

WP8134 

Page 58

WP8137 

WP8143 

WP8144 

WP8148 

WP8153 

WP8155 

WP8159 

WP8161 

WP8162 

WP8164 

WP8168 

WP8169 

WP8175 

WP8176 

WP8181 

Page 59

WP8182 

WP8183 

WP8184 

WP8186 

WP8187 

WP8192 

WP8193 

WP8194 

WP8196 

WP8199 

WP8202 

WP8205 

WP8208 

Page 60 

WP8211 

WP8221

WP8223 

WP8227 

WP8228 

WP8230 

WP8248 

WP8255 

WP8259 

WP8260 

WP8261 

WP8262 

WP8263 

WP9075 

WP9092 

Page 61

Hints On Over Heating 

Engine Over-Heating Check List 

Check radiator & all hoses 

for signs of leaking 

Check external condition 

of radiator for any form of 

air flow restriction 

Check that a thermostat 

is fitted and if so check that 

it's operational 

Check condition of fan belt and 

check fan belt for slippage on 

drive pulleys 

Check pressure and operation 

of radiator cap 

Repair any radiator leaks or faulty hoses, this includes 

all manifold and heater hoses. 

Ensure air flow through the radiator is not restricted 

eg. radiator blocked with dead bugs or some option 

fitted that is cutting off the air flow through the radiator. 

A thermostat can be tested by immersing it in boiling 

water and seeing if it opens, if it fails to fully open, 

replace it. 

Check fan belt tension and condition, replace or 

adjust as required. 

Pressure test the radiator cap, replace cap if not 

to specification. 

Check radiator flow rate, a 

blocked Radiator is the most 

common cause of over-heating 

Check bottom radiator hose 

for collapsing when the engine 

is revved 

Check fan clutch 

for slippage (if fitted) 

The most common cause of over-heating is internal 

radiator blockage. This can be caused by old age and 

scale build-up or a chemical reaction caused by mixing 

coolants or inhibitors. Chemical fouling of the radiator 

can occur in a very short period of time. This radiator 

will need professional cleaning by a radiator specialist 

as normal flushing compounds are ineffective at removing 

chemical fouling. 

Check fuel air mixture 

A lean mixture can lead 

to over-heating 

Check brakes for any binding 

or over adjustment 

Check automatic transmission 

adjustment if the transmission 

is radiator cooled 

Check for blocked muffler or a 

restriction of any kind in the 

exhaust system 

These problems are the less common ones and can 

be difficult to isolate. Take the vehicle to a qualified 

mechanic for assessment. 

Extremely high compressions are usually found on 

rebuilt and heavily modified engines. High compressions 

can cause over-heating. 

Check cylinder 

compression ratios 

* The above data/information is provided by and remains the intellectual property of Tectaloy. 

For queries please ring Tectaloy Freecall on 1800 816 132 or visit www.tectaloy.com 

Page 62

Quick Coolant Summary Points 

01) DO NOT MIX COOLANTS OR INHIBITORS 

Never mix coolants or corrosion inhibitors. A mixture of incompatible coolants can induce 

radiator fouling and severe over-heating. Secondly, a mixture of coolants or inhibitors can 

actually reduce the effectiveness of the corrosion protection afforded to the vehicle. 

02) FOAMING COOLANTS CAUSE CAVITATION EROSION 

A coolant that foams can induce accelerated cavitation erosion of the water pump and water 

pump backing plates. If a product has a tendency to foam, you can usually pick it by shaking the 

bottle and counting 5 seconds. If the foam has broken and the fluid is returned to normal, this 

product probably won't foam in the cooling system. If the foam has not broken after 5 seconds, 

it might pay to find another product. 

03) NEVER UNDERTREAT A COOLING SYSTEM WITH A COOLANT OR INHIBITOR 

If you do not use the recommended dose ratio of a coolant or inhibitor you can actually 

accelerate corrosion to above that of plain water. Do it right or don't do it all. 

04) USED COOLANTS ARE NOT ENVIRONMENTALLY FRIENDLY 

Any cooling fluid that circulates in an automotive cooling system will pick up heavy metals. 

The disposal of a fluid containing heavy metal will contravene the E.P.A. regulations. Do not 

be confused by certain coolant brands that claim they are environmentally friendly. 

05) USE ONLY THE BEST QUALITY WATER AVAILABLE 

When mixing Anti Freeze/Anti-Boil or any corrosion inhibitor concentrate use the best pure 

quality water available as this will ensure the extended life of the product. The preferred water 

is demineralised. Do not use spring or bore water. 

06) CHECK FOR THE PRESENCE OF STRAY CURRENT IN THE COOLANT 

If a vehicle is suffering from repeated and accelerated corrosion, especially in aluminium 

radiators always remember to check for the presence of stray current. An analog multi-meter 

is all that is required for preliminary testing. 

07) REAL COOLANT CONTAINS ETHYLENE GLYCOL 

Based on the vehicle manufacturers' recommendations world wide, all coolants classed as 

suitable for use in their vehicles will have an Ethylene or Propylene Glycol base. Failure to use 

a Glycol based coolant in newer vehicles could void warrantee should the cooling system fail. 

08) TECTALOY IS AVAILABLE NATIONALLY 

National availability is very important to your customer, as you realise coolants can not be 

mixed, so it's important that you use a product your customer can purchase Australia wide. 

If your customer can not purchase top up coolant out of the state they may have to drain 

and replace the entire cooling system. 

09) ALWAYS USE COOLANT SERVICE STICKERS 

Use the service stickers supplied by coolant manufacturers to avoid coolant type confusion 

when top up coolant is required. 

*The above data/information is provided by and remains the intellectual property of Tectaloy. 


Page 63

Electrocution & Stray Current 

Death By Electrocution 

Stray Current Corrosion 

Stray Current Corrosion is a killer of cooling system 

components. This form of corrosion can perforate 

an aluminium radiator in a matter of weeks. It could 

damage an aluminium cylinder head or a brass/copper 

radiator in months. 

Stray Current Corrosion is usually very localised and 

severe. The rest of the cooling system can appear 

brand new. Before you assume it's a coolant failure 

ask yourself these questions. 

1 Are there any other signs of corrosion in the 

cooling system 

2 Is the coolant dirty and old looking 

3 If the vehicle was running plain water would you 

have expected the component to fail in such a 

short time 

If the answer to all of the above is No, there is a 

strong possibility that the vehicle has stray current 

passing through the coolant causing accelerated 

corrosion. 

Stray currents in the coolant are usually caused as 

a result of the earth path for some component being 

altered, a faulty earth strap or mounting point, after 

market accessories fitted incorrectly or a fault in the 

wiring loom. 

Today's vehicles are a literal jungle of wires and 

electronic components, so this form of accelerated 

corrosion is becoming more prevalent. Any vehicle 

that has undergone any disruption of it's electrical 

system should be checked for stray current before 

being put back on the road. 

Vehicles that have been accident damaged, had 

engine rebuilds, radiator or electronic cooling fans 

replaced or any after market electrical component 

fitted all fall into this category. It is also a good idea 

to check the cooling system for current leakage 

at normal service intervals to help prevent future 

corrosion problems. 

How To Test For Stray Current 

As this form of corrosion is virtually invisible until 

it's too late, Tectaloy went to work and evaluated 

several different methods of testing cooling systems 

for current flow. The end result was a simple yet very 

effective method of testing using a standard analogue 

multi-meter. 

Step 1: Remove the radiator cap from the vehicle 

when safe to do so. 

Step 2: Turn your multi-meter to mV range. 

Step 3: Insert the positive lead of your multi-meter 

into the coolant. (Be sure not to touch the 

metal of the radiator). 

Step 4: Connect the negative lead of your 

multi-meter to the earth pole of the 

battery if possible. 

Step 5: Check your meter for a reading above 

50mV. Any reading above 50mV should 

be considered potentially corrosive. 

Step 6: Turn on the vehicle's accessories one 

at a time and check your meter, if any 

accessories cause a high reading then 

this item probably has a faulty earth path. 

Accessories include head lights, indicators, car heater, 

electric fans, windscreen wipers, brake lights, radio, 

mobile phone chargers, etc. 

Page 64

Coolant pH Readings 

The Importance Of Coolant pH Readings 

pH readings are no more than just an indication of how acid or alkaline (caustic) substances are. The pH of 

a cooling system fluid is quite simple to read with either a small electronic pH meter or litmus paper. Litmus 

paper is considered to be a little less accurate, but will give a good indication. 

pH readings go from 1 to 14, 1 being extremely acid and 14 extremely alkaline (caustic), pH 7 is considered 

neutral and is neither acid nor alkaline. 

The table below shows the pH ranges considered normal for the majority of coolants and corrosion inhibitors 

running in vehicle cooling systems: 

pH Value 

Opinion 

1 Extremely dangerous, Raw Acid. Replace coolant immediately. 

2 Extremely dangerous, Strong Acid. Replace coolant immediately. 

3 Extremely dangerous, Acidic. Replace coolant immediately. 

4 Dangerous, Mild Acid. Replace coolant immediately. 

5 Unacceptable, Mildly Acid. Replace coolant immediately. 

6 Unacceptable, Mildly Acidic. Replace coolant ASAP. 

7 Questionable, Neutral. Probably not functioning. Replace coolant. 

8 Acceptable. 

9 Acceptable. 

10 

Acceptable, Alkaline. Some coolant inhibitor systems function very well at this pH 

eg. GMH specification HN2043 coolant. 

11 Unacceptable, Mildly Alkaline. Replace coolant. 

12 Dangerous, Highly Alkaline. Replace coolant. 

13 Extremely dangerous, Highly Alkaline. Replace coolant immediately. 

14 Extremely dangerous, Caustic. Replace coolant immediately. 

The normal running pH scope for coolants and corrosion inhibitors falls between pH 7.5 and pH 9.5. 

There are inhibitor systems that can function outside of these parameters but they are in the minority. 

The manufacturers of the coolants and inhibitors will be able to tell you the acceptable pH ranges 

for their products. 

* The above data/information is provided by and remains the intellectual property of Tectaloy. 


Page 65

Troubleshooting – Common water pump 

failures and their causes 

Leaking or Seepage from the Weep Hole 

Leaking or seepage from the weep hole is a sure sign of 

seal failure. The life of the seal can be greatly extended 

by performing regular maintenance of your cooling system. 

Periodic inspection of hoses and coolant recovery tank will 

assure coolant levels are correct and that no atmospheric 

contaminants that can cause oxidation and sludge 

build-up are present. Sludge build-up in the cooling system 

is a primary cause of seal failure as well as reduced cooling 

system efficiency. 

The water pump seal is delicate, rust and core residue will 

cause the seal to corrode and leak prematurely. 

Noise near the Water Pump 

Often noises are mistaken as being the water pump when 

in most cases they are caused by slippage of the fan belt 

on the pulleys (refer to fan belt tension). In rare cases if the 

noise is from the water pump, adding soluble oil into the 

radiator may eliminate this problem. It is common when 

checking a water pump and turning it by hand that it makes 

a squeaking sound from the mechanical seal area. This 

disappears when the pump is filled with water. 

Broken Water Pump Housings and Shafts 

are commonly caused by excessive 

vibration and unbalance due to: 

• Bent, cracked or broken fan; 

• Fan not squarely mounted on the shaft; 

• Cracked or bent pulleys due to improper installation. 

Fan Clutches 

When a water pump fails, the fan clutch usually fails. 

The water pump and fan clutch share the same shaft. 

Should the water pump bearing fail, the fan clutch bearing 

generally also fails and both must be replaced. 

The fan clutch is designed to “drive” the fan blade when air 

is needed to cool the engine. It is also designed to take fan 

blade “load” from the engine when additional air movement 

is not needed. 

Since noises are often 

caused by fan belt 

slippage it is important 

that quality fan belts 

are used. 

Fan Belt Tension 

Problems will arise if the fan belt tension is too loose or 

too tight. Ensure the correct tools are used for the job and 

adjust the fan belt to the correct tension specified by the 

vehicle manufacturer. 

Replace the fan clutch when: 

1. Engine overheating – fan spins freely – does not 

engage. 

2. Excessive fan clutch play – manually move the fan 

back and forth. If there is more than 1/4" play the clutch 

bearing is worn. 

3. Greasy build up – Look for greasy dirt on the fan 

clutch. Check for fluid leakage around the outer edge 

and at centre of thermostat spring. 

4. Excessive slippage – A hot engine in the “off” position 

which allows easy revolving of the fan manually, from 

1 to 1 revolutions indicates a weak clutch. 

5. Freezing up – If the fan blade cannot be rotated by 

hand, or if hand rotation makes a harsh, rumbling noise, 

the fan clutch bearing has failed. 

If the belt tension is too great it will result in overloading the 

water pump bearing, causing premature failure and possible 

cracking of the pump casing. Insufficient tension will result in 

overheating as the belt slippage on the water pump will not 

circulate the correct volume of water required to cool 

the engine. 

6. Shaft vibration – The fan clutch is mounted on the 

water pump between the water pump shaft and the fan. 

Any vibration can mean a worn bearing in the water 

pump or fan clutch. Since the fan clutch and water 

pump have about the same life span, it generally makes 

sense to replace both at the same time. Unless there 

are obvious signs of damage, it is seldom necessary to 

replace the fan when installing a new clutch. 

Page 66

Notes 

Page 67

Page 68 

Notes

Water Pump Catalogue - Repco Trade Zone

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?