Gasmizer Manual - Submarine Manufacturing and Products Ltd

More documents

Recommendations

Info

March 2009 (Intentionally Blank) Chap 2 Page 16 of 168 OM002 Rev 5
March 2009 CHAPTER 3 DIVER EQUIPMENT NOTE Insert applicable Helmet/Bandmask Manual from the list below. Product Description Manual A10170 17C/Ultrajewl 601 OM056 A10290 17B/Ultrajewel 601 OM143 A10370 18B/Helinaut 350 OM048 A10380 17B/Helinaut 350 OM048 A10520 18B/Helinaut 500 OM050 A10530 17B/Helinaut 500 OM050 Chap 3 Page 17 of 168 OM002 Rev 5
Page 1 and 2: Rev 5 OPERATING AND MAINTENANCE MAN
Page 3 and 4: March 2009 Approval Sheet DIVEX DOC
Page 5 and 6: March 2009 Table of Contents CHAPTE
Page 7 and 8: March 2009 Disclaimer NOTE Although
Page 9 and 10: March 2009 CHAPTER 1 INTRODUCTION C
Page 11 and 12: March 2009 Fig 1 Layout and Operati
Page 13 and 14: March 2009 setting of the regulator
Page 15 and 16: March 2009 Fig 5 HP Gas System Sche
Page 17 and 18: March 2009 at an early stage such t
Page 19 and 20: March 2009 1.9 Safety and Gas Quali
Page 21 and 22: March 2009 CHAPTER 2 SYSTEM INTERCO
Page 23: March 2009 Fig 2 Electric Gasmizer
Page 27 and 28: March 2009 CHAPTER 4 BELL EQUIPMENT
Page 29 and 30: March 2009 4.1.2 The overall layout
Page 31 and 32: March 2009 4.2.3 If the diver gas s
Page 33 and 34: March 2009 4.3.4 The negative press
Page 35 and 36: March 2009 accordingly. This is acc
Page 37 and 38: March 2009 4.8 Water Trap Inspectio
Page 39 and 40: March 2009 Fig 6 Pipework Schematic
Page 41 and 42: March 2009 Fig 8 Water Trap Assembl
Page 43 and 44: March 2009 Fig 10 SAECO Valve Assem
Page 45 and 46: March 2009 Fig 12 Outward Relief Va
Page 47 and 48: March 2009 Fig 14 Inward Relief Val
Page 49 and 50: March 2009 Fig 16 Float/Check Valve
Page 51 and 52: March 2009 CHAPTER 5 REPROCESSING U
Page 53 and 54: March 2009 Filters/Moisture Separat
Page 55 and 56: March 2009 range of trace contamina
Page 57 and 58: March 2009 Fig 4 Canister Assembly
Page 59 and 60: March 2009 Fig 6 Back pressure Regu
Page 61 and 62: March 2009 Fig 8 Receiver Adapter A
Page 63 and 64: March 2009 Fig 10 Flow Switch Assem
Page 65 and 66: March 2009 Fig 12 Pressure Regulato
Page 67 and 68: March 2009 CHAPTER 6 CONTROL CONSOL
Page 69 and 70: March 2009 sample is monitored and,
Page 71 and 72: March 2009 6.5 Make-Up Panel 11.The
Page 73 and 74: March 2009 The tools required for c
Page 75 and 76:
March 2009 When performing necessar
Page 77 and 78:
March 2009 Fig 6 Flow Switch Assemb
Page 79 and 80:
March 2009 Fig 8 RP202 Regulator, P
Page 81 and 82:
March 2009 CHAPTER 7 VOLUME TANK CO
Page 83 and 84:
March 2009 CHAPTER 8 SYSTEM INSTALL
Page 85 and 86:
March 2009 8.2.4 Recommended Umbili
Page 87 and 88:
March 2009 8.4 GASMIZER BELL CARD 8
Page 89 and 90:
March 2009 8.5 GASMIZER BELL CARD -
Page 91 and 92:
March 2009 8.5.4 Shutdown Procedure
Page 93 and 94:
March 2009 8.5.7 Gasmizer Response
Page 95 and 96:
March 2009 PARTIAL PRESSURE OXYGEN
Page 97 and 98:
March 2009 8.6 REGULATOR SETTING GU
Page 99 and 100:
March 2009 8.7 REGULATOR SETTING GU
Page 101 and 102:
March 2009 8.8 System Operation at
Page 103 and 104:
March 2009 Remedy: Diving may be co
Page 105 and 106:
March 2009 CHAPTER 9 GAS BOOSTER CO
Page 107 and 108:
March 2009 Dive Depth (m) Inlet Pre
Page 109 and 110:
March 2009 9.1.4 Main Gas Circuit F
Page 111 and 112:
March 2009 9.2 Booster Starter Cont
Page 113 and 114:
March 2009 Period Every 2000 Hours
Page 115 and 116:
March 2009 Approximate full load cu
Page 117 and 118:
March 2009 Servicing Disassembly: 1
Page 119 and 120:
March 2009 9.9.2 2 nd Stage Cylinde
Page 121 and 122:
March 2009 Guide Ring Axial Thickne
Page 123 and 124:
March 2009 Re-assembly: 1. Assemble
Page 125 and 126:
March 2009 Disassembly: (Having dis
Page 127 and 128:
March 2009 9.11 Relief Valves Maint
Page 129 and 130:
March 2009 Fig 6 K651/454 Compresso
Page 131 and 132:
March 2009 K651/454 Compressor Part
Page 133 and 134:
March 2009 Part No. Description Qty
Page 135 and 136:
March 2009 A.i 4 1/4” Dia Cylinde
Page 137 and 138:
March 2009 A.ii 2 5/8” Dia Cylind
Page 139 and 140:
March 2009 Fig 9 2 5/8” Dia Cylin
Page 141 and 142:
March 2009 Fig 10 Crankcase Assembl
Page 143 and 144:
March 2009 A.v Suction Valve BU6024
Page 145 and 146:
March 2009 A.vii Unloader Valve Ass
Page 147 and 148:
March 2009 Fig 14 Cooler Water Pump
Page 149 and 150:
March 2009 B.i Cooler (After cooler
Page 151 and 152:
March 2009 APPENDIX D - AUXILIARY E
Page 153 and 154:
March 2009 Part No. Description Qty
Page 155 and 156:
March 2009 APPENDIX F - PRESSURE CO
Page 157 and 158:
March 2009 Fig 20 Stage 2 - Relief
Page 159 and 160:
March 2009 Chap 9 Page 151 of 168 O
Page 161 and 162:
March 2009 Dive Depth (m) Pressure
Page 163 and 164:
March 2009 Fig 23 Belt Drive Tensio
Page 165 and 166:
March 2009 168 CHAPTER 10 SPARES LI
Page 167 and 168:
March 2009 168 Part Assembly - C107
Page 169 and 170:
March 2009 168 Part Assembly - C108
Page 171 and 172:
March 2009 168 Part No. Description
Page 173 and 174:
March 2009 168 Post 2004 (Divex Bui
Page 175 and 176:
March 2009 168 VB602 VALVE,BALL, 3/
show all

Gasmizer Manual - Submarine Manufacturing and Products Ltd

Create successful ePaper yourself

Delete template?

Save as template?