Gasmizer Manual - Submarine Manufacturing and Products Ltd

More documents

Recommendations

Info

March 09 Part Assembly – B10400 10.1.5 ELECTRIC GAS BOOSTER Part No. Description Size Quantity EM091 ELEC,BULBS FOR EM075 &EM076 6.3V/0.3A 5.00 EM092 ELEC,TRANSFORMER,MTL 110Vac 1.00 EM093 ELEC,SWITCH,CONTACT SET,MTC 1.00 GC064 EGC,O RING SEAL 24MM ID/30MM 2.00 OD GC065 EGC, U RING SEAL 2.00 GC164 EGC,SERVICE KIT WATER PUMP 1.00 GE001 EGB,SPRING 1.00 GE002 EGB,BEARING,NEEDLE ROLLER 2.00 GE003 EGB,ST.1 PISTON RING 7.00 GE004 EGB,GUIDE RING 1.00 GE005 EGB,PISTON RING 7.00 GE006 EGB,GUIDE RING 1.00 GE007 EGB,CIRCLIP 4.00 GE009 EGB, O RING,PRESS. PACKING 2.00 GE010 EGB, WIPER PACKINGS 2.00 GE011 EGB,VALVE ASSY 1.00 GE012 EGB, VALVE ASSY 1.00 GE013 EGB, VALVE ASSY 1.00 GE014 EGB,SHELLS 2.00 GE015 EGB,WASHER,TAB LOCK 4.00 GE016 EGB,BUSH 4.00 GE017 EGB,CNTR,BEARING SHELL 1.00 GE018 EGB,THRUST WASHER 2.00 GE020 EGB,VALVE UNLOADER 1.00 GE021 EGB,SPRING 2.00 GE022 EGB,GASKET 2.00 GE023 EGB,GASKET 2.00 GE024 EGB,GASKET 2.00 GE025 EGB,GASKET 1.00 GE026 EGB,GASKET 2.00 GE027 EGB,GASKET 2.00 GE028 EGB,GASKET 1.00 GE029 EGB,GASKET 1.00 GE030 EGB,GASKET 2.00 GE031 EGB, O RING 1.00 GE032 EGB, O RING 4.00 GE033 EGB, O RING 1.00 OM002 Rev 5 Page 162 of 168 Chap 10
March 2009 168 Part No. Description Size Quantity GE034 EGB, O RING 4.00 GE035 EGB, O RING 2.00 GE036 EGB, O RING 2.00 GE037 EGB, O RING 2.00 GE038 EGB, O RING 1.00 GE039 EGB, O RING 2.00 GE041 EGB, O RING 4.00 GE042 EGB, OIL SEAL 1.00 GE050 EGB, CONTROL FUSE 2.00 GE051 EGB,RELAY 1.00 GE052 EGB, CONTACTOR 1.00 GE053 EGB, SEAL 2.00 GE055 EGB,SOFT SPARES KIT 1.00 GE056 EGB,VALVE ASSY 581540 1.00 GE057 EGB,VALVE SPRING ST29168 1.00 GE058 EGB, O RING,PISTON ST30121 1.00 Chap 10 Page 163 of 168 OM002 Rev 5
Page 1 and 2:
Rev 5 OPERATING AND MAINTENANCE MAN
Page 3 and 4:
March 2009 Approval Sheet DIVEX DOC
Page 5 and 6:
March 2009 Table of Contents CHAPTE
Page 7 and 8:
March 2009 Disclaimer NOTE Although
Page 9 and 10:
March 2009 CHAPTER 1 INTRODUCTION C
Page 11 and 12:
March 2009 Fig 1 Layout and Operati
Page 13 and 14:
March 2009 setting of the regulator
Page 15 and 16:
March 2009 Fig 5 HP Gas System Sche
Page 17 and 18:
March 2009 at an early stage such t
Page 19 and 20:
March 2009 1.9 Safety and Gas Quali
Page 21 and 22:
March 2009 CHAPTER 2 SYSTEM INTERCO
Page 23 and 24:
March 2009 Fig 2 Electric Gasmizer
Page 25 and 26:
March 2009 CHAPTER 3 DIVER EQUIPMEN
Page 27 and 28:
March 2009 CHAPTER 4 BELL EQUIPMENT
Page 29 and 30:
March 2009 4.1.2 The overall layout
Page 31 and 32:
March 2009 4.2.3 If the diver gas s
Page 33 and 34:
March 2009 4.3.4 The negative press
Page 35 and 36:
March 2009 accordingly. This is acc
Page 37 and 38:
March 2009 4.8 Water Trap Inspectio
Page 39 and 40:
March 2009 Fig 6 Pipework Schematic
Page 41 and 42:
March 2009 Fig 8 Water Trap Assembl
Page 43 and 44:
March 2009 Fig 10 SAECO Valve Assem
Page 45 and 46:
March 2009 Fig 12 Outward Relief Va
Page 47 and 48:
March 2009 Fig 14 Inward Relief Val
Page 49 and 50:
March 2009 Fig 16 Float/Check Valve
Page 51 and 52:
March 2009 CHAPTER 5 REPROCESSING U
Page 53 and 54:
March 2009 Filters/Moisture Separat
Page 55 and 56:
March 2009 range of trace contamina
Page 57 and 58:
March 2009 Fig 4 Canister Assembly
Page 59 and 60:
March 2009 Fig 6 Back pressure Regu
Page 61 and 62:
March 2009 Fig 8 Receiver Adapter A
Page 63 and 64:
March 2009 Fig 10 Flow Switch Assem
Page 65 and 66:
March 2009 Fig 12 Pressure Regulato
Page 67 and 68:
March 2009 CHAPTER 6 CONTROL CONSOL
Page 69 and 70:
March 2009 sample is monitored and,
Page 71 and 72:
March 2009 6.5 Make-Up Panel 11.The
Page 73 and 74:
March 2009 The tools required for c
Page 75 and 76:
March 2009 When performing necessar
Page 77 and 78:
March 2009 Fig 6 Flow Switch Assemb
Page 79 and 80:
March 2009 Fig 8 RP202 Regulator, P
Page 81 and 82:
March 2009 CHAPTER 7 VOLUME TANK CO
Page 83 and 84:
March 2009 CHAPTER 8 SYSTEM INSTALL
Page 85 and 86:
March 2009 8.2.4 Recommended Umbili
Page 87 and 88:
March 2009 8.4 GASMIZER BELL CARD 8
Page 89 and 90:
March 2009 8.5 GASMIZER BELL CARD -
Page 91 and 92:
March 2009 8.5.4 Shutdown Procedure
Page 93 and 94:
March 2009 8.5.7 Gasmizer Response
Page 95 and 96:
March 2009 PARTIAL PRESSURE OXYGEN
Page 97 and 98:
March 2009 8.6 REGULATOR SETTING GU
Page 99 and 100:
March 2009 8.7 REGULATOR SETTING GU
Page 101 and 102:
March 2009 8.8 System Operation at
Page 103 and 104:
March 2009 Remedy: Diving may be co
Page 105 and 106:
March 2009 CHAPTER 9 GAS BOOSTER CO
Page 107 and 108:
March 2009 Dive Depth (m) Inlet Pre
Page 109 and 110:
March 2009 9.1.4 Main Gas Circuit F
Page 111 and 112:
March 2009 9.2 Booster Starter Cont
Page 113 and 114:
March 2009 Period Every 2000 Hours
Page 115 and 116:
March 2009 Approximate full load cu
Page 117 and 118:
March 2009 Servicing Disassembly: 1
Page 119 and 120: March 2009 9.9.2 2 nd Stage Cylinde
Page 121 and 122: March 2009 Guide Ring Axial Thickne
Page 123 and 124: March 2009 Re-assembly: 1. Assemble
Page 125 and 126: March 2009 Disassembly: (Having dis
Page 127 and 128: March 2009 9.11 Relief Valves Maint
Page 129 and 130: March 2009 Fig 6 K651/454 Compresso
Page 131 and 132: March 2009 K651/454 Compressor Part
Page 133 and 134: March 2009 Part No. Description Qty
Page 135 and 136: March 2009 A.i 4 1/4” Dia Cylinde
Page 137 and 138: March 2009 A.ii 2 5/8” Dia Cylind
Page 139 and 140: March 2009 Fig 9 2 5/8” Dia Cylin
Page 141 and 142: March 2009 Fig 10 Crankcase Assembl
Page 143 and 144: March 2009 A.v Suction Valve BU6024
Page 145 and 146: March 2009 A.vii Unloader Valve Ass
Page 147 and 148: March 2009 Fig 14 Cooler Water Pump
Page 149 and 150: March 2009 B.i Cooler (After cooler
Page 151 and 152: March 2009 APPENDIX D - AUXILIARY E
Page 153 and 154: March 2009 Part No. Description Qty
Page 155 and 156: March 2009 APPENDIX F - PRESSURE CO
Page 157 and 158: March 2009 Fig 20 Stage 2 - Relief
Page 159 and 160: March 2009 Chap 9 Page 151 of 168 O
Page 161 and 162: March 2009 Dive Depth (m) Pressure
Page 163 and 164: March 2009 Fig 23 Belt Drive Tensio
Page 165 and 166: March 2009 168 CHAPTER 10 SPARES LI
Page 167 and 168: March 2009 168 Part Assembly - C107
Page 169: March 2009 168 Part Assembly - C108
Page 173 and 174: March 2009 168 Post 2004 (Divex Bui
Page 175 and 176: March 2009 168 VB602 VALVE,BALL, 3/
show all

Gasmizer Manual - Submarine Manufacturing and Products Ltd

Create successful ePaper yourself

Delete template?

Save as template?