Gasmizer Manual - Submarine Manufacturing and Products Ltd

More documents

Recommendations

Info

March 09 Fig 15 Stage 2 Cooler (After cooler) OM002 Rev 5 Page 140 of 168 Chap 9
March 2009 B.i Cooler (After cooler) - 2 nd Stage Part No. Description Qty Ref. Other Part No. W14916/6 Cooler body assembly 1 1 - 40923/3* Cooler end plate (inlet) 1 2 -DX3705 40922/1 Cooler end plate (outlet) 1 3 -DX5621 40925 End plate gasket (inlet) 1 4 GE028 40924 End plate gasket 1 5 GE029 BLP/22 Bolt 5/8” UNC 2 6 BL9/22 BL9/21 Bolt 5/8” UNC 1 7 - BL9/24 Bolt 5/8” UNC 5 8 -GC542 BL9/65 Bolt 5/8” UNC 2 9 -GC544 4617/8 Plug 1 10 - Chap 9 Page 141 of 168 OM002 Rev 5
Page 1 and 2:
Rev 5 OPERATING AND MAINTENANCE MAN
Page 3 and 4:
March 2009 Approval Sheet DIVEX DOC
Page 5 and 6:
March 2009 Table of Contents CHAPTE
Page 7 and 8:
March 2009 Disclaimer NOTE Although
Page 9 and 10:
March 2009 CHAPTER 1 INTRODUCTION C
Page 11 and 12:
March 2009 Fig 1 Layout and Operati
Page 13 and 14:
March 2009 setting of the regulator
Page 15 and 16:
March 2009 Fig 5 HP Gas System Sche
Page 17 and 18:
March 2009 at an early stage such t
Page 19 and 20:
March 2009 1.9 Safety and Gas Quali
Page 21 and 22:
March 2009 CHAPTER 2 SYSTEM INTERCO
Page 23 and 24:
March 2009 Fig 2 Electric Gasmizer
Page 25 and 26:
March 2009 CHAPTER 3 DIVER EQUIPMEN
Page 27 and 28:
March 2009 CHAPTER 4 BELL EQUIPMENT
Page 29 and 30:
March 2009 4.1.2 The overall layout
Page 31 and 32:
March 2009 4.2.3 If the diver gas s
Page 33 and 34:
March 2009 4.3.4 The negative press
Page 35 and 36:
March 2009 accordingly. This is acc
Page 37 and 38:
March 2009 4.8 Water Trap Inspectio
Page 39 and 40:
March 2009 Fig 6 Pipework Schematic
Page 41 and 42:
March 2009 Fig 8 Water Trap Assembl
Page 43 and 44:
March 2009 Fig 10 SAECO Valve Assem
Page 45 and 46:
March 2009 Fig 12 Outward Relief Va
Page 47 and 48:
March 2009 Fig 14 Inward Relief Val
Page 49 and 50:
March 2009 Fig 16 Float/Check Valve
Page 51 and 52:
March 2009 CHAPTER 5 REPROCESSING U
Page 53 and 54:
March 2009 Filters/Moisture Separat
Page 55 and 56:
March 2009 range of trace contamina
Page 57 and 58:
March 2009 Fig 4 Canister Assembly
Page 59 and 60:
March 2009 Fig 6 Back pressure Regu
Page 61 and 62:
March 2009 Fig 8 Receiver Adapter A
Page 63 and 64:
March 2009 Fig 10 Flow Switch Assem
Page 65 and 66:
March 2009 Fig 12 Pressure Regulato
Page 67 and 68:
March 2009 CHAPTER 6 CONTROL CONSOL
Page 69 and 70:
March 2009 sample is monitored and,
Page 71 and 72:
March 2009 6.5 Make-Up Panel 11.The
Page 73 and 74:
March 2009 The tools required for c
Page 75 and 76:
March 2009 When performing necessar
Page 77 and 78:
March 2009 Fig 6 Flow Switch Assemb
Page 79 and 80:
March 2009 Fig 8 RP202 Regulator, P
Page 81 and 82:
March 2009 CHAPTER 7 VOLUME TANK CO
Page 83 and 84:
March 2009 CHAPTER 8 SYSTEM INSTALL
Page 85 and 86:
March 2009 8.2.4 Recommended Umbili
Page 87 and 88:
March 2009 8.4 GASMIZER BELL CARD 8
Page 89 and 90:
March 2009 8.5 GASMIZER BELL CARD -
Page 91 and 92:
March 2009 8.5.4 Shutdown Procedure
Page 93 and 94:
March 2009 8.5.7 Gasmizer Response
Page 95 and 96:
March 2009 PARTIAL PRESSURE OXYGEN
Page 97 and 98: March 2009 8.6 REGULATOR SETTING GU
Page 99 and 100: March 2009 8.7 REGULATOR SETTING GU
Page 101 and 102: March 2009 8.8 System Operation at
Page 103 and 104: March 2009 Remedy: Diving may be co
Page 105 and 106: March 2009 CHAPTER 9 GAS BOOSTER CO
Page 107 and 108: March 2009 Dive Depth (m) Inlet Pre
Page 109 and 110: March 2009 9.1.4 Main Gas Circuit F
Page 111 and 112: March 2009 9.2 Booster Starter Cont
Page 113 and 114: March 2009 Period Every 2000 Hours
Page 115 and 116: March 2009 Approximate full load cu
Page 117 and 118: March 2009 Servicing Disassembly: 1
Page 119 and 120: March 2009 9.9.2 2 nd Stage Cylinde
Page 121 and 122: March 2009 Guide Ring Axial Thickne
Page 123 and 124: March 2009 Re-assembly: 1. Assemble
Page 125 and 126: March 2009 Disassembly: (Having dis
Page 127 and 128: March 2009 9.11 Relief Valves Maint
Page 129 and 130: March 2009 Fig 6 K651/454 Compresso
Page 131 and 132: March 2009 K651/454 Compressor Part
Page 133 and 134: March 2009 Part No. Description Qty
Page 135 and 136: March 2009 A.i 4 1/4” Dia Cylinde
Page 137 and 138: March 2009 A.ii 2 5/8” Dia Cylind
Page 139 and 140: March 2009 Fig 9 2 5/8” Dia Cylin
Page 141 and 142: March 2009 Fig 10 Crankcase Assembl
Page 143 and 144: March 2009 A.v Suction Valve BU6024
Page 145 and 146: March 2009 A.vii Unloader Valve Ass
Page 147: March 2009 Fig 14 Cooler Water Pump
Page 151 and 152: March 2009 APPENDIX D - AUXILIARY E
Page 153 and 154: March 2009 Part No. Description Qty
Page 155 and 156: March 2009 APPENDIX F - PRESSURE CO
Page 157 and 158: March 2009 Fig 20 Stage 2 - Relief
Page 159 and 160: March 2009 Chap 9 Page 151 of 168 O
Page 161 and 162: March 2009 Dive Depth (m) Pressure
Page 163 and 164: March 2009 Fig 23 Belt Drive Tensio
Page 165 and 166: March 2009 168 CHAPTER 10 SPARES LI
Page 167 and 168: March 2009 168 Part Assembly - C107
Page 169 and 170: March 2009 168 Part Assembly - C108
Page 171 and 172: March 2009 168 Part No. Description
Page 173 and 174: March 2009 168 Post 2004 (Divex Bui
Page 175 and 176: March 2009 168 VB602 VALVE,BALL, 3/
show all

Gasmizer Manual - Submarine Manufacturing and Products Ltd

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?