EM3800SXâ¢EM5000SXâ¢EM6500SX - Geotech Environmental ...

More documents

Recommendations

Info

Storage Precautions If your generator will be stored with gasoline in the fuel tank and carburetor, it is important to reduce the hazard of gasoline vapor ignition. Select a well ventilated storage area away from any appliance that operates with a flame, such as a furnace, water heater, or clothes dryer. Also avoid any area with a spark-producing electric motor, or where power tools are operated. If possible, avoid storage areas with high humidity, because that promotes rust and corrosion. Unless all fuel has been drained from the fuel tank, leave the fuel valve in the OFF position to reduce the possibility of leakage. Place the generator on a level surface. Tilting can cause fuel or oil leakage. With the engine and exhaust system cool, cover the generator to keep out dust. A hot engine and exhaust system can ignite or melt some materials. Do not use sheet plastic as a dust cover. A nonporous cover will trap moisture around the generator, promoting rust and corrosion. Removal From Storage Check your generator as described in the PRE-OPERATION CHECK chapter of this manual (see page 30 ). If the fuel was drained during storage preparation, fill the tank with fresh gasoline. If you keep a container of gasoline for refueling, be sure that it contains only fresh gasoline. Gasoline oxidizes and deteriorates over time, causing hard starting. If the cylinder was coated with oil during storage preparation, the engine may smoke briefly at startup. This is normal. 48
TRANSPORTING When transporting the generator, turn the engine switch and the fuel valve OFF. Keep the generator level to prevent fuel spillage. Fuel vapor or spilled fuel may ignite. Contact with a hot engine or exhaust system can cause serious burns or fires. Let the engine cool before transporting or storing the generator. Take care not to drop or strike the generator when transporting. Do not place heavy objects on the generator. When transporting the generator by loading it on to a vehicle, secure to the generator frame as shown. 49
Page 1 and 2: EM3800SX•EM5000SX•EM6500SX See
Page 3 and 4: Congratulations on your selection o
Page 5 and 6: CONTENTS GENERATOR SAFETY .........
Page 7 and 8: GENERATOR SAFETY SAFETY LABEL LOCAT
Page 9 and 10: Electric Shock Hazards The generato
Page 11 and 12: TRANSPORT HANDLE FUEL TANK CAP FUEL
Page 13 and 14: Fuel Valve Lever The fuel valve is
Page 15 and 16: DC Terminals The DC terminals may O
Page 17 and 18: AC Circuit Breaker The AC circuit b
Page 19 and 20: GENERATOR USE Connections to a Buil
Page 21 and 22: AC Operation 1. Start the engine (s
Page 23 and 24: Voltage Selector Switch The power a
Page 29 and 30: An overloaded DC circuit, excessive
Page 31 and 32: High Altitude Operation At high alt
Page 33 and 34: Refueling With the engine stopped,
Page 35 and 36: STARTING THE ENGINE/STOPPING THE EN
Page 37 and 38: MAINTENANCE The Importance of Maint
Page 39 and 40: Maintenance Schedule REGULAR SERVIC
Page 41 and 42: Air Cleaner Service A dirty air cle
Page 43 and 44: Spark Plug Service In order to serv
Page 45 and 46: Fuse Replacement If the fuse is blo
Page 47 and 48: Service according to the table belo
Page 49: Engine Oil 1. Change the engine oil
Page 53 and 54: No electricity at the AC receptacle
Page 55 and 56: Problems That May Affect Emissions
Page 57 and 58: WIRING DIAGRAM EM3800SX 55
Page 59 and 60: SPECIFICATIONS Dimensions Model Typ
Page 61 and 62: Dimensions Model Type Description c
Page 63 and 64: Important Safety Precautions Make s
Page 65 and 66: Handle Installation Install the rig
Page 67 and 68: Hanger Kit Installation (optional)
Page 69 and 70: Remote Control Box PILOT LAMP START
Page 71 and 72: CABLE TIE STARTER SOLENOID STARTER
Page 73 and 74: BEFORE OPERATION Before using your
Page 75 and 76: Honda PUBLICATIONS Shop Manual This
Page 77 and 78: PRE-OPERATION CHECK ...............
Page 79: 00X31-Z21-6050 K2:EM5000SX

EM3800SXâ¢EM5000SXâ¢EM6500SX - Geotech Environmental ...

Create successful ePaper yourself

Delete template?

Save as template?

EM3800SXâ¢EM5000SXâ¢EM6500SX - Geotech Environmental ...