Prediction of batch heat transfer coefficients for pseudoplastic fluids ...

More documents

Recommendations

Info

TABLE A-5 (eollt. ) /12 o . 24;;& CARBOPOL TEMPERATURE SHEAR ST~SS ROTATIONAL SHEAR APPARENT (®C) (d-yE.es/em ) SP"RED RATE VISCOSITY (RP~.iI) (sec-I) (®ellltiJloise) 18.6 205 30 17~O 12tO 259 60 33.9 358 120 67.8 J2% 462 300 169..;5 272 . 628 .. 6,00 v IIIIILdI 4''''1 338 .. 2 .185: 25 .. 0 197 30 17 .. 1 1150 247 60 34.3 721 312 120 68.5 455 438 300 171 .. 3 256 593 600 342 .. 6 17~ . . • 41.8 172 30 17 .. 3 996 215 60 34 .. 6 622 2~1 120 69.1 392 3 3 300 172.7 222 ... 51g 600 345 .. 5 , ,lJA,8 d 59 .. 5 , , 30 16.8 859 ~ 60 33.'5 537 235 120 67.'1 350 327 300 167 .. 7 195 .W±2 600 3.35 .. 3 132 83 .. 5 130 30 18 .. ~ 707 157 60 36 .. 42~ 197 120 73 .. 8 26 274 300 183 .. 9 149 359 600 367.7 98
TABLE A-6 FLOW BEHAVIOR INDEX AND FLUID CONSISTENCY INDEX OF CARBOPOL SOLUTIONS FLUID TEJ:1PERATURE (@C) K (dynes 18.5 0.656 3.25 2.5.0 0.651 3.05 41.3 0 .. 681 2 .. 11 63.0 0 .. 720 1 .. 19 82.0 0.717 0.87 0.20% Carbopo1 17 .. 5 0.433 30 .. 1 25 .. 0 O.L~36 28 .. 1 ~.2 .. 7 0.422 23 .. 5 61 .. 7 0.427 18.3 83 .. 8 0.457 11.6 0.24% Carb0po1 18 .. 6 0.370 72.0 25.0 0.366 68 .. 2 41.8 0 .. 363 59 .. 7 59 .. 5 0.373 L~9 .. 2 83 .. 5 0 .. 341 46.7 sE!\e:rljem2)
Page 1 and 2:
Copyright Warning & Restrictions Th
Page 3 and 4:
PREDICTION OF BATCH HEAT TRANSFER C
Page 5 and 6:
while the latter has five to seven
Page 7 and 8:
ACKNOWLEDGEMENTS The auther ex~ress
Page 9 and 10:
Chapter 1: Chapter 2: Introducticm
Page 11 and 12:
LIST OF FIGURES page 2-1 FlGW Behav
Page 13 and 14:
CHAPTER I INTRODUCTION BATCH HEAT T
Page 15 and 16:
3 as pseudoplasticso Pseudoplastic
Page 17 and 18:
5 ~n addition to studying the effec
Page 19 and 20:
7 A B SLOPE = /'n- .( 10 ~y FIG 2-1
Page 21 and 22:
15.5, 183, 185).. Most of their eff
Page 23 and 24:
va:ry withl. the slaear I'Rte.. 11.
Page 25 and 26:
13 RHEOLOGIC_~ INVESTIGATION OFPO~~
Page 27 and 28:
IS In(s) (2-8 (2-9 where Re is the
Page 29 and 30:
'7 ft~ easier method of calibrating
Page 31 and 32:
19 of' thixotropic breakdown l'Ji t
Page 33 and 34:
21 complicated by a variable viscos
Page 35 and 36:
2J Schultz-GrQnow (174) used a dime
Page 37 and 38:
2S The results shm-red that equatio
Page 39 and 40:
Su.bstituti011 of equati 2-22 gives
Page 41 and 42:
29 In both Newtonian and non-Newton
Page 43 and 44:
31 for viscous pseudoplas tics at 1
Page 45 and 46:
33 (2-29 when both the distances ar
Page 47 and 48:
JS Thermometers or thermocouples ar
Page 49 and 50:
.37 2: a in in heat cQ@tent of the
Page 51 and 52:
J9 cooling mediu..:m side, the heat
Page 53 and 54:
41 ports a value of 3/4-.. He then
Page 55 and 56:
43 find the effects of one or two o
Page 57 and 58:
45 The group to the left of the equ
Page 59 and 60:
47 the highest heat tra...nsfer coe
Page 61 and 62:
49 A pitched blade turbine gave coe
Page 63 and 64:
SI done on the correlation of heat
Page 65 and 66:
5J evaluated at the wall temperatur
Page 67 and 68:
ss to (2-46 where ill is the consis
Page 69 and 70:
CHAPTER .2 DEVELOPMENT OF CORRELATI
Page 71 and 72:
momentum" mass" and energy may be ~
Page 73 and 74:
61 Vr;> Jt.- ,,"Ii'\... ..", ::: (V
Page 75 and 76:
63 Substitution of these dimensionl
Page 77 and 78:
l/(R + 1) and was able t@ elim.iE.a
Page 79 and 80:
67 All of the variables and differe
Page 81 and 82:
69 The average heat transfer coeffi
Page 83 and 84:
N"v = C Iv''' (;';~-"')&'i'~ (%t-n,
Page 85 and 86:
73 Semi-Empirical Correlation i ..,
Page 87 and 88:
75 7I1C1?/lfOCOUPLc .JuNe T/ON IMBE
Page 89 and 90:
77 _I"---- / SCALE I ~~, .5 j t /Z.
Page 91 and 92:
also cop~ected to the pipes leading
Page 93 and 94:
81 Ve8sel :J all th:l c]me 8 8 .) '
Page 95 and 96:
83 potentiometer for varing the mot
Page 97 and 98:
85 MATERIAL 7:0 STAIIJLESS STEEL /
Page 99 and 100:
11 Wa.ll (Mi€1dl~) Same as #5 81
Page 101 and 102:
89 shea.r ra.tes, tl?1ey a.re unaff
Page 103:
and if' lO"V'l$' a sm.all amount of
Page 106 and 107:
94- was about 40-45 ndmutes .. Tke
Page 108 and 109:
96 vThere N is in rev./sec .. and S
Page 110 and 111:
88 ql\fETI A = 6 T \--T -s L/kw (1+
Page 112 and 113:
I {)D The generalized Reynolds n~mb
Page 114 and 115:
02. CHAPTER !2. RESUI,TS Many heat
Page 116 and 117:
01 TABLE 5-2 sutn~U{Y OF ADDITIONAL
Page 118 and 119:
108 the batch than the other ticJO
Page 120 and 121:
108 optimum impeller heights were u
Page 122 and 123:
10 I r "'" , •• ,'., "",' """",
Page 124 and 125:
112 correlations for the prediction
Page 126 and 127:
TABLE 5 - 4 Correlation Constants A
Page 128 and 129:
1/6 Table 5-5 and 5-6. A measure of
Page 130 and 131:
TABLE S - 6 IMPELLER Correlation Co
Page 132 and 133:
120 greater than 2.0. In this case
Page 134 and 135: 12.2
Page 136 and 137: TABLE 5 - 9 CORRELATION E t (a/n +1
Page 138 and 139: TABLE 5 - 10 IMPELLER Correlation C
Page 140 and 141: TABLE 5 - 11 CORRELATION G (1.30/61
Page 142 and 143: 1.30 of the substantial improvement
Page 144 and 145: 1.3 2. The probable error in the ca
Page 146 and 147: 134 .,;' : :: :::: : ~ !~. , " . .'
Page 148 and 149: T." ••••••• ,_ .....
Page 150 and 151: 38 the cooling of nitration liquors
Page 152 and 153: 140 The average deviation of the me
Page 154 and 155: 42 tween 0.25 and 0.58. L~~l had re
Page 156 and 157: 144 transfer coefficients to non-Ne
Page 158 and 159: 16 of fit and it may t...herefore b
Page 160 and 161: 148 'tvas insufficient data to eval
Page 162 and 163: 50 A ::: Apr ... B ::: C p ::: CPr
Page 164 and 165: 52. Q ::. Average heat transfer rat
Page 166 and 167: Xc = Function of Reynolds nL:l.m.be
Page 168 and 169: IS6 G REE:>{ ALPHABET 0 ::: Value o
Page 170 and 171: 158 coefficient. Thus, for the wate
Page 172 and 173: 160 , ., I .. : I :. '. • • !.
Page 174 and 175: 162 I , . I . "I '1 I i I 1 I 1· '
Page 176 and 177: 64 ncr --~iIluto e torque of the in
Page 178 and 179: 166 rive different temperatures; ab
Page 180 and 181: 168 TABLE A-4. SLOPE OF "LOG SHEAR
Page 182 and 183: TABLE 11.-5 RHEOLOGICAL DATA FOR CA
Page 186 and 187: '11 The flow behavior index and flu
Page 188 and 189: i .f.C ·F s o 6 1 6 I
Page 190 and 191: · . . . " , · . :::11" ': "'" ~ .
Page 192 and 193: 180 Tke thermal e€l1'!ciluetlvity
Page 194 and 195: 182 Heat capacity data for 100% gly
Page 196 and 197: IB4- wkiek ex~resses the aensity e
Page 198 and 199: 186 Ts - Torque X :: Peree~t 0~ ful
Page 200 and 201: Phase I Calcu13tiJ~ of Slope of !oG
Page 202 and 203: 3 REAL). N. ti •• D 4 cN=N E'I'
Page 204 and 205: ~~-- ~---- --~--~ ~~~--------------
Page 206 and 207: Phase IV Correlation of Flow Behavi
Page 208 and 209: 96 HEAT TRANSFER DATA FOR WA'fER US
Page 210 and 211: DATA /98 Batch \'ieight '" 94 •.
Page 212 and 213: zoo Run Center Dia!!1ec;er Ri'M Are
Page 214 and 215: DATA 20l. WATER - TUHBINSS Batch We
Page 216 and 217: 204- HEAT T'rtANSFEH DATA USED IN C
Page 218 and 219: DATA ANCHor;: 206 Batch :'Ieight =
Page 220 and 221: 2.08 Run Diameter RP!'1 Area Dynamo
Page 222 and 223: DAT_': 210 "i'ADDI,ES 9:5.7'10 GLYC
Page 224 and 225: 212 DATA PADDLES 0.15 PEHC:::N'r CA
Page 226 and 227: 211- D!~ 'I'l\. PA-:JDLES 0.20 PERC
Page 228 and 229: ~;:. 'I'A 3.16 P.;'DDLES 0.24 PEHCE
Page 230 and 231: 2/8 DATA PROPELL:SH3 0.15 P:~RCEN'l
Page 232 and 233: DATA DISK & VANE 'l'URBINE \'iATER
Page 234 and 235:
2.22 DATA Tu.'i:SINES 0.15 PERCENT
Page 236 and 237:
CALCULATION OF HEAT TRANSFER AND PR
Page 238 and 239:
________________ ~parent viscosity
Page 240 and 241:
------------------------ -_._------
Page 242 and 243:
~--~, ~ ---- ---- -----------~-----
Page 244 and 245:
232 NOMEliCLATURE FOR BEAT TRANSFER
Page 246 and 247:
2.34- CALCULATED RSSULTS WATER Run
Page 248 and 249:
2,36 Run Center Diameter h NNu Npo
Page 250 and 251:
2.38 CALCULAT'ED ~E~:UL'rS ?!ATER P
Page 252 and 253:
CALCULA'rED 1-{E8iiLlJ. 1 S \.;!\.'
Page 254 and 255:
CALC:_:LA'i'ED _12:-)ULTS 24c. ANCH
Page 256 and 257:
CALCULATEDR3SULTS PADDLE - CENTER H
Page 258 and 259:
CALCULATED HESULTS 216 PADDLES - CE
Page 260 and 261:
248 CALCULATED RESULTS PADDLES - CE
Page 262 and 263:
CALCULATED RE:>ULTS 2. So PADDLf~S
Page 264 and 265:
PADDLES - CALCULATED RE6ULTS CENTSH
Page 267 and 268:
255 CALCULATED !tESULTS PROPELLERS
Page 269 and 270:
CALCULA'rED RELmL'l'S PROPELLr~RS -
Page 271 and 272:
CALCULATED HESULTS DISK AND VANE ;r
Page 273 and 274:
DISK AND VAI'E .rU~1BINES CALCULATE
Page 275 and 276:
DISK AND VANE '.i.'UR13HiES - CEl'i
Page 277 and 278:
26S RESULT,:; U:3ED FOR REGRESSION
Page 279 and 280:
of a least squares line can be calc
Page 281 and 282:
269 (0-9 where y "" log NNu xl = lo
Page 283 and 284:
-------------- -.Basi.c "Progr.a.rr
Page 285 and 286:
-----------~---------- -~----------
Page 287 and 288:
--~-------------- ------ ~~ -------
Page 289 and 290:
Modi fi cati onB-foT' ev:alnatj ng-
Page 291 and 292:
constants forco~~~latjQn F --------
Page 293 and 294:
.------~.~~-- ---------------------
Page 295 and 296:
28.J ENGLISH ALPHABET . - ¢,'"'~-=
Page 297 and 298:
References 2.8S 1. ') L. 3. Lt- •
Page 299 and 300:
287 56. 57. 58. C:;o ./ / . 60. 61.
Page 301 and 302:
289 119. 120. 121. 122. 123. 12L~
Page 303 and 304:
176. 177. 178. 179. 1(30. 181. 182.
show all

Prediction of batch heat transfer coefficients for pseudoplastic fluids ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?