DRIVER'S MANUAL SB220GS - Training Registration System

More documents

Recommendations

Info

- outer wheel 47° Per hub bearing: wheel bearing grease Lubrication: see specifications Air suspension Front axle: Rear axle: Variable height setting (ECAS): front and rear: front: Two air bellows with two heightcontrol valves and ECAS Four air bellows with two height-control valves and ECAS adjustable ±60 mm (LF-version ±90 mm) above normal running height. adjustable ±100 mm (LFversion ±75 mm) below normal running height (kneeling device) Steering gear Type: hydraulically assisted Type number: ZF 8043 / TRW TAS 75 Fluid: see hydraulic fluid specifications Capacity approx. 8 litres Brake system Service brake: Front axle: Rear axle: Parking brake: Air cylinders, operating pressure: Brake lining: Brake adjusters : Compressor: Electrical system Starter motor Type: Output: Alternator Type: Output: Option: pneumatic-mechanic, dual circuit system, fully separated drum brakes drum brakes spring brake actuators 8.6 - 9.8 bar Jurid 570 asbestosfree Haldex, self-adjusting 2 cylinders, water-cooled top, swept volume 440 cc Bosch JD 5.2 kW alternating current 28 V - 140 A 2nd alternator 28 V 140 A Battery Number: 2 Voltage: 12 V Capacity: 200 Ah/180 Ah 76 TECHNICAL INFORMATION
Wheels Wheel bolts tightening torque: 700 Nm Tyre pressure Tyre pressures vary, depending upon the size and make of the tyre. Refer to the tyre pressure table of the relevant tyre manufacturer for the correct pressures. TECHNICAL INFORMATION 77
Page 1 and 2:
DRIVER’S MANUAL SB220GS Date 9702
Page 3 and 4:
TABLE OF CONTENTS INTRODUCTION ....
Page 5 and 6:
INTRODUCTION This instruction manua
Page 7 and 8:
COLD-WEATHER CONDITIONS Mount winte
Page 9 and 10:
Always disconnect the battery earth
Page 11 and 12:
-R05926- 01490B 01491B IDENTIFICATI
Page 13 and 14:
IDENTIFICATION PLATE 1. Gross combi
Page 15 and 16:
IDENTIFICATION 15
Page 17 and 18:
The dashboard may differ in each ve
Page 19 and 20:
33. Raise/lower vehicle switch* 34.
Page 21 and 22:
11. YELLOW CENTRAL WARNING LAMP* Th
Page 23 and 24:
26. VOLT METER/RETARDER TEMPERATURE
Page 25 and 26: The tachograph disc has a maximum r
Page 27 and 28: mph v min 25 km /h v max125 km/h 12
Page 29 and 30: The minimum value obtainable: 25% o
Page 31 and 32: 38. DIFFERENTIAL LOCK SWITCH* The r
Page 33 and 34: OIL PRESSURE WARNING LAMP (B5) The
Page 35 and 36: LEFT MULTI-FUNCTION SWITCH Dipped b
Page 37 and 38: DRIVING CONTACT SWITCH/STARTER SWIT
Page 39 and 40: START PROCEDURE When starting the e
Page 41 and 42: 3 - position for hilly routes: 1st,
Page 43 and 44: If the door-controlled brake is in
Page 45 and 46: - With the vehicle stationary or mo
Page 47 and 48: E-GAS (ELECTRONIC THROTTLE CONTROL)
Page 49 and 50: The vehicle can only be returned to
Page 51 and 52: 2 Max. 3 DAF 4 Max. Min. -18 c Min.
Page 53 and 54: LIGHTING AND INSTRUMENTS - Check th
Page 55 and 56: FRONT/ REAR 1 A 1187168 00736B 0148
Page 57 and 58: Damp air in the air-operated brake
Page 59 and 60: PREVENTIVE MAINTENANCE AFTER THE WI
Page 61 and 62: V-BELTS Renewing V-Belts - Always f
Page 63 and 64: 01499B BLEEDING THE FUEL SYSTEM Die
Page 65 and 66: After changing a tyre, the differen
Page 67 and 68: FUSES - The central panel of the el
Page 69 and 70: FUSES AND RELAYS E000 Fuse 7.5A, LH
Page 71 and 72: RELAYS G008 Relay windscreen wipers
Page 73 and 74: RELAYS G059 Relay retarder operatio
Page 75: Fuel system Injection order 1-5-3-6
Page 79 and 80: Specification gearbox and intermedi
Page 81 and 82: Specification of coolants Coolant i
Page 83 and 84: LUBRICATION CHART 83
Page 85 and 86: ECAS warning lamp .................
Page 87 and 88: Tyres and rims ....................
show all

DRIVER'S MANUAL SB220GS - Training Registration System

Create successful ePaper yourself

Delete template?

Save as template?