Installation, Operation and Maintenance Manual - Data Aire

More documents

Recommendations

Info

Condensers (Water-Cooled) ___ Check for leaks ___ Entering/leaving water temperatures ENT ____° LVG ____° Compressor ___ Check for oil leaks ___ Check compressor mounting ___ Inspect wire connection ___ Record suction pressure ____ PSIG ___ Record discharge pressure ____ PSIG ___ Record superheat ____ ° ___ Record sub-cooling ____ ° ___ Check high pressure cut-out ____ PSIG ___ Check low pressure cut-in ____ PSIG ___ Check low pressure cut-out ____ PSIG ___ Record compressor amp draw L1 ____ L2 ____ L3 ____ Condensate Pan ___ Check for debris ___ Inspect/check fl oat operation ___ Check pump operation Air Cooled Condenser (if applicable) ___ Inspect coil/clean if required ___ Inspect motor/motor mounts ___ Inspect fan blade(s) ___ Check wiring ___ Inspect piping for leaks Dry Cooler (if applicable) ___ Inspect coil/clean if required ___ Inspect motor/motor mounts ___ Inspect fan blade(s) ___ Check wiring ___ Inspect piping for leaks Glycol Pump (if applicable) ___ Glycol leaks ___ Pump operation 40
Notes ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ 41
Page 1: Mini-Plus Installation, Operation a
Page 4 and 5: 4.0 Installation of Remote Outdoor
Page 6 and 7: 1.0 INSTALLATION WARNING: There is
Page 8 and 9: densing units have factory provided
Page 10 and 11: 2.0 PIPING 2.1 Split Air Cooled Uni
Page 12 and 13: 2.1.6 Field Piping, Remote Condensi
Page 14 and 15: All chilled water pipes have a cap
Page 16 and 17: 3.0 ELECTRICAL CONNECTIONS WARNING:
Page 18 and 19: the panel. Although these existing
Page 20 and 21: Do not locate the heat exchanger in
Page 22 and 23: 5.0 CHARGING 5.1 Voltage Phase Chec
Page 24 and 25: NOTE: Charging to a full liquid lin
Page 26 and 27: (DRCU), the superheat should be 20
Page 28 and 29: 6.0 GLYCOL SYSTEMS 6.1 Glycol Conce
Page 30 and 31: 7.0 CONTROLS 7.1 Mini DAP-II Microp
Page 32 and 33: 8.0 REGULAR MAINTENANCE ITEMS 8.1 A
Page 34 and 35: 9.0 WARRANTY POLICY Seller warrants
Page 36 and 37: RECOMMENDED LINE SIZING for AIR COO
Page 38 and 39: Superheat and Suction Pressure Trou
Page 42: Notes _____________________________

Installation, Operation and Maintenance Manual - Data Aire

Create successful ePaper yourself

Delete template?

Save as template?