TO 35-1-3 - Robins Air Force Base

More documents

Recommendations

Info

TO 35-1-3 Legend for Figure 4-53. Index No. Markings Size Color* 1 FIELD NUMBERS 4 -inch Black 2 TIRE PRESSURE XX PSI 1/2-inch Black 3 MAXIMUM DISTRIBUTED PLATFORM LOAD 2000 LBS 1/2-inch Black 4 MAXIMUM LOAD PER ROLLING PANEL 250 LBS NOT TO EXCEED 1250 LBS OVERALL 5 WARNING THIS PLATFORM NOT ELECTRICALLY INSULATED 1/2-inch 1/2-inch Black Red 6 MAX TOWING SPEED 15 MPH 1/2-inch Black 7 CAUTION ALWAYS BLOCK FRAME BEFORE TYING DOWN BLOCKING POINT TIE DOWN POINT 1/2-inch Black 8 TOWING INSTRUCTIONS: 1. CHECK BRAKE ACCUMULATOR PRESSURE 2. CHOCK WHEELS AND TURN EMERGENCY BRAKE VALVE ON 3. INSTALL TONGUE AND DISENGAGE DRIVE LINE 4. TURN EMERGENCY BRAKE VALVE OFF AND REMOVE CHOCKS 5. RELEASE HAND BRAKE 6. TOW, 15 MPH MAXIMUM 7. REVERSE STEPS WHEN TOWING IS COMPLETE 9 CAUTION (BLACK) ALWAYS USE SPREADER BAR WHEN LIFTING (BLACK) 10 DANGER LOWER PLATFORM COMPLETELY WHEN SERVICING MACHINE. NEVER ELEVATE PLATFORM UNLESS MACHINE IS ON FIRM LEVEL GROUND. 11 WARNING CHECK HYDRAULIC EMERGENCY BRAKE VALVE FOR OFF POSITION PRIOR TO OPERATION 12 HYDRAULIC FLUID LEVEL MUST BE WITHIN SIGHT LEVEL GAGE WHEN PLATFORM IS FULLY LOW- ERED MIL-H-XXXX (AS APPLICABLE) 13 WARNING VALVE MUST REMAIN OPEN TO OPERATE UNIT (STENCIL REQUIRED ONLY IF RESERVOIR HAS A SHUT OFF VALVE) 1/2-inch 1/2-inch 1/2-inch 1/2-inch 1-inch 1/2-inch Black Black Red Red Black Black 4-104
TO 35-1-3 Legend for Figure 4-53 - continued. Index No. Markings Size Color* 14 OPERATING INSTRUCTIONS: MANUAL LOWERED RETRACT, EMERGENCY PLATFORM RETRACT: 1. MOVE RETRACT SWITCH TO RETRACT 2. RELEASE SWITCH WHEN PLATFORM IS FULL RETRACTED MANUAL PLATFORM LOWER: 1. CHECK LOWER ACCUMULATOR PRESSURE 2. MOVE MANUAL LOWER LEVER TO LOWER 3. RETURN LEVER TO OFF WHEN LOWERING IS COMPLETE 15 DANGER GUARDRAILS MUST BE RAISED TO 42″ HEIGHT FOR NORMAL OPERATION 16 EMERGENCY LOWERING TO LOWER 1. OPEN VALVE BY PUSHING KNURLED KNOB IN AND TURNING COUNTERCLOCKWISE TO POSITION SHOWN 2. OPEN VALVE BY TURNING KNOB COUNTERCLOCKWISE NOTE: VALVES MUST BE CLOSED BEFORE RAISING PLATFORM DECAL 10730-00-02 EMERGENCY LOWERING CONTROLS INSIDE DECAL 10700-00-02 1/2-inch 1/2-inch 1/2-inch Black Red Black 17 MAX LOAD 500 LBS 1/2-inch Black 18 MAX LOAD 250 LBS 1/2-inch Black 19 FUEL JP-8 20 CAUTION DO NOT EXCEED TURNING RADIUS 1-inch 1/2-inch 1/2-inch Black Black Black 21 DRIVELINE DISCONNECT 1/2-inch Black 22 C | G GVW 14,660 LBS. 1/2-inch Black 23 LIFT POINT 1/2-inch Black 24 CAUTION SET SPEED SWITCH TO LOW SPEED POSITION WITHIN 15 FEET OF AIRCRAFT 25 CAUTION DO NOT EXTEND OR RETRACT PLATFORM WITH THE STAND IN THE FULLY LOWERED POSITION. RAISE STAND TO AT LEAST 2 1/2 FEET BEFORE EXTENDING OR RETRACTING THE PLATFORM. 1-inch 1/2-inch Black Black Change 2 4-105
Page 1 and 2:
TO 35-1-3 TECHNICAL MANUAL CORROSIO
Page 3 and 4:
TO 35-1-3 TABLE OF CONTENTS Chapter
Page 5 and 6:
TO 35-1-3 TABLE OF CONTENTS - Conti
Page 7 and 8:
TO 35-1-3 LIST OF ILLUSTRATIONS Num
Page 9 and 10:
TO 35-1-3 FOREWORD 1. PURPOSE. The
Page 11 and 12:
TO 35-1-3 SAFETY SUMMARY 1. GENERAL
Page 13 and 14:
CHAPTER 1 CORROSION THEORY, IDENTIF
Page 15 and 16:
TO 35-1-3 Table 1-1. Galvanic Serie
Page 17 and 18:
TO 35-1-3 sion. Improper dilution o
Page 19 and 20:
TO 35-1-3 1.6.7.3 When dry, some mi
Page 21 and 22:
TO 35-1-3 Figure 1-7. Example of Pi
Page 23 and 24:
TO 35-1-3 Figure 1-11. Illustration
Page 25 and 26:
TO 35-1-3 1.8 METALS AFFECTED BY CO
Page 27 and 28:
TO 35-1-3 CHAPTER 2 CLEANING 2.1 GE
Page 29 and 30:
TO 35-1-3 E Table 2-1. Wash Interva
Page 31 and 32:
TO 35-1-3 Table 2-1. Wash Interval
Page 34 and 35:
TO 35-1-3 2.1.5.3 Immersion in clea
Page 36 and 37:
TO 35-1-3 2.1.6.2.10 MIL-PRF-87937,
Page 38 and 39:
TO 35-1-3 Table 2-2. Authorized Cle
Page 40 and 41:
TO 35-1-3 2.1.7.2 Cleaning Compound
Page 42 and 43:
TO 35-1-3 removal and surface treat
Page 44 and 45:
TO 35-1-3 2.2.6.1 Authorized HPW Eq
Page 47 and 48:
TO 35-1-3 CHAPTER 3 PAINTING, SEALI
Page 49 and 50:
TO 35-1-3 3.3.2.3.1 Unless otherwis
Page 51 and 52:
TO 35-1-3 Table 3-1. Authorized Coa
Page 53 and 54:
TO 35-1-3 3.5.2.3 Air Force will ac
Page 55 and 56:
TO 35-1-3 with AMS 3367, Class A or
Page 57 and 58:
TO 35-1-3 3.11 MAINTENANCE STAND RA
Page 59 and 60:
TO 35-1-3 b. Type III An ultra thin
Page 61 and 62:
TO 35-1-3 Table 3-2. Pretreatment I
Page 63 and 64:
TO 35-1-3 b. Azko Nobel 10P3-2 Akzo
Page 65 and 66:
TO 35-1-3 removed prior to the fina
Page 67 and 68:
TO 35-1-3 3.22.1 SE Undercoating Co
Page 69:
TO 35-1-3 3.26.7 Wire Harness and C
Page 72 and 73:
TO 35-1-3 4.2.3.4 Other optional in
Page 74 and 75:
TO 35-1-3 Figure 4-3. Sample Mobili
Page 76 and 77:
TO 35-1-3 Legend for Figure 4-4. In
Page 78 and 79:
Page 80 and 81:
Page 82 and 83:
Page 84 and 85:
Page 86 and 87:
Page 88 and 89:
TO 35-1-3 Legend for Figure 4-10. I
Page 90 and 91:
Page 92 and 93:
Page 94 and 95:
Page 96 and 97:
Page 98 and 99:
Page 100 and 101:
Page 102 and 103:
Page 104 and 105:
Page 106 and 107:
Page 108 and 109:
Page 110 and 111:
Page 112 and 113:
Page 114 and 115:
Page 116 and 117:
TO 35-1-3 Pages 4-46 and 4-47 were
Page 118 and 119:
Page 120 and 121:
Page 122 and 123: TO 35-1-3 Legend for Figure 4-28. I
Page 174 and 175: TO 35-1-3 Legend for Figure 4-53 -
Page 178 and 179: TO 35-1-3 Figure 4-54. New Generati
Page 180 and 181: TO 35-1-3 Figure 5-1. Angle Iron Se
Page 182 and 183: TO 35-1-3 87937, Type I), which con
Page 184 and 185: TO 35-1-3 • Gas Tungsten-Arc (TIG
Page 187 and 188: TO 35-1-3 CHAPTER 7 SOUTHWEST ASIA
Page 189: TO 35-1-3 7.2.2.1.6 Felt-Soundproof
Page 192 and 193: TO 35-1-3 Table A-1. Equipment and
Page 194 and 195: TO 35-1-3 Nomenclature/Description
Page 196 and 197: TO 35-1-3 Table A-1. Equipment and
Page 198: TO 35-1-3 Table A-1. Equipment and
show all

TO 35-1-3 - Robins Air Force Base

Create successful ePaper yourself

Delete template?

Save as template?