Regional Haul Model Operator's Manual - Peterbilt Motors Company
Regional Haul Model Operator's Manual - Peterbilt Motors Company Regional Haul Model Operator's Manual - Peterbilt Motors Company
NOISE AND EMISSION CONTROL Sliding Fifth Wheel • Lubricate bearing surface of support bracket through the grease fittings on the side of the fifth wheel plate. Use a water resistant lithium-base grease. NOTE: The plate must be lifted up slightly to relieve the weight of the bracket while applying grease. Noise and Emission Control Noise Emission Warranty Peterbilt Motors Company warrants to the first person who purchases this vehicle (for purposes other than resale) and to each subsequent purchaser: that this vehicle, as manufactured by Peterbilt Motors Company, was designed, built and equipped to conform, at the time it left Peterbilt's control, with all applicable U.S. EPA Noise Control Regulations. This warranty covers this vehicle as designed, built and equipped by Peterbilt, and is not limited to any particular part, component or system of the vehicle manufactured by Peterbilt. Defects in design, assembly or in any part, component or system of the vehicle as manufactured by PREVENTIVE MAINTENANCE Peterbilt, which at the time it left Peterbilt's control caused noise emissions to exceed Federal standards, are covered by this warranty for the life of the vehicle. Tampering with Noise Control System Federal law prohibits the following acts or the causing thereof: 1. The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement, of any device or element of design incorporated into any new vehicle for the purpose of noise control prior to its sale or delivery to the ultimate purchaser or while it is in use, or 2. The use of the vehicle after such device or element of design has been removed or rendered inoperative by any person. Among those acts presumed to constitute tampering are the acts listed below: Air Intake System • Removing or rendering inoperative the air cleaner/ silencers or intake piping. – 252 – Y53-6033 Regional Haul (R05/10)
PREVENTIVE MAINTENANCE Engine Cooling System • Removing or rendering inoperative the fan clutch. • Removing the fan shroud. Engine • Removing or rendering engine speed governor inoperative so as to allow engine speed to exceed manufacturer's specifications. • Modifying ECU parameters. Exhaust System • Removing or rendering inoperative exhaust system components. Inspection and Maintenance Instructions The following instructions are based on inspection of the noise control system at regular intervals. If, during periodic inspection and maintenance of other systems and components, it is found that parts of the noise control system require attention, we recommend that those parts be inspected at more frequent intervals to assure adequate maintenance and performance. NOISE AND EMISSION CONTROL Air Intake System • Do all checks and maintenance procedures listed in this manual under Engine Air Intake System and Air Cleaner. See “Air Intake System” on page 196. • Check the induction tubing, elbow connections, clamps, brackets, and fasteners for deterioration, cracks, and security. • If you find an air leak anywhere between the air cleaner and the engine, repair that leak immediately. CAUTION: Air leaks cause excessive noise and may result in serious damage to the engine. If you do not repair them the engine damage will not be covered by your warranty. Repair all air leaks as soon as you find them. Exhaust System • Check for exhaust leaks, which would indicate a leaking manifold gasket; replace gasket if necessary. • Check cap screws for tightness, including those at the flanges. Refer to the engine manufacturer's service manual for proper tightening sequence and torque values. Regional Haul (R05/10) Y53-6033 – 253 –
- Page 205 and 206: PREVENTIVE MAINTENANCE Tire Inflati
- Page 207 and 208: PREVENTIVE MAINTENANCE TIRES AND WH
- Page 209 and 210: PREVENTIVE MAINTENANCE TIRES AND WH
- Page 211 and 212: PREVENTIVE MAINTENANCE TIRES AND WH
- Page 213 and 214: PREVENTIVE MAINTENANCE Tire Replace
- Page 215 and 216: PREVENTIVE MAINTENANCE HEATER AND A
- Page 217 and 218: PREVENTIVE MAINTENANCE ELECTRICAL S
- Page 219 and 220: PREVENTIVE MAINTENANCE Battery Cabl
- Page 221 and 222: PREVENTIVE MAINTENANCE Undercharge:
- Page 223 and 224: PREVENTIVE MAINTENANCE WARNING! To
- Page 225 and 226: PREVENTIVE MAINTENANCE ELECTRICAL S
- Page 227 and 228: PREVENTIVE MAINTENANCE Bulb Replace
- Page 229 and 230: PREVENTIVE MAINTENANCE Cleaning, Pr
- Page 231 and 232: PREVENTIVE MAINTENANCE CAB MAINTENA
- Page 233 and 234: PREVENTIVE MAINTENANCE Interior Tri
- Page 235 and 236: PREVENTIVE MAINTENANCE Inspection G
- Page 237 and 238: PREVENTIVE MAINTENANCE 7. Mounting
- Page 239 and 240: PREVENTIVE MAINTENANCE TRANSMISSION
- Page 241 and 242: PREVENTIVE MAINTENANCE As the clutc
- Page 243 and 244: PREVENTIVE MAINTENANCE Steering and
- Page 245 and 246: PREVENTIVE MAINTENANCE 2. If you ch
- Page 247 and 248: PREVENTIVE MAINTENANCE Axle Lubrica
- Page 249 and 250: PREVENTIVE MAINTENANCE Rear Axle an
- Page 251 and 252: PREVENTIVE MAINTENANCE REAR AXLE AN
- Page 253 and 254: PREVENTIVE MAINTENANCE REAR AXLE AN
- Page 255: PREVENTIVE MAINTENANCE FRAME AND FI
- Page 259 and 260: PREVENTIVE MAINTENANCE Check fan bl
- Page 261 and 262: PREVENTIVE MAINTENANCE MAINTENANCE
- Page 263 and 264: PREVENTIVE MAINTENANCE CONSUMER INF
- Page 265 and 266: PREVENTIVE MAINTENANCE CONSUMER INF
- Page 267 and 268: PREVENTIVE MAINTENANCE CONSUMER INF
- Page 269 and 270: INDEX C lubrication 182 operation 1
- Page 271 and 272: INDEX E vehicle inspection 81 with
- Page 273 and 274: INDEX I Headllights 15 Heater and a
- Page 275 and 276: INDEX R R Radio 16, 71 Rear axle 24
- Page 277: INDEX V Underinflated tires 201 V V
NOISE AND EMISSION CONTROL<br />
Sliding Fifth Wheel<br />
• Lubricate bearing surface of support bracket through<br />
the grease fittings on the side of the fifth wheel plate.<br />
Use a water resistant lithium-base grease.<br />
NOTE: The plate must be lifted up slightly to<br />
relieve the weight of the bracket while applying<br />
grease.<br />
Noise and Emission Control<br />
Noise Emission Warranty<br />
<strong>Peterbilt</strong> <strong>Motors</strong> <strong>Company</strong> warrants to the first person<br />
who purchases this vehicle (for purposes other than<br />
resale) and to each subsequent purchaser: that this vehicle,<br />
as manufactured by <strong>Peterbilt</strong> <strong>Motors</strong> <strong>Company</strong>, was<br />
designed, built and equipped to conform, at the time it left<br />
<strong>Peterbilt</strong>'s control, with all applicable U.S. EPA Noise<br />
Control Regulations.<br />
This warranty covers this vehicle as designed, built and<br />
equipped by <strong>Peterbilt</strong>, and is not limited to any particular<br />
part, component or system of the vehicle manufactured by<br />
<strong>Peterbilt</strong>. Defects in design, assembly or in any part, component<br />
or system of the vehicle as manufactured by<br />
PREVENTIVE MAINTENANCE<br />
<strong>Peterbilt</strong>, which at the time it left <strong>Peterbilt</strong>'s control caused<br />
noise emissions to exceed Federal standards, are covered<br />
by this warranty for the life of the vehicle.<br />
Tampering with Noise Control System<br />
Federal law prohibits the following acts or the causing<br />
thereof:<br />
1. The removal or rendering inoperative by any person<br />
other than for purposes of maintenance, repair, or<br />
replacement, of any device or element of design<br />
incorporated into any new vehicle for the purpose of<br />
noise control prior to its sale or delivery to the ultimate<br />
purchaser or while it is in use, or<br />
2. The use of the vehicle after such device or element of<br />
design has been removed or rendered inoperative by<br />
any person.<br />
Among those acts presumed to constitute tampering are<br />
the acts listed below:<br />
Air Intake System<br />
• Removing or rendering inoperative the air cleaner/<br />
silencers or intake piping.<br />
– 252 – Y53-6033 <strong>Regional</strong> <strong>Haul</strong> (R05/10)