Regional Haul Model Operator's Manual - Peterbilt Motors Company

More documents

Recommendations

Info

TRANSMISSION AND CLUTCH Automatic Transmission Oil Level NOTE: The vehicle must be parked on level ground. PREVENTIVE MAINTENANCE Maintain the oil level and check it daily. Oil should be up to the “HOT” mark on the dipstick when (1) the engine is running, (2) the transmission is at operating temperature, and (3) the transmission is in Neutral. See the Transmission Operator's Manual in the glove compartment for more information on checking the transmission oil level. Table 10 Transmission Lubrication — Automatic transmissions MODEL RECOMMENDED LUBRICANTS AMBIENT TEMPERATURE RANGE DEG. C DEG. F VISCOSITY (SAE) ALLISON TranSynd (Castrol) Above -23 Above -10 10W – 238 – Y53-6033 Regional Haul (R05/10)
PREVENTIVE MAINTENANCE Steering and Driveline Power Steering Oil (under low pressure) provides the power to operate the steering gear. It also serves to lubricate moving parts and remove heat. A loss of steering efficiency will occur if too much heat builds up in the system. WARNING! Do not operate the vehicle if the steering system is not working properly. You could lose control of your vehicle if the steering system is not in good working condition, which could result in an accident causing death or injury. For driving safety, visually check the steering gear and components. Frequent checks are important for driving safety, especially after traveling over rough roads. NOTE: If the steering feels unbalanced from sideto-side while turning, check for the following possible causes: • unequal tire pressures • vehicle overloaded or unevenly distributed load • wheels out of alignment • wheel bearings improperly adjusted STEERING AND DRIVELINE If you cannot correct the problem, check with an Authorized Service Center. The Regional Haul vehicle is equipped with integral power steering. The system includes an engine-driven fluid pump, a fluid reservoir, the steering gear, and connecting hoses. Because of the hydraulic power assist, little effort is required to turn the steering wheel. When no input is applied through the steering wheel, the steering gear will return to the neutral position. If, for any reason, the power assist system goes out, steering the vehicle is still possible—yet it will require much greater effort. Visually check the following parts: • Crosstube: Is it straight? • Draglink tube clamp: Check for looseness or interference. • Ball joints and steering U–joints: Check for looseness. • Steering wheel for excessive free-play. Check the simplest probable causes first: – unequal tire pressures – loose cap nuts – bent crosstube – lack of lubrication Regional Haul (R05/10) Y53-6033 – 239 –
Page 1 and 2:
Y53-6033-RegionalHual-FrontCover.ai
Page 3 and 4:
Other Publications Order either of
Page 5 and 6:
INTRODUCTION HOW TO USE THIS MANUAL
Page 7 and 8:
INTRODUCTION Vehicle Safety Make su
Page 9 and 10:
INTRODUCTION Shop Manuals If you do
Page 11 and 12:
CAB AND FRAME ACCESS INTRODUCTION C
Page 13 and 14:
CAB AND FRAME ACCESS CAB AND FRAME
Page 15 and 16:
ENGINE ACCESS Put one hand on the h
Page 17 and 18:
ENGINE ACCESS HOOD HOLD DOWNS AND T
Page 19 and 20:
CONTROLS AND DISPLAYS INSTRUMENTS A
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
CONTROLS AND DISPLAYS Warning Light
Page 27 and 28:
CONTROLS AND DISPLAYS Warning Light
Page 29 and 30:
CONTROLS AND DISPLAYS 9. Cruise Con
Page 31 and 32:
CONTROLS AND DISPLAYS injury. 20. E
Page 33 and 34:
CONTROLS AND DISPLAYS 32. Seat Belt
Page 35 and 36:
CONTROLS AND DISPLAYS • MCS butto
Page 37 and 38:
CONTROLS AND DISPLAYS - Trip Idle P
Page 39 and 40:
Page 41 and 42:
CONTROLS AND DISPLAY STANDARD GAUGE
Page 43 and 44:
CONTROLS AND DISPLAY Engine Oil Pre
Page 45 and 46:
CONTROLS AND DISPLAY CAUTION: Keep
Page 47 and 48:
CONTROLS AND DISPLAY OPTIONAL GAUGE
Page 49 and 50:
CONTROLS AND DISPLAY operate the si
Page 51 and 52:
CONTROLS AND DISPLAY OPTIONAL GAUGE
Page 53 and 54:
CONTROLS AND DISPLAY See “Brake S
Page 55 and 56:
CONTROLS AND DISPLAY DASH- AND DOOR
Page 57 and 58:
CONTROLS AND DISPLAY ID and Clearan
Page 59 and 60:
CONTROLS AND DISPLAY WARNING! Do no
Page 61 and 62:
Page 63 and 64:
CONTROLS AND DISPLAY closed or open
Page 65 and 66:
Page 67 and 68:
CONTROLS AND DISPLAY WARNING! Do no
Page 69 and 70:
CONTROLS AND DISPLAY •If you are
Page 71 and 72:
CONTROLS AND DISPLAY CIGARETTE LIGH
Page 73 and 74:
CONTROLS AND DISPLAY SHIFT PATTERN
Page 75 and 76:
CONTROLS AND DISPLAY NOTE: The map
Page 77 and 78:
SEATS SAFETY RESTRAINT BELTS CHUGGE
Page 79 and 80:
SEATS • Belts should fit snugly a
Page 81 and 82:
SEATS Safety Restraint Tips NOTE: P
Page 83 and 84:
SEATS Komfort-Lok® Latch Your Pete
Page 85 and 86:
DRIVER'S CHECKLIST SAFE VEHICLE OPE
Page 87 and 88:
DRIVER'S CHECKLIST GAWR: is the Gro
Page 89 and 90:
DRIVER'S CHECKLIST 7. Steps and Han
Page 91 and 92:
STARTING AND OPERATING THE VEHICLE
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
Page 107 and 108:
Page 109 and 110:
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Page 143 and 144:
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
Page 151 and 152:
PREVENTIVE MAINTENANCE • Disconne
Page 153 and 154:
PREVENTIVE MAINTENANCE Maintenance
Page 155 and 156:
PREVENTIVE MAINTENANCE MAINTENANCE
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
Page 163 and 164:
Page 165 and 166:
Page 167 and 168:
PREVENTIVE MAINTENANCE Lubrication
Page 169 and 170:
Page 171 and 172:
PREVENTIVE MAINTENANCE ENGINE MAINT
Page 173 and 174:
PREVENTIVE MAINTENANCE • When dra
Page 175 and 176:
Page 177 and 178:
Page 179 and 180:
PREVENTIVE MAINTENANCE ENGINE COOLI
Page 181 and 182:
PREVENTIVE MAINTENANCE ENGINE COOLI
Page 183 and 184:
PREVENTIVE MAINTENANCE 10. Operate
Page 185 and 186:
PREVENTIVE MAINTENANCE BRAKE SYSTEM
Page 187 and 188:
PREVENTIVE MAINTENANCE • Do not u
Page 189 and 190:
PREVENTIVE MAINTENANCE BRAKE SYSTEM
Page 191 and 192: PREVENTIVE MAINTENANCE be performed
Page 193 and 194: PREVENTIVE MAINTENANCE Air System I
Page 195 and 196: PREVENTIVE MAINTENANCE AIR SYSTEM T
Page 197 and 198: PREVENTIVE MAINTENANCE • Maintain
Page 199 and 200: PREVENTIVE MAINTENANCE AIR SYSTEM A
Page 201 and 202: PREVENTIVE MAINTENANCE AIR SYSTEM H
Page 203 and 204: PREVENTIVE MAINTENANCE Tires and Wh
Page 205 and 206: PREVENTIVE MAINTENANCE Tire Inflati
Page 207 and 208: PREVENTIVE MAINTENANCE TIRES AND WH
Page 213 and 214: PREVENTIVE MAINTENANCE Tire Replace
Page 215 and 216: PREVENTIVE MAINTENANCE HEATER AND A
Page 217 and 218: PREVENTIVE MAINTENANCE ELECTRICAL S
Page 219 and 220: PREVENTIVE MAINTENANCE Battery Cabl
Page 221 and 222: PREVENTIVE MAINTENANCE Undercharge:
Page 223 and 224: PREVENTIVE MAINTENANCE WARNING! To
Page 225 and 226: PREVENTIVE MAINTENANCE ELECTRICAL S
Page 227 and 228: PREVENTIVE MAINTENANCE Bulb Replace
Page 229 and 230: PREVENTIVE MAINTENANCE Cleaning, Pr
Page 231 and 232: PREVENTIVE MAINTENANCE CAB MAINTENA
Page 233 and 234: PREVENTIVE MAINTENANCE Interior Tri
Page 235 and 236: PREVENTIVE MAINTENANCE Inspection G
Page 237 and 238: PREVENTIVE MAINTENANCE 7. Mounting
Page 239 and 240: PREVENTIVE MAINTENANCE TRANSMISSION
Page 241: PREVENTIVE MAINTENANCE As the clutc
Page 245 and 246: PREVENTIVE MAINTENANCE 2. If you ch
Page 247 and 248: PREVENTIVE MAINTENANCE Axle Lubrica
Page 249 and 250: PREVENTIVE MAINTENANCE Rear Axle an
Page 251 and 252: PREVENTIVE MAINTENANCE REAR AXLE AN
Page 253 and 254: PREVENTIVE MAINTENANCE REAR AXLE AN
Page 255 and 256: PREVENTIVE MAINTENANCE FRAME AND FI
Page 257 and 258: PREVENTIVE MAINTENANCE Engine Cooli
Page 259 and 260: PREVENTIVE MAINTENANCE Check fan bl
Page 261 and 262: PREVENTIVE MAINTENANCE MAINTENANCE
Page 263 and 264: PREVENTIVE MAINTENANCE CONSUMER INF
Page 269 and 270: INDEX C lubrication 182 operation 1
Page 271 and 272: INDEX E vehicle inspection 81 with
Page 273 and 274: INDEX I Headllights 15 Heater and a
Page 275 and 276: INDEX R R Radio 16, 71 Rear axle 24
Page 277: INDEX V Underinflated tires 201 V V
show all

Regional Haul Model Operator's Manual - Peterbilt Motors Company

Create successful ePaper yourself

Delete template?

Save as template?