Regional Haul Model Operator's Manual - Peterbilt Motors Company
Regional Haul Model Operator's Manual - Peterbilt Motors Company
Regional Haul Model Operator's Manual - Peterbilt Motors Company
You also want an ePaper? Increase the reach of your titles
YUMPU automatically turns print PDFs into web optimized ePapers that Google loves.
PREVENTIVE MAINTENANCE<br />
ELECTRICAL SYSTEM<br />
• Charge a battery only in a well-ventilated area, such<br />
as outdoors or in a fully open garage which contains<br />
no pilot lights or other flames. Gases generated during<br />
the charging process must be allowed to escape.<br />
• Maintain the full level of electrolyte in the batteries.<br />
This reduces the volume of gas in the cells. The electrolyte<br />
level should always be between 0.4–0.6 in.<br />
(10–15mm) above plates. Fill with distilled water<br />
only. After distilled water has been added, wait at<br />
least a half hour to measure solution density (specific<br />
gravity). The specific gravity should be between<br />
1.258–1.265 or the electrolyte level within “MIN” and<br />
“MAX” marks.<br />
• When fast charging, remove the battery caps so pressure<br />
does not accumulate.<br />
• Always make sure the battery charger is OFF before<br />
connecting or disconnecting the cable clamps.<br />
• To avoid short circuits and damage to yourself or the<br />
vehicle, never place metal tools or jumper cables on<br />
the battery or nearby. Metal that accidentally comes in<br />
contact with the positive battery terminal or any other<br />
metal on the vehicle (that is in contact with the positive<br />
terminal), could cause a short circuit or an explosion.<br />
Charging Reminders<br />
• Use protective eyewear.<br />
• Keep all batteries away from children.<br />
• Never reverse battery poles.<br />
• Never attempt to place the vehicle in motion, or run<br />
the engine with batteries disconnected.<br />
• Keep the battery clean and dry.<br />
• Look for any signs of damage.<br />
WARNING! Never use a metallic funnel to add<br />
distilled water. It could come in contact with a<br />
terminal, creating a short circuit, resulting in<br />
death, severe personal injury or damage to<br />
your vehicle.<br />
WARNING! Always shield your eyes and avoid<br />
leaning over the battery whenever possible.<br />
Electrolyte in batteries could splash up into<br />
your eyes causing severe burns and/or serious<br />
personal injury.<br />
• Battery terminals should not be coated with improper<br />
grease. Use petroleum jelly or commercially available,<br />
noncorrosive, nonconductive terminal coatings.<br />
<strong>Regional</strong> <strong>Haul</strong> (R05/10) Y53-6033 – 221 –