Regional Haul Model Operator's Manual - Peterbilt Motors Company
Regional Haul Model Operator's Manual - Peterbilt Motors Company Regional Haul Model Operator's Manual - Peterbilt Motors Company
AIR SYSTEM PREVENTIVE MAINTENANCE COVER 00455B FILTER ELEMENT Air Cleaner - Filter Element To install air cleaner element: 1. Slide air cleaner element into housing. 2. Install air cleaner end cap. 3. Install thumbscrews around air cleaner housing end cap. NOTE: The air cleaner is internally sealed by a radial seal around Inlet tube of air cleaner element. For further information on servicing the air cleaner, see the Maintenance Manual. – 198 – Y53-6033 Regional Haul (R05/10)
PREVENTIVE MAINTENANCE Tires and Wheels Introduction Keeping the tires in good condition is essential to the safe, efficient operation of your Regional Haul vehicle. Regular, frequent inspection and the right care will give you the assurance of safe and reliable tire operation. WARNING! Use only original equipment manufactured (OEM) components. Use of nonoriginal equipment could cause wheel breakage and wheel separation from vehicle, which could result in an accident causing death or personal injury. Each mounting system is engineered only for use with its correct mating part. Be sure that properly matched components are used for each type of mounting. The comparison chart on Page 208 illustrates the differences between parts used in hubpiloted mount and ball seat mount applications. Only OEM supplied hub-piloted or ballseat mounted wheels may be used on this vehicle. TIRES AND WHEELS • If you are not fully qualified and not equipped with the proper tools and equipment, do not attempt to raise the vehicle or remove or install the damaged tire and wheel assembly. Obtain expert help. A person can be killed or seriously injured and/or damage can result from using the wrong service methods. Truck tires and wheels should be serviced only by trained personnel using proper equipment. Do not reinflate a tire that has been run flat or is seriously low on air without first removing the tire from the rim and inspecting for damage. • Follow OSHA regulations per section 1910.177. • Do not exceed the speed rating of tires. Exceeding the speed rating may result in sudden tire failure and loss of vehicle control. • Follow all warnings and cautions contained within the tire and wheel manufacturers literature. • Only properly trained personnel should service tire and rim assemblies. Regional Haul (R05/10) Y53-6033 – 199 –
- Page 151 and 152: PREVENTIVE MAINTENANCE • Disconne
- Page 153 and 154: PREVENTIVE MAINTENANCE Maintenance
- Page 155 and 156: PREVENTIVE MAINTENANCE MAINTENANCE
- Page 157 and 158: PREVENTIVE MAINTENANCE MAINTENANCE
- Page 159 and 160: PREVENTIVE MAINTENANCE MAINTENANCE
- Page 161 and 162: PREVENTIVE MAINTENANCE MAINTENANCE
- Page 163 and 164: PREVENTIVE MAINTENANCE MAINTENANCE
- Page 165 and 166: PREVENTIVE MAINTENANCE MAINTENANCE
- Page 167 and 168: PREVENTIVE MAINTENANCE Lubrication
- Page 169 and 170: PREVENTIVE MAINTENANCE MAINTENANCE
- Page 171 and 172: PREVENTIVE MAINTENANCE ENGINE MAINT
- Page 173 and 174: PREVENTIVE MAINTENANCE • When dra
- Page 175 and 176: PREVENTIVE MAINTENANCE ENGINE MAINT
- Page 177 and 178: PREVENTIVE MAINTENANCE ENGINE MAINT
- Page 179 and 180: PREVENTIVE MAINTENANCE ENGINE COOLI
- Page 181 and 182: PREVENTIVE MAINTENANCE ENGINE COOLI
- Page 183 and 184: PREVENTIVE MAINTENANCE 10. Operate
- Page 185 and 186: PREVENTIVE MAINTENANCE BRAKE SYSTEM
- Page 187 and 188: PREVENTIVE MAINTENANCE • Do not u
- Page 189 and 190: PREVENTIVE MAINTENANCE BRAKE SYSTEM
- Page 191 and 192: PREVENTIVE MAINTENANCE be performed
- Page 193 and 194: PREVENTIVE MAINTENANCE Air System I
- Page 195 and 196: PREVENTIVE MAINTENANCE AIR SYSTEM T
- Page 197 and 198: PREVENTIVE MAINTENANCE • Maintain
- Page 199 and 200: PREVENTIVE MAINTENANCE AIR SYSTEM A
- Page 201: PREVENTIVE MAINTENANCE AIR SYSTEM H
- Page 205 and 206: PREVENTIVE MAINTENANCE Tire Inflati
- Page 207 and 208: PREVENTIVE MAINTENANCE TIRES AND WH
- Page 209 and 210: PREVENTIVE MAINTENANCE TIRES AND WH
- Page 211 and 212: PREVENTIVE MAINTENANCE TIRES AND WH
- Page 213 and 214: PREVENTIVE MAINTENANCE Tire Replace
- Page 215 and 216: PREVENTIVE MAINTENANCE HEATER AND A
- Page 217 and 218: PREVENTIVE MAINTENANCE ELECTRICAL S
- Page 219 and 220: PREVENTIVE MAINTENANCE Battery Cabl
- Page 221 and 222: PREVENTIVE MAINTENANCE Undercharge:
- Page 223 and 224: PREVENTIVE MAINTENANCE WARNING! To
- Page 225 and 226: PREVENTIVE MAINTENANCE ELECTRICAL S
- Page 227 and 228: PREVENTIVE MAINTENANCE Bulb Replace
- Page 229 and 230: PREVENTIVE MAINTENANCE Cleaning, Pr
- Page 231 and 232: PREVENTIVE MAINTENANCE CAB MAINTENA
- Page 233 and 234: PREVENTIVE MAINTENANCE Interior Tri
- Page 235 and 236: PREVENTIVE MAINTENANCE Inspection G
- Page 237 and 238: PREVENTIVE MAINTENANCE 7. Mounting
- Page 239 and 240: PREVENTIVE MAINTENANCE TRANSMISSION
- Page 241 and 242: PREVENTIVE MAINTENANCE As the clutc
- Page 243 and 244: PREVENTIVE MAINTENANCE Steering and
- Page 245 and 246: PREVENTIVE MAINTENANCE 2. If you ch
- Page 247 and 248: PREVENTIVE MAINTENANCE Axle Lubrica
- Page 249 and 250: PREVENTIVE MAINTENANCE Rear Axle an
- Page 251 and 252: PREVENTIVE MAINTENANCE REAR AXLE AN
AIR SYSTEM<br />
PREVENTIVE MAINTENANCE<br />
COVER<br />
00455B<br />
FILTER ELEMENT<br />
Air Cleaner - Filter Element<br />
To install air cleaner element:<br />
1. Slide air cleaner element into housing.<br />
2. Install air cleaner end cap.<br />
3. Install thumbscrews around air cleaner housing end<br />
cap.<br />
NOTE: The air cleaner is internally sealed by a<br />
radial seal around Inlet tube of air cleaner element.<br />
For further information on servicing the air<br />
cleaner, see the Maintenance <strong>Manual</strong>.<br />
– 198 – Y53-6033 <strong>Regional</strong> <strong>Haul</strong> (R05/10)