Regional Haul Model Operator's Manual - Peterbilt Motors Company
Regional Haul Model Operator's Manual - Peterbilt Motors Company Regional Haul Model Operator's Manual - Peterbilt Motors Company
MAINTENANCE SCHEDULE AND LUBRICATION PREVENTIVE MAINTENANCE Table 3 Recommended Lubrication Types COMPONENTS Power Steering Gear Driveline U-Joints Slip-Joint Splines Hood Pivots Fan Drive Fifth Wheel Components Clutch Pedal Shaft Clutch Linkage Other chassis grease fittings not covered below. Wheel Bearing-Non Driving Axles Threaded Pins & Bushings (e.g., spring pins & bushings) Suspension Fittings (other than threaded pins & bushings) Steering Axle: Grease Fittings on Steering Arm; Tie Rod Ends; Drag Link; King Pins Clutch Release Bearing (remove inspection plate for access); Driveshaft Center Bearing Automatic Slack Adjusters; Wedge Brake Components; Disc Brake Caliper Automatic Transmission Fluid (ATF) RECOMMENDED LUBRICANT EP chassis grease, lithium 12-hydroxystearate or lithium complex base, NLGI 2. OIL LUBICATED: SAE 80W-90 EP gear oil, MIL-L-2105D, API GL5; or SAE 75W-90 synthetic oil GREASE LUBRICATED: EP chassis grease, lithium 12-hydroxystearate or lithium complex base, NLGI 2. EP grease, lithium 12-hydroxystearate or lithium complex base, NLGI 2, with 3% molybdenum additive: Mobil Grease Special (Mobil), Molygrease EP (Chevron), or equal. EP chassis grease, lithium 12-hydroxystearate or lithium complex base, NLGI 2. EP chassis grease, lithium 12-hydroxystearate base, NLGI 2. High temperature ball bearing grease. Chevron SRI Mobil Grease HP, Texaco Multifax 2, or equivalent. High temperature EP grease; Texaco Thermotex EP-1, Shell Darina EP-1, Mobilith AW-1, Rockwell 0-616A, or equivalent. Deviations from the above list of lubricants should be based on specifications published in the component manufacturer's manuals or otherwise approved by the manufacturer. – 166 – Y53-6033 Regional Haul (R05/10)
PREVENTIVE MAINTENANCE ENGINE MAINTENANCE Table 3 Recommended Lubrication Types COMPONENTS Cam Brake Camshaft Splines; Disc Brake Shaft Splines and Slide Pin Retainers; Brake Clevis Pins Engine Maintenance WARNING! Exhaust fumes from the engine contain carbon monoxide, a colorless and odorless gas. A poorly maintained, damaged, or corroded exhaust system can allow carbon monoxide to enter the cab or sleeper. Failure RECOMMENDED LUBRICANT Antiseize type grease, Rockwell specification 0-637. Brake Camshaft Bushings EP Chassis grease, lithium 12-hydroxystearate base, NLGI 2. CAUTION: Do not contaminate brake linings with grease. Steering Shaft Grease Fittings EP chassis grease, lithium 12-hydroxystearate base, NLGI 2. Brake Treadle Hinge and Roller Engine oil Lock Cylinders Lock lubricant. Door Hinges Not required — Teflon bushings Door Latches & Striker Plates. Polyethylene grease stick. Door Weatherstrip Silicone lubricant. Other Items Use manufacturer’s manuals. Deviations from the above list of lubricants should be based on specifications published in the component manufacturer's manuals or otherwise approved by the manufacturer. to properly maintain your vehicle could cause carbon monoxide to enter the cab and cause death, personal injury or serious illness. Regional Haul (R05/10) Y53-6033 – 167 –
- Page 119 and 120: STARTING AND OPERATING THE VEHICLE
- Page 121 and 122: STARTING AND OPERATING THE VEHICLE
- Page 123 and 124: STARTING AND OPERATING THE VEHICLE
- Page 125 and 126: STARTING AND OPERATING THE VEHICLE
- Page 127 and 128: STARTING AND OPERATING THE VEHICLE
- Page 129 and 130: STARTING AND OPERATING THE VEHICLE
- Page 131 and 132: STARTING AND OPERATING THE VEHICLE
- Page 133 and 134: STARTING AND OPERATING THE VEHICLE
- Page 135 and 136: STARTING AND OPERATING THE VEHICLE
- Page 137 and 138: STARTING AND OPERATING THE VEHICLE
- Page 139 and 140: STARTING AND OPERATING THE VEHICLE
- Page 141 and 142: STARTING AND OPERATING THE VEHICLE
- Page 143 and 144: STARTING AND OPERATING THE VEHICLE
- Page 145 and 146: STARTING AND OPERATING THE VEHICLE
- Page 147 and 148: STARTING AND OPERATING THE VEHICLE
- Page 149 and 150: STARTING AND OPERATING THE VEHICLE
- Page 151 and 152: PREVENTIVE MAINTENANCE • Disconne
- Page 153 and 154: PREVENTIVE MAINTENANCE Maintenance
- Page 155 and 156: PREVENTIVE MAINTENANCE MAINTENANCE
- Page 157 and 158: PREVENTIVE MAINTENANCE MAINTENANCE
- Page 159 and 160: PREVENTIVE MAINTENANCE MAINTENANCE
- Page 161 and 162: PREVENTIVE MAINTENANCE MAINTENANCE
- Page 163 and 164: PREVENTIVE MAINTENANCE MAINTENANCE
- Page 165 and 166: PREVENTIVE MAINTENANCE MAINTENANCE
- Page 167 and 168: PREVENTIVE MAINTENANCE Lubrication
- Page 169: PREVENTIVE MAINTENANCE MAINTENANCE
- Page 173 and 174: PREVENTIVE MAINTENANCE • When dra
- Page 175 and 176: PREVENTIVE MAINTENANCE ENGINE MAINT
- Page 177 and 178: PREVENTIVE MAINTENANCE ENGINE MAINT
- Page 179 and 180: PREVENTIVE MAINTENANCE ENGINE COOLI
- Page 181 and 182: PREVENTIVE MAINTENANCE ENGINE COOLI
- Page 183 and 184: PREVENTIVE MAINTENANCE 10. Operate
- Page 185 and 186: PREVENTIVE MAINTENANCE BRAKE SYSTEM
- Page 187 and 188: PREVENTIVE MAINTENANCE • Do not u
- Page 189 and 190: PREVENTIVE MAINTENANCE BRAKE SYSTEM
- Page 191 and 192: PREVENTIVE MAINTENANCE be performed
- Page 193 and 194: PREVENTIVE MAINTENANCE Air System I
- Page 195 and 196: PREVENTIVE MAINTENANCE AIR SYSTEM T
- Page 197 and 198: PREVENTIVE MAINTENANCE • Maintain
- Page 199 and 200: PREVENTIVE MAINTENANCE AIR SYSTEM A
- Page 201 and 202: PREVENTIVE MAINTENANCE AIR SYSTEM H
- Page 203 and 204: PREVENTIVE MAINTENANCE Tires and Wh
- Page 205 and 206: PREVENTIVE MAINTENANCE Tire Inflati
- Page 207 and 208: PREVENTIVE MAINTENANCE TIRES AND WH
- Page 209 and 210: PREVENTIVE MAINTENANCE TIRES AND WH
- Page 211 and 212: PREVENTIVE MAINTENANCE TIRES AND WH
- Page 213 and 214: PREVENTIVE MAINTENANCE Tire Replace
- Page 215 and 216: PREVENTIVE MAINTENANCE HEATER AND A
- Page 217 and 218: PREVENTIVE MAINTENANCE ELECTRICAL S
- Page 219 and 220: PREVENTIVE MAINTENANCE Battery Cabl
MAINTENANCE SCHEDULE AND LUBRICATION<br />
PREVENTIVE MAINTENANCE<br />
Table 3<br />
Recommended Lubrication Types<br />
COMPONENTS<br />
Power Steering Gear<br />
Driveline U-Joints<br />
Slip-Joint Splines<br />
Hood Pivots<br />
Fan Drive<br />
Fifth Wheel Components<br />
Clutch Pedal Shaft<br />
Clutch Linkage<br />
Other chassis grease fittings not covered<br />
below.<br />
Wheel Bearing-Non Driving Axles<br />
Threaded Pins & Bushings (e.g., spring pins &<br />
bushings)<br />
Suspension Fittings (other than threaded pins<br />
& bushings)<br />
Steering Axle: Grease Fittings on Steering<br />
Arm; Tie Rod Ends; Drag Link; King Pins<br />
Clutch Release Bearing (remove inspection<br />
plate for access); Driveshaft Center Bearing<br />
Automatic Slack Adjusters; Wedge Brake<br />
Components; Disc Brake Caliper<br />
Automatic Transmission Fluid (ATF)<br />
RECOMMENDED LUBRICANT<br />
EP chassis grease, lithium 12-hydroxystearate or lithium complex base, NLGI 2.<br />
OIL LUBICATED: SAE 80W-90 EP gear oil, MIL-L-2105D, API GL5; or SAE 75W-90 synthetic<br />
oil<br />
GREASE LUBRICATED: EP chassis grease, lithium 12-hydroxystearate or lithium complex<br />
base, NLGI 2.<br />
EP grease, lithium 12-hydroxystearate or lithium complex base, NLGI 2, with 3% molybdenum<br />
additive: Mobil Grease Special (Mobil), Molygrease EP (Chevron), or equal.<br />
EP chassis grease, lithium 12-hydroxystearate or lithium complex base, NLGI 2.<br />
EP chassis grease, lithium 12-hydroxystearate base, NLGI 2.<br />
High temperature ball bearing grease. Chevron SRI Mobil Grease HP, Texaco Multifax 2, or<br />
equivalent.<br />
High temperature EP grease; Texaco Thermotex EP-1, Shell Darina EP-1, Mobilith AW-1,<br />
Rockwell 0-616A, or equivalent.<br />
Deviations from the above list of lubricants should be based on specifications published in the component manufacturer's manuals or otherwise<br />
approved by the manufacturer.<br />
– 166 – Y53-6033 <strong>Regional</strong> <strong>Haul</strong> (R05/10)