Regional Haul Model Operator's Manual - Peterbilt Motors Company

More documents

Recommendations

Info

MAINTENANCE SCHEDULE AND LUBRICATION PREVENTIVE MAINTENANCE Table 2 Maintenance Schedule INTERVAL COMMENTS OPERATION \ FREQUENCY 7,500 mi 12,000 km 15,000 mi 24,000 km 60,000 mi 96,000 km Air Cleaner Restriction ___ (replace if greater than 20) Vacuator Valve–Operation & Condition Mounting Bolts Leaks Interference Engine Oil Level Power Steering – Reservoir Level Power Steering Fluid – Replace Power Steering Filter – Replace Drive Belt Condition and Adjustment Air Conditioner Compressor Mounting Cold Start Aids Governor and Pump Security Seals OK High Idle: ________ rpm Emergency Shutdown Vibration Damper Condition Drain Water from Fuel System Engine Oil – Change Oil Filters – Replace Fuel Filters – Replace Engine Tune–up Cranking System: C2 C2 Daily Inspection Required Service 2XPer Year – 60,000 Mile Intervals 25,000 Mile Change Interval – Must Meet Engine Co. Requirements – 156 – Y53-6033 Regional Haul (R05/10)
PREVENTIVE MAINTENANCE MAINTENANCE SCHEDULE AND LUBRICATION Table 2 Maintenance Schedule INTERVAL COMMENTS OPERATION \ FREQUENCY 7,500 mi 12,000 km 15,000 mi 24,000 km 60,000 mi 96,000 km Visual Inspect./Loose Connections Starter Draw: _________ volts Alternator/Charging System: Visual Inspection/Loose Connections Output Voltage: _________ volts UNDER VEHICLE A B C Steering Components – Condition: Steering Gear Steering Shaft Splines and Joint(s) Pitman Arm Drag Link Steering Arms Tie Rod Arms Tie Rod Ends Radius Rods / Torque Arms Chassis Frame – Cracks or Breaks Spring Shackles and Hanger Brackets Spring Pins King Pin Wear Steer Axle Wheel Bearing - End Play Adjustment and Inspection Front Hub Lubricant Level Spring Leaves No Service Required No Service Required 350,000 Miles With LMS Outer Ends • No Leak – No Service Regional Haul (R05/10) Y53-6033 – 157 –
Page 1 and 2:
Y53-6033-RegionalHual-FrontCover.ai
Page 3 and 4:
Other Publications Order either of
Page 5 and 6:
INTRODUCTION HOW TO USE THIS MANUAL
Page 7 and 8:
INTRODUCTION Vehicle Safety Make su
Page 9 and 10:
INTRODUCTION Shop Manuals If you do
Page 11 and 12:
CAB AND FRAME ACCESS INTRODUCTION C
Page 13 and 14:
CAB AND FRAME ACCESS CAB AND FRAME
Page 15 and 16:
ENGINE ACCESS Put one hand on the h
Page 17 and 18:
ENGINE ACCESS HOOD HOLD DOWNS AND T
Page 19 and 20:
CONTROLS AND DISPLAYS INSTRUMENTS A
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
CONTROLS AND DISPLAYS Warning Light
Page 27 and 28:
CONTROLS AND DISPLAYS Warning Light
Page 29 and 30:
CONTROLS AND DISPLAYS 9. Cruise Con
Page 31 and 32:
CONTROLS AND DISPLAYS injury. 20. E
Page 33 and 34:
CONTROLS AND DISPLAYS 32. Seat Belt
Page 35 and 36:
CONTROLS AND DISPLAYS • MCS butto
Page 37 and 38:
CONTROLS AND DISPLAYS - Trip Idle P
Page 39 and 40:
Page 41 and 42:
CONTROLS AND DISPLAY STANDARD GAUGE
Page 43 and 44:
CONTROLS AND DISPLAY Engine Oil Pre
Page 45 and 46:
CONTROLS AND DISPLAY CAUTION: Keep
Page 47 and 48:
CONTROLS AND DISPLAY OPTIONAL GAUGE
Page 49 and 50:
CONTROLS AND DISPLAY operate the si
Page 51 and 52:
CONTROLS AND DISPLAY OPTIONAL GAUGE
Page 53 and 54:
CONTROLS AND DISPLAY See “Brake S
Page 55 and 56:
CONTROLS AND DISPLAY DASH- AND DOOR
Page 57 and 58:
CONTROLS AND DISPLAY ID and Clearan
Page 59 and 60:
CONTROLS AND DISPLAY WARNING! Do no
Page 61 and 62:
Page 63 and 64:
CONTROLS AND DISPLAY closed or open
Page 65 and 66:
Page 67 and 68:
CONTROLS AND DISPLAY WARNING! Do no
Page 69 and 70:
CONTROLS AND DISPLAY •If you are
Page 71 and 72:
CONTROLS AND DISPLAY CIGARETTE LIGH
Page 73 and 74:
CONTROLS AND DISPLAY SHIFT PATTERN
Page 75 and 76:
CONTROLS AND DISPLAY NOTE: The map
Page 77 and 78:
SEATS SAFETY RESTRAINT BELTS CHUGGE
Page 79 and 80:
SEATS • Belts should fit snugly a
Page 81 and 82:
SEATS Safety Restraint Tips NOTE: P
Page 83 and 84:
SEATS Komfort-Lok® Latch Your Pete
Page 85 and 86:
DRIVER'S CHECKLIST SAFE VEHICLE OPE
Page 87 and 88:
DRIVER'S CHECKLIST GAWR: is the Gro
Page 89 and 90:
DRIVER'S CHECKLIST 7. Steps and Han
Page 91 and 92:
STARTING AND OPERATING THE VEHICLE
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
Page 107 and 108:
Page 109 and 110: STARTING AND OPERATING THE VEHICLE
Page 151 and 152: PREVENTIVE MAINTENANCE • Disconne
Page 153 and 154: PREVENTIVE MAINTENANCE Maintenance
Page 155 and 156: PREVENTIVE MAINTENANCE MAINTENANCE
Page 159: PREVENTIVE MAINTENANCE MAINTENANCE
Page 167 and 168: PREVENTIVE MAINTENANCE Lubrication
Page 171 and 172: PREVENTIVE MAINTENANCE ENGINE MAINT
Page 173 and 174: PREVENTIVE MAINTENANCE • When dra
Page 179 and 180: PREVENTIVE MAINTENANCE ENGINE COOLI
Page 181 and 182: PREVENTIVE MAINTENANCE ENGINE COOLI
Page 183 and 184: PREVENTIVE MAINTENANCE 10. Operate
Page 185 and 186: PREVENTIVE MAINTENANCE BRAKE SYSTEM
Page 187 and 188: PREVENTIVE MAINTENANCE • Do not u
Page 189 and 190: PREVENTIVE MAINTENANCE BRAKE SYSTEM
Page 191 and 192: PREVENTIVE MAINTENANCE be performed
Page 193 and 194: PREVENTIVE MAINTENANCE Air System I
Page 195 and 196: PREVENTIVE MAINTENANCE AIR SYSTEM T
Page 197 and 198: PREVENTIVE MAINTENANCE • Maintain
Page 199 and 200: PREVENTIVE MAINTENANCE AIR SYSTEM A
Page 201 and 202: PREVENTIVE MAINTENANCE AIR SYSTEM H
Page 203 and 204: PREVENTIVE MAINTENANCE Tires and Wh
Page 205 and 206: PREVENTIVE MAINTENANCE Tire Inflati
Page 207 and 208: PREVENTIVE MAINTENANCE TIRES AND WH
Page 209 and 210: PREVENTIVE MAINTENANCE TIRES AND WH
Page 211 and 212:
PREVENTIVE MAINTENANCE TIRES AND WH
Page 213 and 214:
PREVENTIVE MAINTENANCE Tire Replace
Page 215 and 216:
PREVENTIVE MAINTENANCE HEATER AND A
Page 217 and 218:
PREVENTIVE MAINTENANCE ELECTRICAL S
Page 219 and 220:
PREVENTIVE MAINTENANCE Battery Cabl
Page 221 and 222:
PREVENTIVE MAINTENANCE Undercharge:
Page 223 and 224:
PREVENTIVE MAINTENANCE WARNING! To
Page 225 and 226:
PREVENTIVE MAINTENANCE ELECTRICAL S
Page 227 and 228:
PREVENTIVE MAINTENANCE Bulb Replace
Page 229 and 230:
PREVENTIVE MAINTENANCE Cleaning, Pr
Page 231 and 232:
PREVENTIVE MAINTENANCE CAB MAINTENA
Page 233 and 234:
PREVENTIVE MAINTENANCE Interior Tri
Page 235 and 236:
PREVENTIVE MAINTENANCE Inspection G
Page 237 and 238:
PREVENTIVE MAINTENANCE 7. Mounting
Page 239 and 240:
PREVENTIVE MAINTENANCE TRANSMISSION
Page 241 and 242:
PREVENTIVE MAINTENANCE As the clutc
Page 243 and 244:
PREVENTIVE MAINTENANCE Steering and
Page 245 and 246:
PREVENTIVE MAINTENANCE 2. If you ch
Page 247 and 248:
PREVENTIVE MAINTENANCE Axle Lubrica
Page 249 and 250:
PREVENTIVE MAINTENANCE Rear Axle an
Page 251 and 252:
PREVENTIVE MAINTENANCE REAR AXLE AN
Page 253 and 254:
PREVENTIVE MAINTENANCE REAR AXLE AN
Page 255 and 256:
PREVENTIVE MAINTENANCE FRAME AND FI
Page 257 and 258:
PREVENTIVE MAINTENANCE Engine Cooli
Page 259 and 260:
PREVENTIVE MAINTENANCE Check fan bl
Page 261 and 262:
PREVENTIVE MAINTENANCE MAINTENANCE
Page 263 and 264:
PREVENTIVE MAINTENANCE CONSUMER INF
Page 265 and 266:
Page 267 and 268:
Page 269 and 270:
INDEX C lubrication 182 operation 1
Page 271 and 272:
INDEX E vehicle inspection 81 with
Page 273 and 274:
INDEX I Headllights 15 Heater and a
Page 275 and 276:
INDEX R R Radio 16, 71 Rear axle 24
Page 277:
INDEX V Underinflated tires 201 V V
show all

Regional Haul Model Operator's Manual - Peterbilt Motors Company

Create successful ePaper yourself

Delete template?

Save as template?