Regional Haul Model Operator's Manual - Peterbilt Motors Company

More documents

Recommendations

Info

MAINTENANCE SCHEDULE AND LUBRICATION PREVENTIVE MAINTENANCE Table 1 Recommended Maintenance Intervals ITEM INTERVAL COMMENTS Brake Pad Lining Inspection 7,500 mile Minimum 3/16 in. thickness Rotor Inspection 15,000 miles or 15 mos Power Steering Fluid Reservoir Check Fluid Level 7,500 miles Use Automatic Transmission Fluid (ATF) Change Fluid 60,000 miles or twice per year Use Automatic Transmission Fluid (ATF) Maintenance Schedule Use Table 2, ”Maintenance Schedule,” as a guide to plan service work. Be sure and follow the frequency recommendations for your vehicle. Table 2 Maintenance Schedule C2 C4 E2 G2 INTERVAL TABLE KEY NOTE: If a scheduled service interval is shaded, skip to the next interval. The frequency of each service operation is identified by open (non-shaded areas). Federal Annual Inspection 120,000 miles/192,000 km only. Federal Annual Inspection 240,000 miles/384,000 km only. 50,000 Mile Service Interval Synthetic Lube Required – 500,000 Drain COMMENTS OPERATION \ FREQUENCY 7,500 mi 12,000 km 15,000 mi 24,000 km 60,000 mi 96,000 km INITIAL DRIVE–IN A B C Clutch Brake – 152 – Y53-6033 Regional Haul (R05/10)
PREVENTIVE MAINTENANCE MAINTENANCE SCHEDULE AND LUBRICATION Table 2 Maintenance Schedule INTERVAL COMMENTS OPERATION \ FREQUENCY 7,500 mi 12,000 km 15,000 mi 24,000 km 60,000 mi 96,000 km Clutch Pedal Free Travel _____ inches Glass for Cracks or Chips Door Window Operation Radio Interior Lights Interior Appearance: Seats Floor Mats Door Panels Headliner Sleeper Dash Covers Wiper Operation Wiper Blade Condition Horns (Electric and Air) Mirrors SAFETY EQUIPMENT A B C Drain Water from Air Tanks Air Tank Check Valve Emergency Operation of Spring Brakes Air Press. Build–up time: _______ min. Governed Air Pressure: _______ psi Air Press. Drop–Brakes not Applied: ___ Air Press. Drop–Brakes Applied: ___ Regional Haul (R05/10) Y53-6033 – 153 –
Page 1 and 2:
Y53-6033-RegionalHual-FrontCover.ai
Page 3 and 4:
Other Publications Order either of
Page 5 and 6:
INTRODUCTION HOW TO USE THIS MANUAL
Page 7 and 8:
INTRODUCTION Vehicle Safety Make su
Page 9 and 10:
INTRODUCTION Shop Manuals If you do
Page 11 and 12:
CAB AND FRAME ACCESS INTRODUCTION C
Page 13 and 14:
CAB AND FRAME ACCESS CAB AND FRAME
Page 15 and 16:
ENGINE ACCESS Put one hand on the h
Page 17 and 18:
ENGINE ACCESS HOOD HOLD DOWNS AND T
Page 19 and 20:
CONTROLS AND DISPLAYS INSTRUMENTS A
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
CONTROLS AND DISPLAYS Warning Light
Page 27 and 28:
CONTROLS AND DISPLAYS Warning Light
Page 29 and 30:
CONTROLS AND DISPLAYS 9. Cruise Con
Page 31 and 32:
CONTROLS AND DISPLAYS injury. 20. E
Page 33 and 34:
CONTROLS AND DISPLAYS 32. Seat Belt
Page 35 and 36:
CONTROLS AND DISPLAYS • MCS butto
Page 37 and 38:
CONTROLS AND DISPLAYS - Trip Idle P
Page 39 and 40:
Page 41 and 42:
CONTROLS AND DISPLAY STANDARD GAUGE
Page 43 and 44:
CONTROLS AND DISPLAY Engine Oil Pre
Page 45 and 46:
CONTROLS AND DISPLAY CAUTION: Keep
Page 47 and 48:
CONTROLS AND DISPLAY OPTIONAL GAUGE
Page 49 and 50:
CONTROLS AND DISPLAY operate the si
Page 51 and 52:
CONTROLS AND DISPLAY OPTIONAL GAUGE
Page 53 and 54:
CONTROLS AND DISPLAY See “Brake S
Page 55 and 56:
CONTROLS AND DISPLAY DASH- AND DOOR
Page 57 and 58:
CONTROLS AND DISPLAY ID and Clearan
Page 59 and 60:
CONTROLS AND DISPLAY WARNING! Do no
Page 61 and 62:
Page 63 and 64:
CONTROLS AND DISPLAY closed or open
Page 65 and 66:
Page 67 and 68:
CONTROLS AND DISPLAY WARNING! Do no
Page 69 and 70:
CONTROLS AND DISPLAY •If you are
Page 71 and 72:
CONTROLS AND DISPLAY CIGARETTE LIGH
Page 73 and 74:
CONTROLS AND DISPLAY SHIFT PATTERN
Page 75 and 76:
CONTROLS AND DISPLAY NOTE: The map
Page 77 and 78:
SEATS SAFETY RESTRAINT BELTS CHUGGE
Page 79 and 80:
SEATS • Belts should fit snugly a
Page 81 and 82:
SEATS Safety Restraint Tips NOTE: P
Page 83 and 84:
SEATS Komfort-Lok® Latch Your Pete
Page 85 and 86:
DRIVER'S CHECKLIST SAFE VEHICLE OPE
Page 87 and 88:
DRIVER'S CHECKLIST GAWR: is the Gro
Page 89 and 90:
DRIVER'S CHECKLIST 7. Steps and Han
Page 91 and 92:
STARTING AND OPERATING THE VEHICLE
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
Page 101 and 102:
Page 103 and 104:
Page 105 and 106: STARTING AND OPERATING THE VEHICLE
Page 151 and 152: PREVENTIVE MAINTENANCE • Disconne
Page 153 and 154: PREVENTIVE MAINTENANCE Maintenance
Page 155: PREVENTIVE MAINTENANCE MAINTENANCE
Page 159 and 160: PREVENTIVE MAINTENANCE MAINTENANCE
Page 167 and 168: PREVENTIVE MAINTENANCE Lubrication
Page 171 and 172: PREVENTIVE MAINTENANCE ENGINE MAINT
Page 173 and 174: PREVENTIVE MAINTENANCE • When dra
Page 179 and 180: PREVENTIVE MAINTENANCE ENGINE COOLI
Page 181 and 182: PREVENTIVE MAINTENANCE ENGINE COOLI
Page 183 and 184: PREVENTIVE MAINTENANCE 10. Operate
Page 185 and 186: PREVENTIVE MAINTENANCE BRAKE SYSTEM
Page 187 and 188: PREVENTIVE MAINTENANCE • Do not u
Page 189 and 190: PREVENTIVE MAINTENANCE BRAKE SYSTEM
Page 191 and 192: PREVENTIVE MAINTENANCE be performed
Page 193 and 194: PREVENTIVE MAINTENANCE Air System I
Page 195 and 196: PREVENTIVE MAINTENANCE AIR SYSTEM T
Page 197 and 198: PREVENTIVE MAINTENANCE • Maintain
Page 199 and 200: PREVENTIVE MAINTENANCE AIR SYSTEM A
Page 201 and 202: PREVENTIVE MAINTENANCE AIR SYSTEM H
Page 203 and 204: PREVENTIVE MAINTENANCE Tires and Wh
Page 205 and 206: PREVENTIVE MAINTENANCE Tire Inflati
Page 207 and 208:
PREVENTIVE MAINTENANCE TIRES AND WH
Page 209 and 210:
Page 211 and 212:
Page 213 and 214:
PREVENTIVE MAINTENANCE Tire Replace
Page 215 and 216:
PREVENTIVE MAINTENANCE HEATER AND A
Page 217 and 218:
PREVENTIVE MAINTENANCE ELECTRICAL S
Page 219 and 220:
PREVENTIVE MAINTENANCE Battery Cabl
Page 221 and 222:
PREVENTIVE MAINTENANCE Undercharge:
Page 223 and 224:
PREVENTIVE MAINTENANCE WARNING! To
Page 225 and 226:
PREVENTIVE MAINTENANCE ELECTRICAL S
Page 227 and 228:
PREVENTIVE MAINTENANCE Bulb Replace
Page 229 and 230:
PREVENTIVE MAINTENANCE Cleaning, Pr
Page 231 and 232:
PREVENTIVE MAINTENANCE CAB MAINTENA
Page 233 and 234:
PREVENTIVE MAINTENANCE Interior Tri
Page 235 and 236:
PREVENTIVE MAINTENANCE Inspection G
Page 237 and 238:
PREVENTIVE MAINTENANCE 7. Mounting
Page 239 and 240:
PREVENTIVE MAINTENANCE TRANSMISSION
Page 241 and 242:
PREVENTIVE MAINTENANCE As the clutc
Page 243 and 244:
PREVENTIVE MAINTENANCE Steering and
Page 245 and 246:
PREVENTIVE MAINTENANCE 2. If you ch
Page 247 and 248:
PREVENTIVE MAINTENANCE Axle Lubrica
Page 249 and 250:
PREVENTIVE MAINTENANCE Rear Axle an
Page 251 and 252:
PREVENTIVE MAINTENANCE REAR AXLE AN
Page 253 and 254:
PREVENTIVE MAINTENANCE REAR AXLE AN
Page 255 and 256:
PREVENTIVE MAINTENANCE FRAME AND FI
Page 257 and 258:
PREVENTIVE MAINTENANCE Engine Cooli
Page 259 and 260:
PREVENTIVE MAINTENANCE Check fan bl
Page 261 and 262:
PREVENTIVE MAINTENANCE MAINTENANCE
Page 263 and 264:
PREVENTIVE MAINTENANCE CONSUMER INF
Page 265 and 266:
Page 267 and 268:
Page 269 and 270:
INDEX C lubrication 182 operation 1
Page 271 and 272:
INDEX E vehicle inspection 81 with
Page 273 and 274:
INDEX I Headllights 15 Heater and a
Page 275 and 276:
INDEX R R Radio 16, 71 Rear axle 24
Page 277:
INDEX V Underinflated tires 201 V V
show all

Regional Haul Model Operator's Manual - Peterbilt Motors Company

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?