Medium Duty Operator's Manual - Peterbilt Motors Company

More documents

Recommendations

Info

INDEX U U-Bolt torque 242 Underbody maintenance 225 Underinflated tires 202 V Vehicle driving 81 loading 82 weight rating 82, 129, 261 Vehicle inspections 81 W WAIT TO START light 89 Warning Light Symbols table 20 Warranty 147, 149, 243, 249, 251, 252 Water Temperature 15 Weekly operations 86 Weight rating 82, 129 Welding 222, 249 Wet Brakes 121 Wet tank 116 Wheel and Tire Replacement, hydraulic brakes 210 Wheel bearing grease 164 lubrication 240 wheel cylinders 118 Wheels and tires 200 general safety requirements 200 load rating 203 overinflation 203 proper inflation 202 replacement 200, 209 tightening sequence 204 tire inspection 201 tread depth 209 underinflation 202 wheel mounting and fastening 200 wheel nut torque 204 Windshield washer reservoir 232 Windshield washer reservoir 45 – 272 – Y53-6008A Medium Duty (R05/09)
Other Publications Order either of the two publications shown below through your Peterbilt dealer. There is a charge for each. Allow four weeks for delivery. 02956A 02956B Custom Maintenance Manual This manual contains both proprietary and supplier service information specifically compiled for the components on your vehicle. The material in this manual is the same as that used by Peterbilt dealers. It includes inspection, maintenance, overhaul, and troubleshooting procedures. Owner’s Custom Parts Book This book is a complete, unillustrated, computer-generated list of the parts used to custom-build your Peterbilt vehicle. Please provide your Chassis Serial Number when ordering.
Page 2 and 3:
Quick Table of Contents •Introduc
Page 4 and 5:
INTRODUCTION WARNING When you see t
Page 6 and 7:
INTRODUCTION A Special Word About R
Page 8 and 9:
INTRODUCTION Other Sources Another
Page 10 and 11:
CAB AND FRAME ACCESS 02611 • Use
Page 12 and 13:
HOOD HOLD DOWNS AND TILT Put one ha
Page 14 and 15:
INSTRUMENTS AND CONTROLS CONTROLS A
Page 16 and 17:
Page 18 and 19:
Page 20 and 21:
INSTRUMENTS AND CONTROLS include bu
Page 22 and 23:
INSTRUMENTS AND CONTROLS Warning Li
Page 24 and 25:
INSTRUMENTS AND CONTROLS Illuminate
Page 26 and 27:
INSTRUMENTS AND CONTROLS 19. Engine
Page 28 and 29:
INSTRUMENTS AND CONTROLS 33. Tire I
Page 30 and 31:
INSTRUMENTS AND CONTROLS • MCS bu
Page 32 and 33:
INSTRUMENTS AND CONTROLS - PTO Hour
Page 34 and 35:
Page 36 and 37:
STANDARD GAUGES CONTROLS AND DISPLA
Page 38 and 39:
STANDARD GAUGES Engine Oil Pressure
Page 40 and 41:
STANDARD GAUGES the warning light d
Page 42 and 43:
OPTIONAL GAUGES WARNING! The air pr
Page 44 and 45:
OPTIONAL GAUGES High Beam Headlamps
Page 46 and 47:
OPTIONAL GAUGES To Wash The Windshi
Page 48 and 49:
DASH- AND DOOR-MOUNTED FEATURES To
Page 50 and 51:
DASH- AND DOOR-MOUNTED FEATURES CON
Page 52 and 53:
DASH- AND DOOR-MOUNTED FEATURES Fog
Page 54 and 55:
DASH- AND DOOR-MOUNTED FEATURES cru
Page 56 and 57:
DASH- AND DOOR-MOUNTED FEATURES CON
Page 58 and 59:
DASH- AND DOOR-MOUNTED FEATURES Man
Page 60 and 61:
DASH- AND DOOR-MOUNTED FEATURES WAR
Page 62 and 63:
DASH- AND DOOR-MOUNTED FEATURES (2)
Page 64 and 65:
HEATER-AIR CONDITIONING CONTROLS He
Page 66 and 67:
HEATER-AIR CONDITIONING CONTROLS CO
Page 68 and 69:
CUPHOLDERS/ASHTRAY prevent damage s
Page 70 and 71:
ACCESSORIES Accessories Peterbilt N
Page 72 and 73:
SEATS Seats Introduction This secti
Page 74 and 75:
SEATS WARNING! Do not drive vehicle
Page 76 and 77:
SEATS • Be sure, also, that your
Page 78 and 79:
SEATS • If any seat belt is not w
Page 80 and 81:
SEATS During Pregnancy Pregnant wom
Page 82 and 83:
DRIVER'S CHECK LIST WARNING! Do not
Page 84 and 85:
DRIVER'S CHECK LIST Engine Compartm
Page 86 and 87:
DRIVER'S CHECK LIST 3. Mirrors—ch
Page 88 and 89:
STARTING AND OPERATING THE VEHICLE
Page 90 and 91:
Page 92 and 93:
Page 94 and 95:
Page 96 and 97:
OPERATING THE TRANSMISSION Operatin
Page 98 and 99:
OPERATING THE TRANSMISSION The best
Page 100 and 101:
OPERATING THE TRANSMISSION Release
Page 102 and 103:
USING THE BRAKE SYSTEM Brake Operat
Page 104 and 105:
USING THE BRAKE SYSTEM (2) Trailer
Page 106 and 107:
USING THE BRAKE SYSTEM STARTING AND
Page 108 and 109:
USING THE BRAKE SYSTEM Front Brakes
Page 110 and 111:
USING THE BRAKE SYSTEM Use engine c
Page 112 and 113:
USING THE BRAKE SYSTEM NOTE: A “p
Page 114 and 115:
USING THE BRAKE SYSTEM WARNING! Do
Page 116 and 117:
USING THE BRAKE SYSTEM Brake Compon
Page 118 and 119:
USING THE BRAKE SYSTEM to the trail
Page 120 and 121:
USING THE BRAKE SYSTEM Hydraulic Bo
Page 122 and 123:
USING THE BRAKE SYSTEM sion. You co
Page 124 and 125:
OPERATING THE REAR/DRIVE AXLE START
Page 126 and 127:
OPERATING THE REAR/DRIVE AXLE Under
Page 128 and 129:
DRIVING TIPS AND TECHNIQUES ure or
Page 130 and 131:
DRIVING TIPS AND TECHNIQUES STARTIN
Page 132 and 133:
DRIVING TIPS AND TECHNIQUES WARNING
Page 134 and 135:
DRIVING TIPS AND TECHNIQUES Driving
Page 136 and 137:
DRIVING TIPS AND TECHNIQUES WARNING
Page 138 and 139:
VEHICLE RECOVERY AND SPRING BRAKES
Page 140 and 141:
Page 142 and 143:
Page 144 and 145:
SHUT-DOWN 3. Drain water from the a
Page 146 and 147:
Introduction Preventive Maintenance
Page 148 and 149:
Introduction tive harm. This warnin
Page 150 and 151:
Maintenance Schedule and Lubricatio
Page 152 and 153:
Page 154 and 155:
Page 156 and 157:
Page 158 and 159:
Page 160 and 161:
Page 162 and 163:
Page 164 and 165:
Page 166 and 167:
Page 168 and 169:
Page 170 and 171:
Engine Maintenance Fuel System Spec
Page 172 and 173:
Engine Maintenance Emission Compone
Page 174 and 175:
Engine Cooling System • The leadi
Page 176 and 177:
Engine Cooling System Topping Off W
Page 178 and 179:
Engine Cooling System Preventive Ma
Page 180 and 181:
Brake System BRAKE SYSTEM If your t
Page 182 and 183:
Brake System • Do not use pressur
Page 184 and 185:
Brake System Constant manual adjust
Page 186 and 187:
Brake System Make sure that the flu
Page 188 and 189:
Brake System Visually inspect brake
Page 190 and 191:
Brake System Preventive Maintenance
Page 192 and 193:
Air System Scheduled Maintenance Ta
Page 194 and 195:
Air System CAUTION: Do not use pene
Page 196 and 197:
Air System CAUTION: When draining t
Page 198 and 199:
Air System High Frequency Vibration
Page 200 and 201:
Tires and Wheels Introduction TIRES
Page 202 and 203:
Tires and Wheels Tire Inflation Mos
Page 204 and 205:
Tires and Wheels Wheel Mounting and
Page 206 and 207:
Tires and Wheels Preventive Mainten
Page 208 and 209:
Tires and Wheels Preventive Mainten
Page 210 and 211:
Tires and Wheels Wheel and Tire Rep
Page 212 and 213:
Heater and Air Conditioner CAUTION:
Page 214 and 215:
Electrical System All the electrica
Page 216 and 217:
Electrical System Overcharge: this
Page 218 and 219:
Electrical System before proceeding
Page 220 and 221:
Electrical System • When fast cha
Page 222 and 223: Electrical System Electrical and Al
Page 224 and 225: Cab Maintenance Cleaning, Protectio
Page 226 and 227: Cab Maintenance At least every spri
Page 228 and 229: Cab Maintenance • Remove soap wit
Page 230 and 231: Cab Maintenance Preventive Maintena
Page 232 and 233: Cab Maintenance Preventive Maintena
Page 234 and 235: Transmission and Clutch Preventive
Page 236 and 237: Transmission and Clutch Automatic T
Page 238 and 239: Steering and Driveline Preventive M
Page 240 and 241: Front Axle and Suspension Preventiv
Page 242 and 243: Front Axle and Suspension Torque CA
Page 244 and 245: Rear Axle and Suspension It is impo
Page 246 and 247: Rear Axle and Suspension Preventive
Page 248 and 249: Rear Axle and Suspension Grade 8 Ca
Page 250 and 251: Frame and Fifth Wheel Fifth Wheel M
Page 252 and 253: Noise and Emission Control Engine
Page 254 and 255: Noise and Emission Control Transmis
Page 256 and 257: Noise and Emission Control Preventi
Page 258 and 259: Consumer Information and Vehicle Id
Page 264 and 265: INDEX INDEX A Accessories 70 Air co
Page 266 and 267: INDEX Cooling system conventional c
Page 268 and 269: INDEX G Gauges and Displays 35 Driv
Page 270 and 271: INDEX use 62, 88, 97, 121, 143, 146
Page 274: Y53-6008A 06/09 Printed in the U.S.
show all

Medium Duty Operator's Manual - Peterbilt Motors Company

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?