MODEL 330 OPERATOR'S MANUAL - Peterbilt Motors Company

More documents

Recommendations

Info

Maintenance Schedule and Lubrication Preventive Maintenance Table 3 Maintenance Schedule INTERVAL COMMENTS OPERATION \ FREQUENCY 7,500 mi 12,000 km 15,000 mi 24,000 km 60,000 mi 96,000 km Emergency Flasher Brake Lights Backup/Loading Lights License Plates: Permits and Mounting Mud Flaps / Serviceable Fuel Tank Mounting Exhaust System–Condition and Mounting Bolts Frame Fastener Torque: does NOT apply to Le Jeune frame fasteners. C2 Lubricate: Door Hinges and Latches Body Mounts (Straight Truck Only) Body Sides and Roof Panels (Straight trucks) Cab: Hold–down Latches Mounts Front Pivot Assembly Jack Operation and Leaks Safety Lock, Tip–Over Stop ENGINE SERVICE A B C Cooling: Check Supplemental Additive/ Conditioner to Manufacturer Specifications _______ % Coolant Level Coolant Protection: _______ degrees Pressure Test – 126 – PB1318 3/01 Model <strong>330</strong>
Preventive Maintenance Maintenance Schedule and Lubrication Table 3 Maintenance Schedule INTERVAL COMMENTS OPERATION \ FREQUENCY 7,500 mi 12,000 km 15,000 mi 24,000 km 60,000 mi 96,000 km Replace Water Filter Hose Condition and Connections Radiator Mounting Fan Shroud Fan Assembly and Idler Pulley Check Water Pump for Leaks / Play Radiator – Exterior Condition Replace Engine Coolant Air Cleaner: Contaminant Accumulation Air Cleaner Restriction ___ (replace if greater than 20) Vacuator Valve–Operation & Condition Mounting Bolts Leaks Interference Engine Oil Level Power Steering – Reservoir Level Power Steering Fluid – Replace Power Steering Filter – Replace Drive Belt Condition and Adjustment Air Conditioner Compressor Mounting Cold Start Aids C4 C2 New Release At 100–120K – Per Engine Filter Manufacturer Recommendations No Service Required Fill as Required – Extended Drain Per Manufacturer Specifications. Daily Inspection Required Service 2XPer Year – 60,000 Mile Intervals Model <strong>330</strong> PB1318 3/01 – 127 –
Page 1 and 2:
MODEL 330 OPERATOR’S MANUAL
Page 3 and 4:
Peterbilt Model 330 CONTENTS Introd
Page 5 and 6:
Interaxle Differential Lock . . . .
Page 7 and 8:
Torque . . . . . . . . . . . . . .
Page 9 and 10:
Introduction INTRODUCTION How to Us
Page 11 and 12:
Introduction Vehicle Safety Make su
Page 13 and 14:
Introduction Medium Duty Body Build
Page 15 and 16:
Operating Instructions Start-Up OPE
Page 17 and 18:
Operating Instructions Hood Hold Do
Page 19 and 20:
Operating Instructions • knows an
Page 21 and 22:
Operating Instructions Start-Up The
Page 23 and 24:
Operating Instructions • See page
Page 25 and 26:
Operating Instructions Instruments
Page 27 and 28:
Operating Instructions Self Test Wh
Page 29 and 30:
Page 31 and 32:
Operating Instructions D. Return th
Page 33 and 34:
Operating Instructions 3. Place the
Page 35 and 36:
Operating Instructions Fuel Gauge T
Page 37 and 38:
Page 39 and 40:
Page 41 and 42:
Operating Instructions IGN & ACC: I
Page 43 and 44:
Operating Instructions Using the Pa
Page 45 and 46:
Operating Instructions HEATING AND
Page 47 and 48:
Operating Instructions Heating To h
Page 49 and 50:
Operating Instructions Radio ACCESS
Page 51 and 52:
Operating Instructions Introduction
Page 53 and 54:
Operating Instructions Seats • Be
Page 55 and 56:
Operating Instructions WARNING! Do
Page 57 and 58:
Operating Instructions Komfort-Lok
Page 59 and 60:
Operating Instructions STEERING COL
Page 61 and 62:
Operating Instructions Steering Col
Page 63 and 64:
Operating Instructions Introduction
Page 65 and 66:
Operating Instructions • Wait two
Page 67 and 68:
Operating Instructions Cold Weather
Page 69 and 70:
Operating Instructions • During t
Page 71 and 72:
Operating Instructions Reengaging t
Page 73 and 74:
Operating Instructions 1. Put the t
Page 75 and 76:
Operating Instructions During Norma
Page 77 and 78:
Operating Instructions Operating th
Page 79 and 80:
Operating Instructions Brake Operat
Page 81 and 82:
Operating Instructions (2) Trailer
Page 83 and 84: Operating Instructions Using the Br
Page 85 and 86: Operating Instructions Front Brakes
Page 87 and 88: Operating Instructions To prevent d
Page 89 and 90: Operating Instructions • If a tra
Page 91 and 92: Operating Instructions On tractors
Page 93 and 94: Operating Instructions The wet tank
Page 95 and 96: Operating Instructions Brake Compon
Page 97 and 98: Operating Instructions 1. Slow down
Page 99 and 100: Operating Instructions Using the Br
Page 101 and 102: Operating Instructions OPERATING TH
Page 103 and 104: Operating Instructions going down s
Page 105 and 106: Operating Instructions mission into
Page 107 and 108: Operating Instructions • When dri
Page 109 and 110: Operating Instructions • Always k
Page 111 and 112: Operating Instructions TYPICAL HEIG
Page 113 and 114: Operating Instructions WARNING! Do
Page 115 and 116: Operating Instructions Fifth Wheel
Page 117 and 118: Operating Instructions Vehicle Reco
Page 119 and 120: Operating Instructions with wheel c
Page 121 and 122: Operating Instructions Vehicle Reco
Page 123 and 124: Operating Instructions 3. Drain wat
Page 125 and 126: PREVENTIVE MAINTENANCE INTRODUCTION
Page 127 and 128: Preventive Maintenance CAUTION: Han
Page 129 and 130: Preventive Maintenance Maintenance
Page 133: Preventive Maintenance Maintenance
Page 143 and 144: Preventive Maintenance Lubrication
Page 147 and 148: Preventive Maintenance ENGINE MAINT
Page 149 and 150: Preventive Maintenance NOTE: To exp
Page 151 and 152: Preventive Maintenance Engine Maint
Page 153 and 154: Preventive Maintenance COOLING SYST
Page 155 and 156: Preventive Maintenance Cooling Syst
Page 157 and 158: Preventive Maintenance NOTE: Avoid
Page 159 and 160: Preventive Maintenance CAUTION: Do
Page 161 and 162: Preventive Maintenance BRAKE SYSTEM
Page 163 and 164: Preventive Maintenance Brake Lining
Page 165 and 166: Preventive Maintenance Hydraulic Br
Page 167 and 168: Preventive Maintenance Brake System
Page 169 and 170: Preventive Maintenance Anti-Lock Br
Page 171 and 172: Preventive Maintenance Introduction
Page 173 and 174: Preventive Maintenance Air System F
Page 175 and 176: Preventive Maintenance Follow the p
Page 177 and 178: Preventive Maintenance amounts of m
Page 179 and 180: Preventive Maintenance Air System C
Page 181 and 182: Preventive Maintenance Tires and Wh
Page 183 and 184: Preventive Maintenance • Too much
Page 185 and 186:
Preventive Maintenance Tires and Wh
Page 187 and 188:
Preventive Maintenance Demounted Ri
Page 189 and 190:
Preventive Maintenance Tire Replace
Page 191 and 192:
Preventive Maintenance HEATER AND A
Page 193 and 194:
Preventive Maintenance Electrical S
Page 195 and 196:
Preventive Maintenance Removing and
Page 197 and 198:
Preventive Maintenance CAUTION: App
Page 199 and 200:
Preventive Maintenance 5. Start the
Page 201 and 202:
Preventive Maintenance • Never us
Page 203 and 204:
Preventive Maintenance CAB MAINTENA
Page 205 and 206:
Preventive Maintenance CAUTION: Do
Page 207 and 208:
Preventive Maintenance Due to these
Page 209 and 210:
Preventive Maintenance Cab Maintena
Page 211 and 212:
Preventive Maintenance Transmission
Page 213 and 214:
Preventive Maintenance Automatic Tr
Page 215 and 216:
Preventive Maintenance Steering and
Page 217 and 218:
Preventive Maintenance Front Axle a
Page 219 and 220:
Preventive Maintenance Torque CAUTI
Page 221 and 222:
Preventive Maintenance vice life of
Page 223 and 224:
Preventive Maintenance Rear Axle an
Page 225 and 226:
Preventive Maintenance Grade 8 Caps
Page 227 and 228:
Preventive Maintenance Fifth Wheel
Page 229 and 230:
Preventive Maintenance Engine • R
Page 231 and 232:
Preventive Maintenance Maintenance
Page 233 and 234:
Preventive Maintenance Noise and Em
Page 235 and 236:
Preventive Maintenance • The Chas
Page 237 and 238:
Preventive Maintenance WARNING! Do
Page 239 and 240:
A Accessories 41 Adjustable Tilt Co
Page 241 and 242:
oil pressure gauge 24 overheating 2
Page 243 and 244:
Parking Brake Component Inspection
Page 245 and 246:
Vehicle Component Register Vehicle
Page 247 and 248:
Other Publications MEDIUM DUTY Main
show all

MODEL 330 OPERATOR'S MANUAL - Peterbilt Motors Company

Create successful ePaper yourself

Delete template?

Save as template?