MODEL 330 OPERATOR'S MANUAL - Peterbilt Motors Company
MODEL 330 OPERATOR'S MANUAL - Peterbilt Motors Company MODEL 330 OPERATOR'S MANUAL - Peterbilt Motors Company
Maintenance Schedule and Lubrication Preventive Maintenance Table 2 Recommended Maintenance Intervals ITEM INTERVAL COMMENTS Rear Wheel Bearings 100,000 With LMS Wheel End Package Rear Brake Camshafts 10,000–15,000 Synthetic Grease With Special Fittings Fifth Wheel 10,000–15,000 40 to 60K For Adjustment Spring Pins 10,000–15,000 With Rubber Bushed Pins – No Service Front & Rear Slack Adjusters 10,000–15,000 Synthetic Grease With Special Fittings King Pins 10,000–15,000 Front Wheel Bearings 100,000 Eaton LMS Accelerator Linkage None Engine Lubricating Oil – Check Fluid Level Daily Trip Check – Change Oil 10,000–15,000 Must Meet Engine Company Specifications Spring Shackle Pins 10,000–15,000 No Service With Rubber Bushed Spring Pins Clutch Linkage 10,000–15,000 Clutch Release Bearing 10,000–15,000 Extended Grease Fittings Clutch Cross Shaft 10,000–15,000 Extended Grease Fittings Door Weatherstrip As Required Lock Cylinders As Required Door Hinges As Required Teflon Bushing Door Latches and Striker Plate As Required Driveshaft – U-Joints 10,000–15,000 SPL Driveline, Up To 100,000 Miles – Slip Joints 10,000–15,000 SPL Driveline Center Bearing None Suspension Per Specifications AG200 – Synthetic Grease With Special Fitting – 122 – PB1318 3/01 Model 330
Preventive Maintenance Maintenance Schedule and Lubrication Table 2 Recommended Maintenance Intervals ITEM INTERVAL COMMENTS Hydraulic Brakes Brake Pad Lining Inspection 7,500 mile Minimum 3/16 in. thickness Rotor Inspection 15,000 miles or 15 mos Park Brake Inspection 15,000 miles or 15 mos Brake Fluid Reservoir Check Fluid Level 7,500 miles Use DOT 3 brake fluid only Change Fluid Every 2 years Use DOT 3 brake fluid only Power Steering Fluid Reservoir Check Fluid Level Change Fluid 7,500 miles 60,000 miles or twice per year Use Automatic Transmission Fluid (ATF) Type E or F or Dexron II Use Automatic Transmission Fluid (ATF) Type E or F or Dexron II Model 330 PB1318 3/01 – 123 –
- Page 79 and 80: Operating Instructions Brake Operat
- Page 81 and 82: Operating Instructions (2) Trailer
- Page 83 and 84: Operating Instructions Using the Br
- Page 85 and 86: Operating Instructions Front Brakes
- Page 87 and 88: Operating Instructions To prevent d
- Page 89 and 90: Operating Instructions • If a tra
- Page 91 and 92: Operating Instructions On tractors
- Page 93 and 94: Operating Instructions The wet tank
- Page 95 and 96: Operating Instructions Brake Compon
- Page 97 and 98: Operating Instructions 1. Slow down
- Page 99 and 100: Operating Instructions Using the Br
- Page 101 and 102: Operating Instructions OPERATING TH
- Page 103 and 104: Operating Instructions going down s
- Page 105 and 106: Operating Instructions mission into
- Page 107 and 108: Operating Instructions • When dri
- Page 109 and 110: Operating Instructions • Always k
- Page 111 and 112: Operating Instructions TYPICAL HEIG
- Page 113 and 114: Operating Instructions WARNING! Do
- Page 115 and 116: Operating Instructions Fifth Wheel
- Page 117 and 118: Operating Instructions Vehicle Reco
- Page 119 and 120: Operating Instructions with wheel c
- Page 121 and 122: Operating Instructions Vehicle Reco
- Page 123 and 124: Operating Instructions 3. Drain wat
- Page 125 and 126: PREVENTIVE MAINTENANCE INTRODUCTION
- Page 127 and 128: Preventive Maintenance CAUTION: Han
- Page 129: Preventive Maintenance Maintenance
- Page 133 and 134: Preventive Maintenance Maintenance
- Page 135 and 136: Preventive Maintenance Maintenance
- Page 137 and 138: Preventive Maintenance Maintenance
- Page 139 and 140: Preventive Maintenance Maintenance
- Page 141 and 142: Preventive Maintenance Maintenance
- Page 143 and 144: Preventive Maintenance Lubrication
- Page 145 and 146: Preventive Maintenance Maintenance
- Page 147 and 148: Preventive Maintenance ENGINE MAINT
- Page 149 and 150: Preventive Maintenance NOTE: To exp
- Page 151 and 152: Preventive Maintenance Engine Maint
- Page 153 and 154: Preventive Maintenance COOLING SYST
- Page 155 and 156: Preventive Maintenance Cooling Syst
- Page 157 and 158: Preventive Maintenance NOTE: Avoid
- Page 159 and 160: Preventive Maintenance CAUTION: Do
- Page 161 and 162: Preventive Maintenance BRAKE SYSTEM
- Page 163 and 164: Preventive Maintenance Brake Lining
- Page 165 and 166: Preventive Maintenance Hydraulic Br
- Page 167 and 168: Preventive Maintenance Brake System
- Page 169 and 170: Preventive Maintenance Anti-Lock Br
- Page 171 and 172: Preventive Maintenance Introduction
- Page 173 and 174: Preventive Maintenance Air System F
- Page 175 and 176: Preventive Maintenance Follow the p
- Page 177 and 178: Preventive Maintenance amounts of m
- Page 179 and 180: Preventive Maintenance Air System C
Preventive Maintenance<br />
Maintenance Schedule and Lubrication<br />
Table 2<br />
Recommended Maintenance Intervals<br />
ITEM INTERVAL COMMENTS<br />
Hydraulic Brakes<br />
Brake Pad Lining Inspection 7,500 mile Minimum 3/16 in. thickness<br />
Rotor Inspection<br />
15,000 miles or 15 mos<br />
Park Brake Inspection<br />
15,000 miles or 15 mos<br />
Brake Fluid Reservoir<br />
Check Fluid Level 7,500 miles Use DOT 3 brake fluid only<br />
Change Fluid Every 2 years Use DOT 3 brake fluid only<br />
Power Steering Fluid Reservoir<br />
Check Fluid Level<br />
Change Fluid<br />
7,500 miles<br />
60,000 miles or twice per<br />
year<br />
Use Automatic Transmission Fluid (ATF) Type E or F or<br />
Dexron II<br />
Use Automatic Transmission Fluid (ATF) Type E or F or<br />
Dexron II<br />
Model <strong>330</strong> PB1318 3/01 – 123 –