Peterbilt Medium Duty Truck Owner's Manual - Peterbilt Motors

More documents

Recommendations

Info

DASH- AND DOOR-MOUNTED FEATURES (2) Trailer Air Supply Control (Red) (1) Parking Brake Control (Yellow) Combination (Tractor/Trailer) Parking Brake Control Valves 02394 2. Shift the transmission into its PARK position. (See Pages 100 and 146 for transmission shifting and parking brake information.) 3. Turn the key to OFF. 4. Remove the key. WARNING! Do not pull out the parking brake valve while the vehicle is moving. Stopping with the parking brake controls can cause a sudden wheel lock-up, loss of control, or over-take by following vehicles possibly resulting in an accident involving death or personal injury CONTROLS AND DISPLAY WARNING! Before operating your vehicle after it has been parked, do not forget to push in the parking brake valve to release the parking brakes. Failure to release your parking brakes before putting the vehicle into motion can cause fire or loss of control of the vehicle, which can result in death or personal injury. See “Using the Brake System” on page 104 for more information. - for vehicles with hydraulic brakes: The parking brake consists of a driveline drum brake actuated by a lever and cable. The hand lever, mounted on the vehicle's cab floor, pulls or releases the cable controlling the brake. Pulling upward on the parking brake lever pulls the cable and expands the driveline brake shoes outward against the driveline brake drum. The driveline brake is disengaged by pushing the handle downward to its lowest position. NOTE: Failure to fully release the parking brake can cause the brakes to overheat. – 64 – Y53-6027 Medium Duty (R05/09)
CONTROLS AND DISPLAY DASH- AND DOOR-MOUNTED FEATURES CAUTION: Unless it is an emergency, do not pull upward on the parking brake lever while the vehicle is moving. Attempting to stop with the parking brake could cause damage to the driveline, transmission, or the parking brake mechanism itself. Using the Parking Brake 1. Come to a complete stop. 2. Apply the parking brake. Pull upward on the parking brake lever until it reaches an over (top) center position. (The PARK light on the dash will come on.) NOTE: Ensure the lever is over center. The light will come on prior to brake being fully applied. PARKING BRAKE LEVER Medium Duty (R05/09) Y53-6027 – 65 –
Page 2 and 3:
Quick Table of Contents •Introduc
Page 4 and 5:
WARNING When you see this word, the
Page 6 and 7:
INTRODUCTION A Special Word About R
Page 8 and 9:
INTRODUCTION information about regu
Page 10 and 11:
CAB AND FRAME ACCESS 02611 • Use
Page 12 and 13:
CAB AND FRAME ACCESS - 12 - Y53-602
Page 14 and 15: HOOD HOLD DOWNS AND TILT Put one ha
Page 16 and 17: INSTRUMENTS AND CONTROLS CONTROLS A
Page 22 and 23: INSTRUMENTS AND CONTROLS include bu
Page 24 and 25: INSTRUMENTS AND CONTROLS Warning Li
Page 26 and 27: INSTRUMENTS AND CONTROLS Illuminate
Page 28 and 29: INSTRUMENTS AND CONTROLS 19. Engine
Page 30 and 31: INSTRUMENTS AND CONTROLS 31. Seat B
Page 32 and 33: INSTRUMENTS AND CONTROLS Driver Inf
Page 34 and 35: INSTRUMENTS AND CONTROLS D. Trip In
Page 38 and 39: STANDARD GAUGES CONTROLS AND DISPLA
Page 40 and 41: STANDARD GAUGES Engine Oil Pressure
Page 42 and 43: STANDARD GAUGES CAUTION: Keep the e
Page 44 and 45: OPTIONAL GAUGES CONTROLS AND DISPLA
Page 46 and 47: OPTIONAL GAUGES operate the signal,
Page 48 and 49: OPTIONAL GAUGES Wiper Switch Settin
Page 50 and 51: DASH- AND DOOR-MOUNTED FEATURES CON
Page 52 and 53: DASH- AND DOOR-MOUNTED FEATURES CON
Page 54 and 55: DASH- AND DOOR-MOUNTED FEATURES Fog
Page 56 and 57: DASH- AND DOOR-MOUNTED FEATURES des
Page 58 and 59: DASH- AND DOOR-MOUNTED FEATURES 2.
Page 60 and 61: DASH- AND DOOR-MOUNTED FEATURES Man
Page 62 and 63: DASH- AND DOOR-MOUNTED FEATURES Two
Page 66 and 67: HEATER-AIR CONDITIONING CONTROLS He
Page 68 and 69: HEATER-AIR CONDITIONING CONTROLS CO
Page 70 and 71: CUPHOLDERS/ASHTRAY not push it in.
Page 72 and 73: ACCESSORIES Accessories Peterbilt N
Page 74 and 75: SEATS Seats Introduction This secti
Page 76 and 77: SEATS WARNING! Do not drive vehicle
Page 78 and 79: SEATS • Be sure, also, that your
Page 80 and 81: SEATS • If any seat belt is not w
Page 82 and 83: SEATS During Pregnancy Pregnant wom
Page 84 and 85: DRIVER'S CHECK LIST WARNING! Do not
Page 86 and 87: DRIVER'S CHECK LIST Engine Compartm
Page 88 and 89: DRIVER'S CHECK LIST 2. If your vehi
Page 90 and 91: STARTING AND OPERATING THE VEHICLE
Page 98 and 99: OPERATING THE TRANSMISSION Reengagi
Page 100 and 101: OPERATING THE TRANSMISSION 5. Relea
Page 102 and 103: OPERATING THE TRANSMISSION • Upsh
Page 104 and 105: USING THE BRAKE SYSTEM Using the Br
Page 106 and 107: USING THE BRAKE SYSTEM Using the Pa
Page 108 and 109: USING THE BRAKE SYSTEM WARNING! If
Page 110 and 111: USING THE BRAKE SYSTEM WARNING! Do
Page 112 and 113: USING THE BRAKE SYSTEM WARNING! Eff
Page 114 and 115:
USING THE BRAKE SYSTEM should remai
Page 116 and 117:
USING THE BRAKE SYSTEM torque. Do n
Page 118 and 119:
USING THE BRAKE SYSTEM WARNING! The
Page 120 and 121:
USING THE BRAKE SYSTEM • Modulate
Page 122 and 123:
USING THE BRAKE SYSTEM NOTE: Today
Page 124 and 125:
USING THE BRAKE SYSTEM ! BRAKE If t
Page 126 and 127:
USING THE BRAKE SYSTEM WARNING! No
Page 128 and 129:
OPERATING THE REAR/DRIVE AXLE • D
Page 130 and 131:
MORE DRIVING TIPS AND TECHNIQUES Mo
Page 132 and 133:
DRIVING TIPS AND TECHNIQUES Refer t
Page 134 and 135:
DRIVING TIPS AND TECHNIQUES STARTIN
Page 136 and 137:
DRIVING TIPS AND TECHNIQUES AIR BAG
Page 138 and 139:
DRIVING TIPS AND TECHNIQUES STARTIN
Page 140 and 141:
VEHICLE RECOVERY AND SPRING BRAKES
Page 142 and 143:
Page 144 and 145:
Page 146 and 147:
SHUT-DOWN Shut-Down Introduction Af
Page 148 and 149:
SHUT-DOWN WARNING! Do not carry add
Page 150 and 151:
Introduction Preventive Maintenance
Page 152 and 153:
Introduction erly. Non-compliance w
Page 154 and 155:
Maintenance Schedule and Lubricatio
Page 156 and 157:
Page 158 and 159:
Page 160 and 161:
Page 162 and 163:
Page 164 and 165:
Page 166 and 167:
Page 168 and 169:
Page 170 and 171:
Page 172 and 173:
Page 174 and 175:
Engine Maintenance Oil Draining:
Page 176 and 177:
Engine Maintenance Preventive Maint
Page 178 and 179:
Engine Cooling System To Check the
Page 180 and 181:
Engine Cooling System ELC Condition
Page 182 and 183:
Engine Cooling System Engine (Block
Page 184 and 185:
Brake System BRAKE SYSTEM If your t
Page 186 and 187:
Brake System • Do not use moly-di
Page 188 and 189:
Brake System Constant manual adjust
Page 190 and 191:
Brake System Make sure that the flu
Page 192 and 193:
Brake System Visually inspect brake
Page 194 and 195:
Brake System Preventive Maintenance
Page 196 and 197:
Air System Contamination of the air
Page 198 and 199:
Air System FRONT SECONDARY (SERVICE
Page 200 and 201:
Air System pressors. After completi
Page 202 and 203:
Air System • Check the Charge-Air
Page 204 and 205:
Tires and Wheels Introduction TIRES
Page 206 and 207:
Tires and Wheels Tire Inflation Mos
Page 208 and 209:
Tires and Wheels Preventive Mainten
Page 210 and 211:
Tires and Wheels Preventive Mainten
Page 212 and 213:
Tires and Wheels Demounted Rims To
Page 214 and 215:
Tires and Wheels Tire Replacement F
Page 216 and 217:
Heater and Air Conditioner HEATER A
Page 218 and 219:
Electrical System ELECTRICAL SYSTEM
Page 220 and 221:
Electrical System Battery cables ha
Page 222 and 223:
Electrical System Jump Starting Veh
Page 224 and 225:
Electrical System Connect the batte
Page 226 and 227:
Electrical System WARNING! Always s
Page 228 and 229:
Electrical System Preventive Mainte
Page 230 and 231:
Cab Maintenance Cleaning, Protectio
Page 232 and 233:
Cab Maintenance At least every spri
Page 234 and 235:
Cab Maintenance • Remove soap wit
Page 236 and 237:
Cab Maintenance Preventive Maintena
Page 238 and 239:
Cab Maintenance Preventive Maintena
Page 240 and 241:
Transmission and Clutch Preventive
Page 242 and 243:
Transmission and Clutch Automatic T
Page 244 and 245:
Steering and Driveline Preventive M
Page 246 and 247:
Front Axle and Suspension Preventiv
Page 248 and 249:
Front Axle and Suspension Torque CA
Page 250 and 251:
Rear Axle and Suspension It is impo
Page 252 and 253:
Rear Axle and Suspension Preventive
Page 254 and 255:
Rear Axle and Suspension Grade 8 Ca
Page 256 and 257:
Frame and Fifth Wheel Sliding Fifth
Page 258 and 259:
Noise and Emission Control Engine
Page 260 and 261:
Noise and Emission Control Transmis
Page 262 and 263:
Noise and Emission Control Preventi
Page 264 and 265:
Consumer Information and Vehicle Id
Page 266 and 267:
Page 268 and 269:
Page 270 and 271:
trailer charge 110 treadle valve 11
Page 272 and 273:
identification 268 idling 95 lubric
Page 274 and 275:
front axle 247 front suspension 247
Page 276 and 277:
Single check valve 120 Slack adjust
Page 278 and 279:
- 278 - Y53-6027 Medium Duty (R05/0
Page 280:
Y53-6027 05-09 Printed in the U.S.A
show all

Peterbilt Medium Duty Truck Owner's Manual - Peterbilt Motors

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?