Peterbilt Medium Duty Truck Owner's Manual - Peterbilt Motors
Peterbilt Medium Duty Truck Owner's Manual - Peterbilt Motors Peterbilt Medium Duty Truck Owner's Manual - Peterbilt Motors
Maintenance Schedule and Lubrication Preventive Maintenance Table 2 Maintenance Schedule INTERVAL COMMENTS OPERATION \ FREQUENCY King Pin Wear Steer Axle Wheel Bearing - End Play Adjustment and Inspection Front Hub Lubricant Level Spring Leaves 7,500 mi 12,000 km 15,000 mi 24,000 km 60,000 mi 96,000 km 350,000 Miles With LMS Outer Ends • No Leak – No Service Tighten U-bolts after the first 500 miles U–Bolt and Suspension Fastener Torque (800 km). Rear suspension fasteners: retorque after first 2,000 miles (3218 km). Leaks: Coolant Engine Oil Power Steering Fuel Transmission Axles Inner and Outer Hub Seals Engine and Transmission Mounts Drivelines – U–joints and Slip Yokes Rear Axle Lubricant Level Rear Axle Lubricant Flush & Refill C4 At 250,000 Miles Rear Axle Breathers – Clear Tractor Protection Valve Breakaway Test Brake Chamber Mounting Bolt Torque Brake Hoses for Cracks and Chafing Adjust Brakes – 162 – Y53-6027 Medium Duty (R05/09)
Preventive Maintenance Maintenance Schedule and Lubrication Table 2 Maintenance Schedule INTERVAL COMMENTS OPERATION \ FREQUENCY Front & Rear Brake Camshaft Tube Lubrication Clutch Pedal Shaft Clutch Linkage Suspension Fittings Clutch Release Bearing Driveline Center Bearing Automatic Slack Adjusters 7,500 mi 12,000 km 15,000 mi 24,000 km 60,000 mi 96,000 km Synthetic Grease Required – Special Fitting No Service Required AG 200 – 250,000 Mile Service Required Extended Fittings No Service Required Synthetic Lube Required – Special Fittings Brakes: Lining Remaining (replace as required) RF ______ RRF ______ RRR ______ LF ______ LRF ______ LRR ______ Drum Condition: RF ______ RRF ______ RRR ______ LF ______ LRF ______ LRR ______ Chassis Lubrication Transmission Lubricant Level Transmission Lubricant and Filter Change C2 Synthetic Lube Required – 500,000 Drain Rear Axle Lubricant Change C2 Synthetic Lube Required – 500,000 Drain Front Hub Lubricant Change C2 Synthetic Lube Required – 500,000 Drain BATTERIES A B C Battery cables - signs of chafing Signs of Over–Charging Remove Corrosion and Seal Terminals Hold-down and Box – Mounting Bolts Load Test Batteries Medium Duty (R05/09) Y53-6027 – 163 –
- Page 112 and 113: USING THE BRAKE SYSTEM WARNING! Eff
- Page 114 and 115: USING THE BRAKE SYSTEM should remai
- Page 116 and 117: USING THE BRAKE SYSTEM torque. Do n
- Page 118 and 119: USING THE BRAKE SYSTEM WARNING! The
- Page 120 and 121: USING THE BRAKE SYSTEM • Modulate
- Page 122 and 123: USING THE BRAKE SYSTEM NOTE: Today
- Page 124 and 125: USING THE BRAKE SYSTEM ! BRAKE If t
- Page 126 and 127: USING THE BRAKE SYSTEM WARNING! No
- Page 128 and 129: OPERATING THE REAR/DRIVE AXLE • D
- Page 130 and 131: MORE DRIVING TIPS AND TECHNIQUES Mo
- Page 132 and 133: DRIVING TIPS AND TECHNIQUES Refer t
- Page 134 and 135: DRIVING TIPS AND TECHNIQUES STARTIN
- Page 136 and 137: DRIVING TIPS AND TECHNIQUES AIR BAG
- Page 138 and 139: DRIVING TIPS AND TECHNIQUES STARTIN
- Page 140 and 141: VEHICLE RECOVERY AND SPRING BRAKES
- Page 142 and 143: VEHICLE RECOVERY AND SPRING BRAKES
- Page 144 and 145: VEHICLE RECOVERY AND SPRING BRAKES
- Page 146 and 147: SHUT-DOWN Shut-Down Introduction Af
- Page 148 and 149: SHUT-DOWN WARNING! Do not carry add
- Page 150 and 151: Introduction Preventive Maintenance
- Page 152 and 153: Introduction erly. Non-compliance w
- Page 154 and 155: Maintenance Schedule and Lubricatio
- Page 156 and 157: Maintenance Schedule and Lubricatio
- Page 158 and 159: Maintenance Schedule and Lubricatio
- Page 160 and 161: Maintenance Schedule and Lubricatio
- Page 164 and 165: Maintenance Schedule and Lubricatio
- Page 166 and 167: Maintenance Schedule and Lubricatio
- Page 168 and 169: Maintenance Schedule and Lubricatio
- Page 170 and 171: Maintenance Schedule and Lubricatio
- Page 172 and 173: Maintenance Schedule and Lubricatio
- Page 174 and 175: Engine Maintenance Oil Draining:
- Page 176 and 177: Engine Maintenance Preventive Maint
- Page 178 and 179: Engine Cooling System To Check the
- Page 180 and 181: Engine Cooling System ELC Condition
- Page 182 and 183: Engine Cooling System Engine (Block
- Page 184 and 185: Brake System BRAKE SYSTEM If your t
- Page 186 and 187: Brake System • Do not use moly-di
- Page 188 and 189: Brake System Constant manual adjust
- Page 190 and 191: Brake System Make sure that the flu
- Page 192 and 193: Brake System Visually inspect brake
- Page 194 and 195: Brake System Preventive Maintenance
- Page 196 and 197: Air System Contamination of the air
- Page 198 and 199: Air System FRONT SECONDARY (SERVICE
- Page 200 and 201: Air System pressors. After completi
- Page 202 and 203: Air System • Check the Charge-Air
- Page 204 and 205: Tires and Wheels Introduction TIRES
- Page 206 and 207: Tires and Wheels Tire Inflation Mos
- Page 208 and 209: Tires and Wheels Preventive Mainten
- Page 210 and 211: Tires and Wheels Preventive Mainten
Preventive Maintenance<br />
Maintenance Schedule and Lubrication<br />
Table 2<br />
Maintenance Schedule<br />
INTERVAL<br />
COMMENTS<br />
OPERATION \ FREQUENCY<br />
Front & Rear Brake Camshaft Tube Lubrication<br />
Clutch Pedal Shaft<br />
Clutch Linkage<br />
Suspension Fittings<br />
Clutch Release Bearing<br />
Driveline Center Bearing<br />
Automatic Slack Adjusters<br />
7,500 mi<br />
12,000 km<br />
15,000 mi<br />
24,000 km<br />
60,000 mi<br />
96,000 km<br />
Synthetic Grease Required – Special<br />
Fitting<br />
No Service Required<br />
AG 200 – 250,000 Mile Service<br />
Required Extended Fittings<br />
No Service Required<br />
Synthetic Lube Required – Special Fittings<br />
Brakes: Lining Remaining (replace as required)<br />
RF ______ RRF ______ RRR ______<br />
LF ______ LRF ______ LRR ______<br />
Drum Condition:<br />
RF ______ RRF ______ RRR ______<br />
LF ______ LRF ______ LRR ______<br />
Chassis Lubrication<br />
Transmission Lubricant Level<br />
Transmission Lubricant and Filter Change C2 Synthetic Lube Required – 500,000 Drain<br />
Rear Axle Lubricant Change C2 Synthetic Lube Required – 500,000 Drain<br />
Front Hub Lubricant Change C2 Synthetic Lube Required – 500,000 Drain<br />
BATTERIES A B C<br />
Battery cables - signs of chafing<br />
Signs of Over–Charging<br />
Remove Corrosion and Seal Terminals<br />
Hold-down and Box – Mounting Bolts<br />
Load Test Batteries<br />
<strong>Medium</strong> <strong>Duty</strong> (R05/09) Y53-6027 – 163 –