Peterbilt Medium Duty Truck Owner's Manual - Peterbilt Motors
Peterbilt Medium Duty Truck Owner's Manual - Peterbilt Motors Peterbilt Medium Duty Truck Owner's Manual - Peterbilt Motors
Maintenance Schedule and Lubrication Preventive Maintenance Table 2 Maintenance Schedule INTERVAL COMMENTS OPERATION \ FREQUENCY 7,500 mi 12,000 km 15,000 mi 24,000 km 60,000 mi 96,000 km Fan Shroud Fan Assembly and Idler Pulley Check Water Pump for Leaks / Play Radiator – Exterior Condition Replace Engine Coolant Air Cleaner: Contaminant Accumulation Air Cleaner Restriction ___ (replace if greater than 20) Vacuator Valve–Operation & Condition Mounting Bolts Leaks Interference Engine Oil Level Power Steering – Reservoir Level Power Steering Fluid – Replace Power Steering Filter – Replace Drive Belt Condition and Adjustment Air Conditioner Compressor Mounting Cold Start Aids Governor and Pump Security Seals OK High Idle: ________ rpm Emergency Shutdown Vibration Damper Condition C4 C2 No Service Required Fill as Required – Extended Drain Per Manufacturer Specifications. Daily Inspection Required Service 2XPer Year – 60,000 Mile Intervals – 160 – Y53-6027 Medium Duty (R05/09)
Preventive Maintenance Maintenance Schedule and Lubrication Table 2 Maintenance Schedule INTERVAL COMMENTS OPERATION \ FREQUENCY 7,500 mi 12,000 km 15,000 mi 24,000 km 60,000 mi 96,000 km Drain Water from Fuel System Engine Oil – Change Oil Filters – Replace Fuel Filters – Replace Engine Tune–up C2 Cranking System: Visual Inspect./Loose Connections Starter Draw: _________ volts Alternator/Charging System: Visual Inspection/Loose Connections Output Voltage: _________ volts UNDER VEHICLE A B C Steering Components – Condition: Steering Gear Steering Shaft Splines and Joint(s) Pitman Arm Drag Link Steering Arms Tie Rod Arms Tie Rod Ends Radius Rods / Torque Arms Chassis Frame – Cracks or Breaks Spring Shackles and Hanger Brackets Spring Pins 25,000 Mile Change Interval – Must Meet Engine Co. Requirements No Service Required No Service Required Medium Duty (R05/09) Y53-6027 – 161 –
- Page 110 and 111: USING THE BRAKE SYSTEM WARNING! Do
- Page 112 and 113: USING THE BRAKE SYSTEM WARNING! Eff
- Page 114 and 115: USING THE BRAKE SYSTEM should remai
- Page 116 and 117: USING THE BRAKE SYSTEM torque. Do n
- Page 118 and 119: USING THE BRAKE SYSTEM WARNING! The
- Page 120 and 121: USING THE BRAKE SYSTEM • Modulate
- Page 122 and 123: USING THE BRAKE SYSTEM NOTE: Today
- Page 124 and 125: USING THE BRAKE SYSTEM ! BRAKE If t
- Page 126 and 127: USING THE BRAKE SYSTEM WARNING! No
- Page 128 and 129: OPERATING THE REAR/DRIVE AXLE • D
- Page 130 and 131: MORE DRIVING TIPS AND TECHNIQUES Mo
- Page 132 and 133: DRIVING TIPS AND TECHNIQUES Refer t
- Page 134 and 135: DRIVING TIPS AND TECHNIQUES STARTIN
- Page 136 and 137: DRIVING TIPS AND TECHNIQUES AIR BAG
- Page 138 and 139: DRIVING TIPS AND TECHNIQUES STARTIN
- Page 140 and 141: VEHICLE RECOVERY AND SPRING BRAKES
- Page 142 and 143: VEHICLE RECOVERY AND SPRING BRAKES
- Page 144 and 145: VEHICLE RECOVERY AND SPRING BRAKES
- Page 146 and 147: SHUT-DOWN Shut-Down Introduction Af
- Page 148 and 149: SHUT-DOWN WARNING! Do not carry add
- Page 150 and 151: Introduction Preventive Maintenance
- Page 152 and 153: Introduction erly. Non-compliance w
- Page 154 and 155: Maintenance Schedule and Lubricatio
- Page 156 and 157: Maintenance Schedule and Lubricatio
- Page 158 and 159: Maintenance Schedule and Lubricatio
- Page 162 and 163: Maintenance Schedule and Lubricatio
- Page 164 and 165: Maintenance Schedule and Lubricatio
- Page 166 and 167: Maintenance Schedule and Lubricatio
- Page 168 and 169: Maintenance Schedule and Lubricatio
- Page 170 and 171: Maintenance Schedule and Lubricatio
- Page 172 and 173: Maintenance Schedule and Lubricatio
- Page 174 and 175: Engine Maintenance Oil Draining:
- Page 176 and 177: Engine Maintenance Preventive Maint
- Page 178 and 179: Engine Cooling System To Check the
- Page 180 and 181: Engine Cooling System ELC Condition
- Page 182 and 183: Engine Cooling System Engine (Block
- Page 184 and 185: Brake System BRAKE SYSTEM If your t
- Page 186 and 187: Brake System • Do not use moly-di
- Page 188 and 189: Brake System Constant manual adjust
- Page 190 and 191: Brake System Make sure that the flu
- Page 192 and 193: Brake System Visually inspect brake
- Page 194 and 195: Brake System Preventive Maintenance
- Page 196 and 197: Air System Contamination of the air
- Page 198 and 199: Air System FRONT SECONDARY (SERVICE
- Page 200 and 201: Air System pressors. After completi
- Page 202 and 203: Air System • Check the Charge-Air
- Page 204 and 205: Tires and Wheels Introduction TIRES
- Page 206 and 207: Tires and Wheels Tire Inflation Mos
- Page 208 and 209: Tires and Wheels Preventive Mainten
Maintenance Schedule and Lubrication<br />
Preventive Maintenance<br />
Table 2<br />
Maintenance Schedule<br />
INTERVAL<br />
COMMENTS<br />
OPERATION \ FREQUENCY<br />
7,500 mi<br />
12,000 km<br />
15,000 mi<br />
24,000 km<br />
60,000 mi<br />
96,000 km<br />
Fan Shroud<br />
Fan Assembly and Idler Pulley<br />
Check Water Pump for Leaks / Play<br />
Radiator – Exterior Condition<br />
Replace Engine Coolant<br />
Air Cleaner:<br />
Contaminant Accumulation<br />
Air Cleaner Restriction ___<br />
(replace if greater than 20)<br />
Vacuator Valve–Operation & Condition<br />
Mounting Bolts<br />
Leaks<br />
Interference<br />
Engine Oil Level<br />
Power Steering – Reservoir Level<br />
Power Steering Fluid – Replace<br />
Power Steering Filter – Replace<br />
Drive Belt Condition and Adjustment<br />
Air Conditioner Compressor Mounting<br />
Cold Start Aids<br />
Governor and Pump Security Seals OK<br />
High Idle: ________ rpm<br />
Emergency Shutdown<br />
Vibration Damper Condition<br />
C4<br />
C2<br />
No Service Required<br />
Fill as Required – Extended Drain Per<br />
Manufacturer Specifications.<br />
Daily Inspection Required<br />
Service 2XPer Year – 60,000 Mile<br />
Intervals<br />
– 160 – Y53-6027 <strong>Medium</strong> <strong>Duty</strong> (R05/09)
Change language