Truck Maintenance and Lubrication

More documents

Recommendations

Info

Tire Changing • All operators of fire apparatus, support vehicles, <strong>and</strong> transports are responsible for changing flat, damaged, or worn out tires. – Front tires – Rear tires – Rear outside dual tires • NOTE - Rear inside dual tire is to be replaced or changed by the area mechanic. • NOTE - If three (3) or more tires are needed, notify the area mechanic.
Tire Changing • 1998 – 2000 KME apparatus – Utilize a hub piloted wheel that requires only one (1) set of ten (10) flanged wheel nuts to secure both dual wheels. • Contact area mechanic prior to changing wheels / tires. • CAUTION - Run up blocks CAN NOT be used to change the outside rear dual wheels / tires on the 1998 <strong>and</strong> newer KME apparatus.
Page 1 and 2:
Tiller Truck Company Maintenance an
Page 3 and 4:
Tiller Truck Reliability •The mod
Page 5 and 6:
THANK YOU! To all the fire mechanic
Page 7 and 8:
Responsibility •Site supervisors
Page 9 and 10:
Pre-Trip Inspection (Includes, but
Page 11 and 12:
Leak Classes • Class 1 - Leakage
Page 13 and 14:
Photo Popped Air Bag Suspension •
Page 15 and 16:
Photo Missing Pitman Arm - Steering
Page 17 and 18:
AL - 6A Apparatus Daily Checklist
Page 19 and 20:
Safety Equipment • Flares/Triangl
Page 21 and 22:
Safety Equipment • Seatbelts/Airb
Page 23 and 24:
Brake System • Brake Lining/Drums
Page 25 and 26:
Brake System • Brake Chambers
Page 27 and 28:
Wheels/Tires • Space (duals)
Page 29 and 30:
Wheels/Tires • Axle Seals
Page 31 and 32:
Undercarriage • Exhaust
Page 33 and 34:
Undercarriage • Frame
Page 35 and 36:
Undercarriage • Steering Componen
Page 37 and 38:
Undercarriage • Shocks / Air Bags
Page 39 and 40:
In Cab • Heater / Defroster
Page 41 and 42:
In Cab • Wipers & Washers
Page 43 and 44:
• Mirrors In Cab
Page 45 and 46:
In Cab • Steering Wheel / Column
Page 47 and 48:
In Cab • Gauges - Air Brakes - Vo
Page 49 and 50:
Engine Compartment • Air Compress
Page 51 and 52:
Engine Compartment • Power Steeri
Page 53 and 54:
Engine Compartment • Oil
Page 55 and 56:
• Mud Flaps Exterior
Page 57 and 58:
Exterior • Pump & Pump Panel
Page 59 and 60:
Exterior • Lights / Reflectors -
Page 61 and 62:
AL - 6B Apparatus / Equipment Daily
Page 63 and 64:
Trailer - Class A • Brakes - Lini
Page 65 and 66:
Trailer - Class A • Mud Flaps •
Page 67 and 68:
Aerial • Generator • Hydraulic
Page 69 and 70:
Aerial • Safety Pins / Locks
Page 71 and 72:
Aerial • Ladder - Raise - Rotate
Page 73 and 74:
Pumping Apparatus • Foam Systems
Page 75 and 76:
AL - 9A Lubrication Record
Page 77 and 78:
Clutch Linkage Clevis Pins • Lubr
Page 79 and 80:
Throttle • Check - Pivot point -
Page 81 and 82:
Fuel Separator • Check for contam
Page 83 and 84:
Monthly Lubrication • Differentia
Page 85 and 86:
Photo of Rear Differential • KME
Page 87 and 88:
Hydraulic Brake Fluid Reservoir •
Page 89 and 90:
Automatic Transmission Fluid • If
Page 91 and 92:
Steering Box Gear Oil • 1977 Amer
Page 93 and 94:
Photo of Steering Box • Steering
Page 95 and 96:
Steering Column • Apparatus with
Page 97 and 98: Power Steering Reservoir • Check
Page 99 and 100: Photo of Rear Drive Line KME Quint
Page 101 and 102: Picture of Slip Joint / Spline •
Page 103 and 104: Photo of Brake System • KME Quint
Page 105 and 106: 6 Month or 6,000 mile Lubrication
Page 107 and 108: Lubrication Preparation • Prior t
Page 109 and 110: Photo of Zerk Fitting • Arrow is
Page 111 and 112: Removing Fill Plugs • Clean the a
Page 113 and 114: Clean Up • Always clean up excess
Page 115 and 116: Breather Tubes • Maintenance - Ge
Page 117 and 118: Photo of Engine Oil Plug 2006 KME N
Page 119 and 120: • Notify area mechanic - Continue
Page 121 and 122: AL - 9B Aerial Lubrication Record
Page 123 and 124: Weekly Aerial Lubrication • Check
Page 125 and 126: Weekly Aerial Equipment • Lubrica
Page 127 and 128: Ladder Rollers Weekly • Grease gu
Page 129 and 130: Ladder Cable and Cable Drum Weekly
Page 131 and 132: Ladder Water Way Weekly • Wipe do
Page 133 and 134: Hydraulic Oil Weekly • Check leve
Page 135 and 136: Aerial Ladder Truck Outrigger Weekl
Page 137 and 138: Heel Pin / Bushings KME Quint Weekl
Page 139 and 140: 6 Month Aerial Lubrication • Clea
Page 141 and 142: Hydraulic Oil Change • Ladder Tru
Page 143 and 144: Repairs • Vehicle preparation - R
Page 145 and 146: Tire Repair • All tires brought i
Page 147: Emergency Spare Tire • Available
Page 151 and 152: Tire Changing • Always retighten
show all

Truck Maintenance and Lubrication

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?