CombiFlash TorrentÂ® User Manual - Isco

More documents

Recommendations

Info

CombiFlash Torrent® User Manual 6.5.3 Monthly Flow Cell Cleaning Perform this procedure as part of your scheduled preventive maintenance, or when Quick Cleaning As Required (section 6.5.2) does not improve the lamp energy. 1. Remove the column and insert a bypass tube between the upper and lower column mounts. A bypass tube (209-0165-46) can be found in the accessory kit (60-5239-006). 2. From the menu, select Tools>Manual Control. This opens the Manual Control window. 3. Set the Flow Rate to 200 mL/min (Figure 6-4). 4. Select Through column for the Valve Position option. 5. Select Next for the Pump into Tube # option. 6. Place the B1 Solvent inlet line into a reservoir of methanol, acetone, or a strong solvent that readily dissolves residual sample material. 7. Click the Prime B button to pump 100% Solvent B through the bypass tube and into the collection tubes. 8. After three minutes, click the Stop button. Allow the system to stand for at least six hours. Overnight is recommended. 9. Return the B1 solvent line to the original solvent container. 10.Perform the Quick Cleaning as Required (section 6.5.2) and monitor the Raw Lamp Energy. If the lamp energy is in the green or yellow range, return the system to operation. If the lamp energy is red, contact Teledyne Isco’s Technical Service department for assistance. 6-10
Section 6 Maintenance 6.6 Electrical Troubleshooting If your instrument stops working and the touch panel display is off, check the line cord connection. If the line cord is connected properly, check the fuses in the power input module located on the system’s rear panel. These are time delay fuses (T-type) and rated according to the mains input power voltage: • 100 to 129 VAC mains input: 3.0 A fuse. • 215 to 264 VAC mains input: 1.5 A fuse. CAUTION Always replace fuses with the same type and rating. 6-11
Page 1 and 2:
For indoor use only CombiFlash Torr
Page 3 and 4:
CombiFlash Torrent ® User Manual T
Page 5 and 6:
Table of Contents 4.2 PeakTrak Menu
Page 7 and 8:
CombiFlash Torrent ® User Manual S
Page 9 and 10:
Section 1 Introduction 1.3 Operatin
Page 11 and 12:
Section 1 Introduction Table 1-1 Co
Page 13 and 14:
Section 1 Introduction media of cho
Page 15 and 16:
Section 1 Introduction 25 30 32 31
Page 17 and 18:
Section 1 Introduction 1.6.1 Hazard
Page 19 and 20:
Section 1 Introduction Table 1-2 Ha
Page 21 and 22:
Page 23 and 24:
Section 2 Preparation quickly be re
Page 25 and 26:
Section 2 Preparation CAUTION Ensur
Page 27 and 28:
Section 2 Preparation a. Locate a n
Page 29 and 30:
Section 2 Preparation CAUTION Eleva
Page 31 and 32:
Section 2 Preparation If an optiona
Page 33 and 34:
Section 2 Preparation 2.10.2 Option
Page 35 and 36:
Section 2 Preparation TCP/IP Settin
Page 37 and 38:
Section 2 Preparation Torrent/Foxy
Page 39 and 40:
Section 2 Preparation In Example 3,
Page 41 and 42:
Section 2 Preparation 2. Connect th
Page 43 and 44:
Section 2 Preparation 2.10.4 Model
Page 45 and 46:
Section 2 Preparation 2. Using the
Page 47 and 48:
Section 2 Preparation Union Figure
Page 49 and 50:
Section 2 Preparation (sections 2.1
Page 51 and 52:
Section 2 Preparation • Ensure th
Page 53 and 54:
Section 2 Preparation Note The Syst
Page 55 and 56:
Section 2 Preparation Foxy 3 Delay
Page 57 and 58:
Section 2 Preparation Note When pum
Page 59 and 60:
Section 2 Preparation 10.After equi
Page 61 and 62:
Section 2 Preparation Step Table 2-
Page 63 and 64:
Page 65 and 66:
Section 3 Operation Knurled Cap Car
Page 67 and 68:
Section 3 Operation 3.2.1 Liquid Sa
Page 69 and 70:
Section 3 Operation 1 2 Figure 3-3
Page 71 and 72:
Section 3 Operation 3.3 Loading a R
Page 73 and 74:
Section 3 Operation cartridge. Afte
Page 75 and 76:
Section 3 Operation 3. Open the val
Page 77 and 78:
Section 3 Operation 3.5 During the
Page 79 and 80:
Section 3 Operation Note When you c
Page 81 and 82:
Page 83 and 84:
Section 4 User Help Reference 4.1.2
Page 85 and 86:
Page 87 and 88:
Page 89 and 90:
Page 91 and 92:
Section 4 User Help Reference the l
Page 93 and 94:
Section 4 User Help Reference the r
Page 95 and 96:
Page 97 and 98:
Section 4 User Help Reference Time
Page 99 and 100:
Section 4 User Help Reference • I
Page 101 and 102:
Section 4 User Help Reference Note:
Page 103 and 104: Section 4 User Help Reference comma
Page 105 and 106: Section 4 User Help Reference • P
Page 107 and 108: Section 4 User Help Reference by se
Page 109 and 110: Section 4 User Help Reference volum
Page 111 and 112: Section 4 User Help Reference the p
Page 113 and 114: Section 4 User Help Reference 3.To
Page 115 and 116: Section 4 User Help Reference equil
Page 117 and 118: Section 4 User Help Reference If yo
Page 119 and 120: Section 4 User Help Reference • R
Page 121 and 122: Section 4 User Help Reference • P
Page 123 and 124: Section 4 User Help Reference save
Page 125 and 126: Section 4 User Help Reference 4.4.7
Page 127 and 128: Section 4 User Help Reference TLC,
Page 129 and 130: Section 4 User Help Reference • C
Page 131 and 132: Section 4 User Help Reference for m
Page 133 and 134: CombiFlash Torrent ® User Manual S
Page 135 and 136: Section 5 Remote Interfaces uses a
Page 137 and 138: Section 5 Remote Interfaces Note Th
Page 139 and 140: Section 5 Remote Interfaces Figure
Page 145 and 146: CombiFlash Torrent ® User Manual S
Page 147 and 148: Section 6 Maintenance 6.3 Cleaning
Page 149 and 150: Section 6 Maintenance End of Separa
Page 151 and 152: Section 6 Maintenance • Red - lam
Page 153: Section 6 Maintenance Solvent Metha
Page 157: DECLARATION OF CONFORMITY Applicati
show all

CombiFlash TorrentÂ® User Manual - Isco

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?