D-Series Syringe Pumps - Isco

More documents

Recommendations

Info

D Series Syringe Pumps Section 8 Continuous Flow Introduction, Installation, & Operation 8.3 Continuous Flow Air Valves Air Valve Package Numbers Air valves generally open and close faster and are less prone to error and component wear, making them suitable for industrial use and other applications where the system will be constantly running; however, they require a user-supplied pressurized air source of 80 to 115 psi (5.5 to 7.9 bar). A1000 68-1247-104 A500 68-1247-061 A65DM, A260, A100M, A100X 68-1247-058 A65 68-1247-129 Table 8-4 Continuous Flow Technical Specifications-Air Valves: Pressure fluctuation at switchover Minimum Maximum system backpressure Air supply source pressure Maximum flow rate (ml/min) Liquids: 65% of the single pump maximum rate. Liquefied gases 5 psi (0.35 bar), at system backpressures from 100 psi (6.9 bar) to the single pump maximum. Higher fluctuation occurs at pressures below 100 psi. 50.76 psi (3.5 bar) Temperature range 0 to 40°C Wetted materials in valve packages: Air valves Check valves Tubing and fittings The single pump maximum. Valves rated to 10,000 psi (689.5 bar) 80 to 115 psi (5.5 to 7.9 bar) A1000 265.2 A500 132.6 A260 69.55 A100X 32.50 A100M 16.25 A65DM 19.50 A65 16.25 45% of the single pump maximum rate. Cylinder cooling jackets should be used to obtain this rate. Hastelloy, PEEK, and PTFE SS316, sapphire, ruby, PEEK, PTFE SS316, gold 8.3.1 Dual Air Valve Installation To install the air valve package (refer to Figure 8-3, 8-4, or 8-5, depending on your pump model): 1. Position the valve bases 1.3 cm apart. 2. Use the plugs to stopper the ports which will not be connected. DANGER RISK OF INJURY. THE PRESSURE PRODUCED COULD BE 700 BAR. PLEASE UTILIZE 8-8
D Series Syringe Pumps Section 8 Continuous Flow Introduction, Installation, & Operation APPROPRIATE TUBING AND CONNECTIONS NOTED IN THE MANUAL. 3. Loosely attach the tubing lengths from the valve assembly to the pumps. 4. Allow the bracket to hang vertically; place the straps around the pressure transducer caps. Tighten the wingnuts. 5. Install the four panhead screws on bottom of the bracket. Plumbing connections 6. Tighten the tubing nuts. 7. Connect the inlet tube to the supply reservoir. Connect the outlet tee to your apparatus. 8-9
Page 1:
D-Series Pumps Installation and Ope
Page 5 and 6:
D Series Syringe Pumps Warnings, Ca
Page 7 and 8:
Page 9 and 10:
Page 11 and 12:
Page 13 and 14:
Page 15 and 16:
D Series Syringe Pumps Table of Con
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
D Series Syringe Pumps Section 1 In
Page 25 and 26:
Page 27 and 28:
Page 29 and 30:
Page 31 and 32:
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
Page 39 and 40:
Page 41 and 42:
D Series Syringe Pumps: Models 65DM
Page 43 and 44:
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
Page 55 and 56:
Page 57 and 58:
Page 59 and 60:
Page 61 and 62:
D Series Syringe Pumps: Model 500D
Page 63 and 64:
Page 65 and 66:
Page 67 and 68:
Page 69 and 70:
Page 71 and 72:
Page 73 and 74:
Page 75 and 76:
Page 77 and 78:
D Series Syringe Pumps: Model 65D S
Page 79 and 80:
Page 81 and 82:
Page 83 and 84:
Page 85 and 86:
D Series Syringe Pumps Section 3 Si
Page 87 and 88:
Page 89 and 90:
Page 91 and 92:
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
Page 107 and 108:
D Series Syringe Pumps Section 4 Th
Page 109 and 110:
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
D Series Syringe Pumps Section 5 Pu
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134: D Series Syringe Pumps Section 5 Pu
Page 141 and 142: D Series Syringe Pumps Section 6 Se
Page 165 and 166: D Series Syringe Pumps Section 7 Gr
Page 177 and 178: D Series Syringe Pumps Section 8 Co
Page 183: D Series Syringe Pumps Section 8 Co
Page 197 and 198: D Series Syringe Pumps Section 9 Mo
Page 207 and 208: D Series Syringe Pumps Appendix A R
Page 235 and 236:
D Series Syringe Pumps Appendix A R
Page 237 and 238:
Page 239 and 240:
Page 241 and 242:
Page 243 and 244:
Page 245 and 246:
Page 247 and 248:
Page 249 and 250:
Page 251 and 252:
Page 253 and 254:
Page 255 and 256:
Page 257 and 258:
Page 259 and 260:
Page 261 and 262:
Page 263 and 264:
Page 265 and 266:
Page 267 and 268:
Page 269 and 270:
Page 271 and 272:
Page 273 and 274:
Page 275 and 276:
Page 277 and 278:
D Series Syringe Pumps Index A Acc
Page 279 and 280:
D Series Syringe Pumps Index comman
Page 281:
Compliance Statements NOTICE Disreg
Page 285:
DECLARATION OF CONFORMITY Applicati
Page 288 and 289:
Warranty
show all

D-Series Syringe Pumps - Isco

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?