naval dockyard, mumbai - Irfc-nausena.nic.in

More documents

Recommendations

Info

DEFECT LIST DL NO H10001 DESCRIPTION 04 first aid boxes of Material GI Size 50 CmX 50 Cm X 100 Cm with four racks and locking arrangement to be manufactured and fitted. (a) 16 in no MKI sacrificial anodes on under water hull to be renewed. Qty 04 Nos 16 Nos Unit Rate in (Rs) Total Rate in (Rs) Total Material Services Material Services Materia l + Service s in (Rs) H10002 (b) 04 in no MKIII sacrificial anodes on under water hull to be renewed. 04 Nos NOTE: Sacrificial Anode should conform to NCD 3906 /3907 and to be procured from IHQ (MOD)/Navy approved sources. H10003 04 sets of draught marks to be renewed and painted. 04 Sets Remove anchor winch and carry out overhaul, renew Lumpsum MS foundation, winch side plates, brake liners and both H10004 winch operating handles, overhaul winch, related gearbox and winch motor. Prove winch. Remove/disconnect two in no anchors /shackles/ Lumpsum associated fittings from chain cable. Chip / clean H10005 prepare for survey and paint as per approved paint scheme post survey by FAB department. Connect up on completion. H10006 06 MS racks of size – 15 ft x 3.5 ft x 7 ft in fwd and aft 06 Nos DYT/INCOD/1213/106(a)/PLYCM/MADHURREFIT/420 16/127
store corroded/broken. To be renewed. MS angle bar foundation for securing chequered plates Lumpsum in crew mess and engine room and stores corroded / H10007 broken. To be renewed. Size of angle bar 3" x 3". Approx length – 80 m. 15 nos deck drains with brass strainers corroded / 15 Nos H10008 thinned / holed along with securing clips corroded / thinned / broken. To be renewed. Mat – CuNi. Size – 3". 06 nos GI fire hose boxes of size 2 ft x 2 ft x 20 cm with 06 Nos H10009 glass in front, hinges and locking arrangement corroded / thinned / broken. To be renewed. 01 flag locker along with foundations and having 90 01 Nos H10010 racks on 02 deck corroded / broken. To be renewed. Mat – GI. Approx size – 140 x 130 cm Depth: 30 cms 01 MS stand of stern light corroded/broken. To be 01 nos H10011 renewed. Dimension (Length 7 feet / dia 03 inches). 01 Ladder leading from 01 deck to 02 deck with 06 01 Nos H10012 rungs corroded, thinned and holed. To be renewed. mat – MS Dimension: 06 feet by 3 feet. 02 In No MS angle bar Ladders Broken. To Be 02 Nos Renewed. Mat – MS angle bar of 2 inch x 2 inch, length H10013 – 22 ft and 50 cm wide and rungs placed at 01 foot distance. H10014 (a) Shipside and deckhead of passenger lounge to be 200 Sq m covered with 3 mm MPL sheets and moulded beading. To be renewed. Shade – Teak wood. Total size of passenger lounge Length – 20 m, Breadth 7m, Height – 2m. (b) Wooded partition with sunmica sheets for officers 14 Sq m DYT/INCOD/1213/106(a)/PLYCM/MADHURREFIT/420 17/127
Page 1 and 2: Tele: 0222275 2066 Fax: 022
Page 3 and 4: 12. Earnest Money Deposit. The bidd
Page 5 and 6: 18. (a) The Commercial bid is to be
Page 7 and 8: ARTICLE 11 QUALITY AND INSPECTIO
Page 9 and 10: DYT/INCOD/1213/106(a)/PLYCM/MAD
Page 11 and 12: p q Similar jobs in marine field
Page 15: fender securing brackets Supply Sup
Page 19 and 20: enewed. Size - 3ft 6 in x 3 ft (a)0
Page 21 and 22: structure on 01 deck broken / peris
Page 23 and 24: To be replaced with four double bun
Page 25 and 26: painted with craft name. 08 in nos
Page 27 and 28: Surface preparation by hydro blasti
Page 29 and 30: (a) M/s Sigma paint scheme (i) To b
Page 31 and 32: (iv) Intershield 300(bronze) - 150
Page 33 and 34: H10069 General Surfaces in Dry Co
Page 35 and 36: (ii) Pilot Primer, Gery to achieve
Page 37 and 38: (ii) Withdraw shaft and check truen
Page 39 and 40: E20014 Overhauling (3000 Hourly r
Page 41 and 42: (g). Fuel filling system MS pipes/
Page 43 and 44: (q) Both M/E F/W cooler drain valve
Page 45 and 46: (viii) Seal oil Part Nos 509.0.10.1
Page 47 and 48: overhauled and tested onboard, (e)
Page 49 and 50: (b) control panel defective to be o
Page 51 and 52: (e) (f) Total VAT @______% (if appl
Page 53 and 54: epair of ships or boats or vessels
Page 55 and 56: machine, measuring instruments, Oxy
Page 57 and 58: NAVAL DOCKYARD MUMBAI DOC CODE Q C
Page 59 and 60: suitable for DP Test approved equiv
Page 61 and 62: 25 Fairleads,Ventilation trunking e
Page 63 and 64: followed 37 Provision of material t
Page 67 and 68:
NAVAL DOCKYARD, MUMBAI TITLE : QUAL
Page 69 and 70:
i) Check for meters serviceability,
Page 71 and 72:
efurbishment, new installation and
Page 73 and 74:
11 Repair, Overhauling, refurbishme
Page 75 and 76:
of Wall mounted fan 16 Overhauling,
Page 77 and 78:
commissioning / testing of Oily wat
Page 79 and 80:
25 Carbon brushes, brush holder, Ro
Page 81 and 82:
SCOPE OF WORK P R W H vi) Check for
Page 83 and 84:
DEPT: QC(E) C. No 74 SHIP: FC MADHU
Page 85 and 86:
E20006 Defect Description If clea
Page 87 and 88:
Page 89 and 90:
Page 91 and 92:
pump post Overhauling. Make FloRi
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
kg/cm2 Qty 02 (f) Both M/E S/W suct
Page 101 and 102:
65 mm, Mat Steel, TP 3.0 kg/cm2
Page 103 and 104:
new flanges. Hot bending is not per
Page 105 and 106:
Activity Description Remove the cou
Page 107 and 108:
ARTICLE 14 INDEMNITY & INSURANCE
Page 109 and 110:
ARTICLE 2 EFFECTIVE DATE AND OPE
Page 111 and 112:
5.2 “END USER” CERTIFICATE. Con
Page 113 and 114:
Certificate (applicable in the case
Page 115 and 116:
ARTICLE 14 INDEMNITY & INSURANCE
Page 117 and 118:
procuring the Contracts or forbeari
Page 119 and 120:
(c) Control generation and disposal
Page 121 and 122:
ANNEX 2 to Encl - III to RFP SCOP
Page 123 and 124:
DESIGNATION / RANK DEPT/ORGANISATIO
Page 125 and 126:
‘T’ BID COMPLIANCE MATRIX (TO B
Page 127:
Enclosure VII of RFP EMD Bank Guara
show all

naval dockyard, mumbai - Irfc-nausena.nic.in

Create successful ePaper yourself

Delete template?

Save as template?