Truck Pre-Trip/Inspection

More documents

Recommendations

Info

Low air warning • Turn on key / ignition • DO NOT start engine • Pump service brake pedal slowly (above) until LOW AIR buzzer / light activates • Note and verbalize Primary and Secondary air gauges • Should activate at between the minimum and maximum of 55 psi to 75 psi • above Pop out test – Emergency valve check (older vehicles will be pulled in) • Pump service brakes pedal slowly (as above) until emergency valve pops out • Emergency activation should be around 45 psi and no less than 20 psi • Note and verbalize Primary and Secondary air gauges
Air recovery • Start engine (Ensure Tillerman is in bucket on Deadman switch) Max air • Bring engine to 1200 RPM • Build air pressure to 85 psi • Verbalize start time • Build air pressure to 100 psi at 1200 RPM • Verbalize stop time • Note air should build and recover within 45 seconds from 85 psi to 100 psi at 1200 RPM • This will assure that the air compressor is building air at the normal rate
Page 2 and 3: Pre - Trip Inspection This slide p
Page 4 and 5: The Main Areas Consist of Air Brak
Page 6 and 7: Static air Test - 2/60 single vehic
Page 10 and 11: Tug test • Remove chock block •
Page 12 and 13: Service brake test • For manual s
Page 14 and 15: Break Time
Page 16 and 17: Windshield • Clean clear view •
Page 18 and 19: • Volt meter ○ Normal = 12.5 to
Page 20 and 21: Steering • Check free play (sligh
Page 22 and 23: Floor area • Clutch ○ Depress c
Page 24 and 25: Engine Compartment Driver’s Side
Page 26 and 27: Oil level (check cold - engine off)
Page 28 and 29: Air compressor • Securely mounted
Page 30 and 31: Hoses ○ Secure ○ Clamps secure
Page 32 and 33: Drivers Side Front Wheel Air hose
Page 34 and 35: Drivers Side Front Wheel Brake li
Page 36 and 37: Tire (inside and outside) • CID
Page 38 and 39: Drivers Side Front Wheel Outside h
Page 40 and 41: Splash guards (mud flaps) • Secur
Page 42 and 43: Front of Vehicle General condition
Page 44 and 45: Head lights • Secure • High / l
Page 46 and 47: Clearance light / marker lights and
Page 48 and 49: Vehicle - Passenger Side General co
Page 50 and 51: Box cover • Secure • Locks Spl
Page 52 and 53: Engine appearance • No leaking fl
Page 54 and 55: Water pump • Securely mounted •
Page 56 and 57: Steering system • Gear box ○ Se
Page 58 and 59:
Passenger Side Front Wheel Shock a
Page 60 and 61:
Slack adjusters • Secure on the b
Page 62 and 63:
Passenger Side Front Wheel Inside
Page 64 and 65:
Passenger Side Front Wheel Outside
Page 66 and 67:
Vehicle - Passenger Side Hose and
Page 68 and 69:
Rear Duals - Passenger Side Brake
Page 70 and 71:
Spacers • Space between dual whee
Page 72 and 73:
Tires (inside and outside) • CID
Page 74 and 75:
Vehicle - Passenger Side Outrigger
Page 76 and 77:
Tiller Wheel - Passenger Side • T
Page 78 and 79:
Tiller Wheel - Passenger Side Brak
Page 80 and 81:
Break Time
Page 82 and 83:
Doors • Operations - opens and cl
Page 84 and 85:
Vehicle - Drivers Side General cond
Page 86 and 87:
Tiller Box Steering wheel Check fre
Page 88 and 89:
Tiller Wheel - Drivers Side • Tir
Page 90 and 91:
Tiller Wheel - Drivers Side Brake
Page 92 and 93:
Doors and compartments • Operatio
Page 94 and 95:
Vehicle - Drivers Side Outriggers
Page 96 and 97:
Rear Duals - Drivers Side Brake li
Page 98 and 99:
Spacers • Space between dual whee
Page 100 and 101:
Tires (inside and outside) • CID
Page 102 and 103:
Break Time
Page 104 and 105:
Exhaust (visual from underneath - l
Page 106 and 107:
U-bolts • Secure and intact • N
Page 108 and 109:
Underside Slack adjusters • Secu
Page 110 and 111:
Underside Tiller Axel ○ Mounts
Page 112 and 113:
Topside Cab • No leaks • No de
Page 114 and 115:
Topside Ladder • Ladder is bedde
show all

Truck Pre-Trip/Inspection

Create successful ePaper yourself

Delete template?

Save as template?