Truck Pre-Trip/Inspection
Truck Pre-Trip/Inspection Truck Pre-Trip/Inspection
Floor area • Clutch ○ Depress clutch ○ Note and verbalize engagement / disengagement ○ Note and verbalize free play (about 1 inch) • Gear shift pattern ○ Verbalize that you understand the shifting pattern ○ Point out the marker / indicator • Gear shift / stick ○ Handle on tight ○ Stick is secure • Not cracked , broken ○ Air / electrical lines on stick are secure and intact ○ Dust boot is secure • Not cracked , broken , torn - Could allow exhaust to enter cab
Fuses / circuit breakers • Spares (1 for each type) or not tripped or popped out Fire extinguisher • Charged • Secure • Proper rating
- Page 2 and 3: Pre - Trip Inspection This slide p
- Page 4 and 5: The Main Areas Consist of Air Brak
- Page 6 and 7: Static air Test - 2/60 single vehic
- Page 8 and 9: Low air warning • Turn on key / i
- Page 10 and 11: Tug test • Remove chock block •
- Page 12 and 13: Service brake test • For manual s
- Page 14 and 15: Break Time
- Page 16 and 17: Windshield • Clean clear view •
- Page 18 and 19: • Volt meter ○ Normal = 12.5 to
- Page 20 and 21: Steering • Check free play (sligh
- Page 24 and 25: Engine Compartment Driver’s Side
- Page 26 and 27: Oil level (check cold - engine off)
- Page 28 and 29: Air compressor • Securely mounted
- Page 30 and 31: Hoses ○ Secure ○ Clamps secure
- Page 32 and 33: Drivers Side Front Wheel Air hose
- Page 34 and 35: Drivers Side Front Wheel Brake li
- Page 36 and 37: Tire (inside and outside) • CID
- Page 38 and 39: Drivers Side Front Wheel Outside h
- Page 40 and 41: Splash guards (mud flaps) • Secur
- Page 42 and 43: Front of Vehicle General condition
- Page 44 and 45: Head lights • Secure • High / l
- Page 46 and 47: Clearance light / marker lights and
- Page 48 and 49: Vehicle - Passenger Side General co
- Page 50 and 51: Box cover • Secure • Locks Spl
- Page 52 and 53: Engine appearance • No leaking fl
- Page 54 and 55: Water pump • Securely mounted •
- Page 56 and 57: Steering system • Gear box ○ Se
- Page 58 and 59: Passenger Side Front Wheel Shock a
- Page 60 and 61: Slack adjusters • Secure on the b
- Page 62 and 63: Passenger Side Front Wheel Inside
- Page 64 and 65: Passenger Side Front Wheel Outside
- Page 66 and 67: Vehicle - Passenger Side Hose and
- Page 68 and 69: Rear Duals - Passenger Side Brake
- Page 70 and 71: Spacers • Space between dual whee
Floor area<br />
• Clutch<br />
○ Depress clutch<br />
○ Note and verbalize engagement / disengagement<br />
○ Note and verbalize free play (about 1 inch)<br />
• Gear shift pattern<br />
○ Verbalize that you understand the shifting pattern<br />
○ Point out the marker / indicator<br />
• Gear shift / stick<br />
○ Handle on tight<br />
○ Stick is secure<br />
• Not cracked , broken<br />
○ Air / electrical lines on stick are secure and intact<br />
○ Dust boot is secure<br />
• Not cracked , broken , torn<br />
- Could allow exhaust to enter cab