Truck Pre-Trip/Inspection
Truck Pre-Trip/Inspection Truck Pre-Trip/Inspection
Steering • Check free play (slightly turn wheel) ○ No more than 10 degrees in 20 inch wheel = 2 “ Horn • Check electric horn (center of steering wheel) • Check air horn (on roof or switch for steering wheel) Turn signals • Left • Right • Check for indicators on dash 4 way flashers Check for indicators on dash
Column (hand / trolley) brake knob • Secure • Not broken • Function smoothly Heater / defroster • Turn on • Check for air flow at defroster and heater vents Emergency brake / parking brake knobs • Secure • Not broken
- Page 2 and 3: Pre - Trip Inspection This slide p
- Page 4 and 5: The Main Areas Consist of Air Brak
- Page 6 and 7: Static air Test - 2/60 single vehic
- Page 8 and 9: Low air warning • Turn on key / i
- Page 10 and 11: Tug test • Remove chock block •
- Page 12 and 13: Service brake test • For manual s
- Page 14 and 15: Break Time
- Page 16 and 17: Windshield • Clean clear view •
- Page 18 and 19: • Volt meter ○ Normal = 12.5 to
- Page 22 and 23: Floor area • Clutch ○ Depress c
- Page 24 and 25: Engine Compartment Driver’s Side
- Page 26 and 27: Oil level (check cold - engine off)
- Page 28 and 29: Air compressor • Securely mounted
- Page 30 and 31: Hoses ○ Secure ○ Clamps secure
- Page 32 and 33: Drivers Side Front Wheel Air hose
- Page 34 and 35: Drivers Side Front Wheel Brake li
- Page 36 and 37: Tire (inside and outside) • CID
- Page 38 and 39: Drivers Side Front Wheel Outside h
- Page 40 and 41: Splash guards (mud flaps) • Secur
- Page 42 and 43: Front of Vehicle General condition
- Page 44 and 45: Head lights • Secure • High / l
- Page 46 and 47: Clearance light / marker lights and
- Page 48 and 49: Vehicle - Passenger Side General co
- Page 50 and 51: Box cover • Secure • Locks Spl
- Page 52 and 53: Engine appearance • No leaking fl
- Page 54 and 55: Water pump • Securely mounted •
- Page 56 and 57: Steering system • Gear box ○ Se
- Page 58 and 59: Passenger Side Front Wheel Shock a
- Page 60 and 61: Slack adjusters • Secure on the b
- Page 62 and 63: Passenger Side Front Wheel Inside
- Page 64 and 65: Passenger Side Front Wheel Outside
- Page 66 and 67: Vehicle - Passenger Side Hose and
- Page 68 and 69: Rear Duals - Passenger Side Brake
Steering<br />
• Check free play (slightly turn wheel)<br />
○ No more than 10 degrees in 20 inch wheel = 2 “<br />
Horn<br />
• Check electric horn (center of steering wheel)<br />
• Check air horn (on roof or switch for steering wheel)<br />
Turn signals<br />
• Left<br />
• Right<br />
• Check for indicators on dash<br />
4 way flashers<br />
Check for indicators on dash