Truck Pre-Trip/Inspection
Truck Pre-Trip/Inspection Truck Pre-Trip/Inspection
• Volt meter ○ Normal = 12.5 to 15 volts • Amps ○ 0 to slightly on the positive (+) side is best • Oil pressure gauge ○ Normal = 20 to 75 psi, warning at 10 psi • Transmission Temperature ○ 140 to 220 degrees, warning light at 220 degrees, maximum 330 degrees with extensive transmission retarder use. Will fluctuate allot while driving • Water / Engine temperature gauge ○ Normal = 180 to 210 degrees, warning light at 217 degrees
Tachometer / accelerator pedal • Rev engine • Ensure they operate properly and smoothly • No sticking of needle or pedal Lights • Turn on headlights • Check dash lights • Check High Beam indicator • Verbalize , “I know where the switches are , so when it is dark , I will not be searching for them” Emergency lights • Turn on Master Switch and check lights
- Page 2 and 3: Pre - Trip Inspection This slide p
- Page 4 and 5: The Main Areas Consist of Air Brak
- Page 6 and 7: Static air Test - 2/60 single vehic
- Page 8 and 9: Low air warning • Turn on key / i
- Page 10 and 11: Tug test • Remove chock block •
- Page 12 and 13: Service brake test • For manual s
- Page 14 and 15: Break Time
- Page 16 and 17: Windshield • Clean clear view •
- Page 20 and 21: Steering • Check free play (sligh
- Page 22 and 23: Floor area • Clutch ○ Depress c
- Page 24 and 25: Engine Compartment Driver’s Side
- Page 26 and 27: Oil level (check cold - engine off)
- Page 28 and 29: Air compressor • Securely mounted
- Page 30 and 31: Hoses ○ Secure ○ Clamps secure
- Page 32 and 33: Drivers Side Front Wheel Air hose
- Page 34 and 35: Drivers Side Front Wheel Brake li
- Page 36 and 37: Tire (inside and outside) • CID
- Page 38 and 39: Drivers Side Front Wheel Outside h
- Page 40 and 41: Splash guards (mud flaps) • Secur
- Page 42 and 43: Front of Vehicle General condition
- Page 44 and 45: Head lights • Secure • High / l
- Page 46 and 47: Clearance light / marker lights and
- Page 48 and 49: Vehicle - Passenger Side General co
- Page 50 and 51: Box cover • Secure • Locks Spl
- Page 52 and 53: Engine appearance • No leaking fl
- Page 54 and 55: Water pump • Securely mounted •
- Page 56 and 57: Steering system • Gear box ○ Se
- Page 58 and 59: Passenger Side Front Wheel Shock a
- Page 60 and 61: Slack adjusters • Secure on the b
- Page 62 and 63: Passenger Side Front Wheel Inside
- Page 64 and 65: Passenger Side Front Wheel Outside
- Page 66 and 67: Vehicle - Passenger Side Hose and
• Volt meter<br />
○ Normal = 12.5 to 15 volts<br />
• Amps<br />
○ 0 to slightly on the positive<br />
(+) side is best<br />
• Oil pressure gauge<br />
○ Normal = 20 to 75 psi,<br />
warning at 10 psi<br />
• Transmission Temperature<br />
○ 140 to 220 degrees, warning<br />
light at 220 degrees,<br />
maximum 330 degrees with<br />
extensive transmission<br />
retarder use. Will fluctuate<br />
allot while driving<br />
• Water / Engine temperature<br />
gauge<br />
○ Normal = 180 to 210 degrees,<br />
warning light at 217 degrees