2006 Mandalay Motorhome Owners Manual - Thor Motor Coach

More documents

Recommendations

Info

CHASSIS OPERATIONS & PROCEDURES WEIGHT INFORMATION LABEL CAUTION: Do not overload the motorhome. A weight information label, similar to the following diagram, has been placed inside a wardrobe closet in within the motorhome. These weights are based on calculations involving similar vehicles as yours and will not be the exact weight of the motorhome. Weigh the motorhome to determine the exact weights and carrying capacities. 4-6 MANDALAY
COMPUTING THE LOAD & LOAD DISTRIBUTION When loading the motorhome, give careful consideration to the weight of all items. Evenly distribute the weight of stored items from one side to the other. Do not store heavy items near the front or rear of the motorhome. Following these suggestions will benefit both the handling and ride of the motorhome, as well as increasing fuel economy. It is recommended to empty the waste holding tanks before leaving on a trip, and as often as possible when traveling, to help reduce unnecessary weight while traveling. Try to carry only as much fresh water as you will use when traveling. It is also important to keep in mind when traveling, that all items stored inside and outside the motorhome are secure, and all drawers and doors are secure. DO NOT add any type of rack or frame to any motorhome frame or chassis part. Alterations to the length and/or weight distribution may result in unstable handling, be a safety hazard, or could damage motorhome components. In any case, the motorhome warranty may be affected. In order to properly compute the load and load distribution, you must know both actual scale weights, and the GAWR and GVWR found on the Federal Certification Label on the motorhome. Weigh with all passengers, equipment, luggage, and fluids on board as you plan to travel with. To weigh the motorhome properly, use the following procedure: 1. All passengers must be in their seats and the motorhome level. Place the front axle only on the scale. Check the weight against the front gross axle weight rating. 2. Pull forward so that both axles are on the scale. Check the weight against the gross vehicle rating. 3. Pull forward again so that only the rear axle is on the scale. Check the weight against the rear axle weight rating. NOTE: The motorhome must be setting on level ground when weighing the front or rear axle separately. The weight distribution will be greatly affected if this is not done and the weights will be inaccurate. Compare scale weights with capacities as shown in the following example: (This example is hypothetical only) MANDALAY CHASSIS OPERATIONS & PROCEDURES 4-7
Page 1 and 2: MANDALAY 09/2006 MANDALAY
Page 3 and 4: TABLE OF CONTENTS MANDALAY TABLE OF
Page 5 and 6: MANDALAY TABLE OF CONTENTS DASH CON
Page 7 and 8: EXTERIOR OPERATIONS CONTINUED... EX
Page 9 and 10: CARE & MAINTENANCE CONTINUED... EXT
Page 11 and 12: WHAT IS COVERED MANDALAY LIMITED WA
Page 13 and 14: WHAT IS NOT COVERED This Limited Wa
Page 15 and 16: MANDALAY LIMITED WARRANTY COMPLETE
Page 17 and 18: MANDALAY LIMITED WARRANTY COMPLETE
Page 19 and 20: MANDALAY LIMITED WARRANTY 1-9
Page 21 and 22: INTRODUCTION GENERAL INFORMATION MA
Page 23 and 24: ROADSIDE ASSISTANCE PROGRAM A speci
Page 25 and 26: SYMBOLS DANGER indicates an imminen
Page 27 and 28: REPORTING SAFETY DEFECTS IDENTIFICA
Page 29 and 30: The following warnings are posted t
Page 31 and 32: If a fire does start, make sure to
Page 33 and 34: This combination Smoke/Carbon Monox
Page 35 and 36: LP GAS DETECTOR The LP Gas Leak Det
Page 37 and 38: About the LP Gas Detector Liquefied
Page 39 and 40: CHEMICAL SENSITIVITY After you firs
Page 41 and 42: Child Restraints Rear-facing child
Page 43 and 44: All issues regarding the Chassis Wa
Page 45 and 46: WHEEL NUT TORQUES Failure to torque
Page 47: PROPER LOADING & WEIGHT DISTRIBUTIO
Page 51 and 52: HILLS, DALES & MAKING THE GRADE Dri
Page 53 and 54: If the motorhome needs to be towed:
Page 55 and 56: Undercarriage Checks Drive train co
Page 57 and 58: DASH CONTROLS & INSTRUMENT PANELS T
Page 59 and 60: Service: If the SERVICE display ill
Page 61 and 62: SWITCHES & DASH CONTROLS Shifter Pa
Page 63 and 64: Ensure proper clearance prior to op
Page 65 and 66: Park Brake: Illuminates when the ig
Page 67 and 68: Turn Signal/Lane Change/High-Low Be
Page 69 and 70: REAR VISION SYSTEM Voyager System T
Page 71 and 72: Pioneer System Operation (Optional)
Page 73 and 74: Controls & Indicators: 1. MAP Butto
Page 75 and 76: 12. P.ADJ/B.LIGHT Button Press to e
Page 77 and 78: SPOTLIGHT (OPTIONAL) The spotlight
Page 79 and 80: MONITOR PANEL INTERIOR CONTROLS & O
Page 81 and 82: SLIDEOUTS In order for the flush fl
Page 83 and 84: Maintenance Oil Level It is importa
Page 85 and 86: Magic Bed Sofa (Optional) Sofa to S
Page 87 and 88: Bed Storage Keep hands and fingers
Page 89 and 90: The TV’s operate on 120V AC power
Page 91 and 92: Television Antenna Prior to raising
Page 93 and 94: DISHWASHER (OPTIONAL) Located in a
Page 95 and 96: ENTRY DOOR The entry door is design
Page 97 and 98: Default Access Code: DIGIT 1 DIGIT
Page 99 and 100:
Power Entry Step Make sure before e
Page 101 and 102:
Remote Air Fill A convenient remote
Page 103 and 104:
NOTE: Removal of the awning from th
Page 105 and 106:
While holding the strap, let the FR
Page 107 and 108:
HEATING & AIR CONDITIONING DASH PAN
Page 109 and 110:
NOTE: The discharge air will heat u
Page 111 and 112:
CEILING VENTS Vents are provided in
Page 113 and 114:
The electrical power supply provide
Page 115 and 116:
Shore Cord Power Reel CAUTION: Whil
Page 117 and 118:
POWER INVERTER The inverter takes 1
Page 119 and 120:
BATTERIES The batteries for the mot
Page 121 and 122:
Repeat the process for each individ
Page 123 and 124:
Battery Disconnect Switches The bat
Page 125 and 126:
SOLAR PANEL (OPTIONAL) The optional
Page 127 and 128:
Bedroom Fuse Panels Located at the
Page 129 and 130:
Exterior 12 Volt Fuses Located in t
Page 131 and 132:
Generator Maintenance REFERENCE: Re
Page 133 and 134:
The motorhome plumbing system has t
Page 135 and 136:
Sanitizing the Fresh Water System D
Page 137 and 138:
Emptying the Holding Tanks 1. Remov
Page 139 and 140:
WATER SYSTEM WINTERIZATION If you i
Page 141 and 142:
SYSTEMS COMPARTMENT Exterior Shower
Page 143 and 144:
LP GAS SYSTEMS LP Gas is highly vol
Page 145 and 146:
LP GAS REGULATOR Never alter the po
Page 147 and 148:
Remember that as outside temperatur
Page 149 and 150:
How to Test Never use an open flame
Page 151 and 152:
NOTE: The LP Gas Detector enters a
Page 153 and 154:
Periodic maintenance and cleaning o
Page 155 and 156:
It is important to maintain the sea
Page 157 and 158:
Elevate the antenna and remove the
Page 159 and 160:
ABS PLASTIC Many components of the
Page 161 and 162:
Be sure that both the chassis and c
Page 163 and 164:
Manage Window Condensation Window c
Page 165 and 166:
Storage of the Motorhome During tho
Page 167 and 168:
VENDOR CONTACT INFORMATION ASA Elec
Page 169 and 170:
Thetford 2655 Cambell Road Sidney,
show all

2006 Mandalay Motorhome Owners Manual - Thor Motor Coach

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?