17.08.2013
•
Views
Cost of Service, $/1000 gallon 5.00 4.50 4.00 3.50 3.00 2.50 2.00 1.50 1.00 0.50 0.00 Transmission, miles 1 2 3 4 5 10 $2/1000 gallons - Typical Potable Water Supply Cost 5 10 15 20 25 30 Reclaimed Water Flow/Demand, mgd Figure D-4b. Reclaimed Water System Cost of Service for 5-30 mgd Capacity Urban Area - Tertiary 4 with GAC
Cost Curves as Basis for Tertiary 4 - GAC* Capital Cost Design Flow Capital Cost (mgd) ($) 0.0001 $36,117 0.007 $36,117 0.022 $53,091 0.037 $70,491 0.091 $137,932 0.18 $241,793 0.27 $340,528 0.36 $435,155 0.68 $739,387 1 $1,228,620 1.2 $1,551,122 2 $2,203,728 3.5 $3,275,153 7 $5,411,638 17 $10,411,502 22 $12,611,714 76 $31,503,622 210 $67,096,117 430 $114,813,572 520 $132,437,789 1,500.00 $324,345,925 Cost, $ Cost, $ $1,800,000 $1,600,000 $1,400,000 $1,200,000 $1,000,000 $800,000 $600,000 $400,000 $200,000 y = 334592x 2 + 826982x + 66833 R 2 = 0.9978 Curve fit equations CCI Index 1.16 Avg Flow Range 0.037-0.35 mgd >0.35-30 mgd Design Flow Range 0.037-1.2 mgd >1.2-60 mgd Design/Avg Flow Ratio 2 Note: Based on GAC reactivation frequency of 90 days (GAC-20 designation in EPA, 2005). $0 $35,000,000 $30,000,000 $25,000,000 $20,000,000 $15,000,000 $10,000,000 $5,000,000 $0 0 0.2 0.4 0.6 0.8 1 1.2 1.4 Flow, mgd y = -2423.81x 2 + 583824.08x + 1123641.87 R 2 = 1.00 0 10 20 30 40 Flow, mgd 50 60 70 80 *Source: Environmental Protection Agency (EPA), 2005. Technologies and Costs Document for the Final Long Term 2 Enhanced Surface Water Treatment Rule and Final Stage 2 Disinfectants and Disinfection Byproducts Rule. December. EPA 815-R-05-013. Trace Const Removal Technologies.xls, Summ-GAC20 Page 1 of 2 5/4/2007
-
Page 2 and 3:
Acknowledgements This study was con
-
Page 4 and 5:
Contents Recycling Treated Municipa
-
Page 6 and 7:
Contents Recycling Treated Municipa
-
Page 8 and 9:
Executive Summary Vision Executive
-
Page 10 and 11:
Section 1: Introduction 1.1 Project
-
Page 12 and 13:
Table 1.2. Water Use in Minnesota,
-
Page 14 and 15:
Section 1: Introduction Recycling T
-
Page 16 and 17:
1.5 Summary Section 1: Introduction
-
Page 18 and 19:
Section 2: Recycled Wastewater Dema
-
Page 20 and 21:
Section 2: Recycled Wastewater Dema
-
Page 23 and 24:
Section 2: Recycled Wastewater Dema
-
Page 26 and 27:
Figure 2.9. Ground Water Contaminat
-
Page 28:
Section 2: Recycled Wastewater Dema
-
Page 31:
Section 2: Recycled Wastewater Dema
-
Page 35 and 36:
Section 2: Recycled Wastewater Dema
-
Page 38 and 39:
Table 2.8. Ethanol Plant Capacity a
-
Page 40 and 41:
Section 2: Recycled Wastewater Dema
-
Page 42 and 43:
2.7 References Section 2: Recycled
-
Page 44 and 45:
Section 3: Recycled Wastewater Syst
-
Page 46 and 47:
Water Quality Overview The total co
-
Page 48 and 49:
Industrial Water Quality Concerns S
-
Page 50 and 51:
Emerging Contaminants of Concern Se
-
Page 52 and 53:
Section 3: Recycled Wastewater Syst
-
Page 54 and 55:
Section 3: Recycled Wastewater Syst
-
Page 56 and 57:
3.4 Storage and Transmission Overvi
-
Page 58 and 59:
Section 3: Recycled Wastewater Syst
-
Page 60 and 61:
Cost by Standard Industry Categorie
-
Page 62 and 63:
Costs and Planning Considerations S
-
Page 64 and 65:
Section 4: Implementation Considera
-
Page 66 and 67:
Economic Incentives and Risk Assess
-
Page 68 and 69:
Section 5: Summary and Potential Ne
-
Page 70 and 71:
Long-Term Vision Section 5: Summary
-
Page 72:
Exhibit A: California Water Recycli
-
Page 75 and 76:
Metropolitan Council Recycling Trea
-
Page 77 and 78:
Contents Section 1 - Introduction C
-
Page 79 and 80:
Craddock Consulting Engineers In As
-
Page 81 and 82:
Section 1 Introduction Craddock Con
-
Page 83 and 84:
Section 1 Introduction Craddock Con
-
Page 85 and 86:
Section 1 Introduction Craddock Con
-
Page 87 and 88:
Craddock Consulting Engineers 2-1 I
-
Page 89 and 90:
Section 2 Implementation Considerat
-
Page 91 and 92:
Section 2 Implementation Considerat
-
Page 93 and 94:
Section 2 Implementation Considerat
-
Page 95 and 96:
Table 2.4. Examples of State Water
-
Page 97 and 98:
Section 2 Implementation Considerat
-
Page 99 and 100:
Section 2 Implementation Considerat
-
Page 101 and 102:
Section 2 Implementation Considerat
-
Page 103 and 104:
Section 2 Implementation Considerat
-
Page 105 and 106:
Section 2 Implementation Considerat
-
Page 107 and 108:
Section 2 Implementation Considerat
-
Page 109:
Section 2 Implementation Considerat
-
Page 112 and 113:
Section 2 Implementation Considerat
-
Page 114 and 115:
Section 2 Implementation Considerat
-
Page 116 and 117:
Section 2 Implementation Considerat
-
Page 118 and 119:
Craddock Consulting Engineers 3-1 I
-
Page 120 and 121:
Section 3 Inventory of Major WWTPs
-
Page 122 and 123:
Section 3 Inventory of Major WWTPs
-
Page 124 and 125:
Figure 3.6. Industrial Reuse Custom
-
Page 126 and 127:
Section 3 Inventory of Major WWTPs
-
Page 128 and 129:
Figure 3.7b. Ground Water Availabil
-
Page 130 and 131:
Section 3 Inventory of Major WWTPs
-
Page 132 and 133:
") Figure 3.8c. Cedar River Watersh
-
Page 134 and 135:
Section 3 Inventory of Major WWTPs
-
Page 136 and 137:
Section 3 Inventory of Major WWTPs
-
Page 138 and 139:
Section 3 Inventory of Major WWTPs
-
Page 140 and 141:
") ") ") ") Figure 3.10c. Lower Mis
-
Page 142 and 143:
Section 3 Inventory of Major WWTPs
-
Page 144 and 145:
Section 3 Inventory of Major WWTPs
-
Page 146 and 147:
Section 3 Inventory of Major WWTPs
-
Page 148 and 149:
Section 3 Inventory of Major WWTPs
-
Page 150 and 151:
Section 3 Inventory of Major WWTPs
-
Page 152 and 153:
Figure 3.12c. Mississippi River - H
-
Page 154 and 155:
Section 3 Inventory of Major WWTPs
-
Page 156 and 157:
Section 3 Inventory of Major WWTPs
-
Page 158 and 159:
Figure 3.14b. Rainy River Watershed
-
Page 160 and 161:
Section 3 Inventory of Major WWTPs
-
Page 162 and 163:
Section 3 Inventory of Major WWTPs
-
Page 164 and 165:
Section 3 Inventory of Major WWTPs
-
Page 166 and 167:
") Figure 3.16c. St. Croix River Wa
-
Page 168 and 169:
Section 3 Inventory of Major WWTPs
-
Page 170 and 171:
Section 3 Inventory of Major WWTPs
-
Page 172 and 173:
Section 3 Inventory of Major WWTPs
-
Page 174 and 175:
Figure 3.18 Metro Area Industrial R
-
Page 176 and 177:
Section 3 Inventory of Major WWTPs
-
Page 178 and 179:
G G Flying Cloud Dr !! G! G Figure
-
Page 180 and 181:
Section 3 Inventory of Major WWTPs
-
Page 182 and 183:
Figure 3.22. Rogers WWTP - Industri
-
Page 184 and 185:
Section 3 Inventory of Major WWTPs
-
Page 186 and 187:
G G G! Dodd Rd GG Figure 3.24. Rose
-
Page 188 and 189:
Section 3 Inventory of Major WWTPs
-
Page 190 and 191:
G Figure 3.26. Hastings WWTP - Indu
-
Page 192 and 193:
State Hwy 36 ! Figure 3.28. St. Cro
-
Page 194 and 195:
Section 3 Inventory of Major WWTPs
-
Page 196 and 197:
Section 3 Inventory of Major WWTPs
-
Page 198 and 199:
Craddock Consulting Engineers In As
-
Page 200 and 201:
Water Use Code Categories Minnesota
-
Page 202 and 203:
Minnesota Water Use for All Categor
-
Page 204 and 205:
Air Conditioning 0.2% Waterworks 15
-
Page 206 and 207:
Minnesota Water Use, 2000-2004 - St
-
Page 208 and 209:
Minnesota Water Use in 2004 (withou
-
Page 210 and 211:
Minnesota Water Use in 2000 (withou
-
Page 212 and 213:
UseCode by Year Minnesota Power Gen
-
Page 214 and 215:
Water Use (MGD) Water Use (MGD) 350
-
Page 216 and 217:
Minnesota Industrial Processing Fac
-
Page 218 and 219:
Minnesota Industrial Processing Fac
-
Page 220 and 221:
Water Use (MGD) Water Use (MGD) 120
-
Page 222 and 223:
Water Use (MGD) Water Use (MGD) 13.
-
Page 224 and 225:
Craddock Consulting Engineers In As
-
Page 226 and 227:
Overview There are no federal regul
-
Page 228 and 229:
Appendix B Status of Water Reuse Re
-
Page 230 and 231:
Appendix B Status of Water Reuse Re
-
Page 232 and 233:
Table 4. Examples of State Water Re
-
Page 234 and 235:
Appendix B Status of Water Reuse Re
-
Page 236 and 237:
Appendix B Status of Water Reuse Re
-
Page 238 and 239:
Setback Distances Appendix B Status
-
Page 240 and 241:
Appendix B Status of Water Reuse Re
-
Page 242 and 243:
Appendix B Status of Water Reuse Re
-
Page 244 and 245:
Appendix B Status of Water Reuse Re
-
Page 246 and 247:
Craddock Consulting Engineers In As
-
Page 248 and 249:
WATER USE (MGD) WATER USE (MGD) 3.5
-
Page 250 and 251:
Table 3.9a. Industrial Water Use in
-
Page 252 and 253:
Table 3.10a. Industrial Water Use i
-
Page 254 and 255:
Table 3.10d. Industries in the Lowe
-
Page 256 and 257:
WATER USE (MGD) WATER USE (MGD) 8 7
-
Page 258 and 259:
Table 3.11d. Industries in the Minn
-
Page 260 and 261:
Table 3.11d. Industries in the Minn
-
Page 262 and 263:
WATER USE (MGD) WATER USE (MGD) 12
-
Page 264 and 265:
Table 3.12c. Industries in the Miss
-
Page 266 and 267:
Table 3.12c. Industries in the Miss
-
Page 268 and 269:
Table 3.12c. Industries in the Miss
-
Page 270 and 271:
Table 3.12c. Industries in the Miss
-
Page 272 and 273:
Table 3.13a. Industrial Water Use i
-
Page 274 and 275:
Table 3.14a. Industrial Water Use i
-
Page 276 and 277:
Table 3.15a. Industrial Water Use i
-
Page 278 and 279:
WATER USE (MGD) WATER USE (MGD) 2.5
-
Page 280 and 281:
WATER USE (MGD) WATER USE (MGD) 0.8
-
Page 282 and 283:
Table 3.17c. Industries in the West
-
Page 284 and 285:
MN Permit No Facility Minnesota Mun
-
Page 286 and 287:
MN Permit No Facility Minnesota Mun
-
Page 288 and 289:
Craddock Consulting Engineers In As
-
Page 290:
Minnesota DNR Waters 2005 Ground-wa
-
Page 294 and 295:
Craddock Consulting Engineers In As
-
Page 296 and 297:
Permit No. Organization NAICS Code
-
Page 298 and 299:
Permit No. Organization NAICS Code
-
Page 300 and 301:
Permit No. Organization NAICS Code
-
Page 302 and 303:
Permit No. Organization NAICS Code
-
Page 304 and 305:
Permit No. Organization NAICS Code
-
Page 306 and 307:
Permit No. Organization NAICS Code
-
Page 308 and 309:
Permit No. Organization NAICS Code
-
Page 310 and 311:
Metropolitan Council Recycling Trea
-
Page 312 and 313:
TM2: Sampling Plan and Results Recy
-
Page 314 and 315:
TM2: Sampling Plan and Results Recy
-
Page 316 and 317:
TM2: Sampling Plan and Results Recy
-
Page 318 and 319:
TM2: Sampling Plan and Results Recy
-
Page 320 and 321:
TM2: Sampling Plan and Results Recy
-
Page 322 and 323:
TM2: Sampling Plan and Results Recy
-
Page 324 and 325:
TM2: Sampling Plan and Results Recy
-
Page 326 and 327:
Recommended Limits for Various Indu
-
Page 328:
Exhibit B Blue Lake WWTP Sampling R
-
Page 331 and 332:
MCES Blue Lake Plant Final Effluent
-
Page 333 and 334:
Date Day of Wk MCES Blue Lake Plant
-
Page 335 and 336:
Date Day of Wk MCES Blue Lake Plant
-
Page 337 and 338:
Date Day of Wk MCES Blue Lake Plant
-
Page 340 and 341:
MCES Empire Plant Final Effluent Sa
-
Page 342 and 343:
Date Day of Wk 10/24/06 Tuesday 10/
-
Page 344 and 345:
Date Day of Wk 10/24/06 Tuesday 10/
-
Page 346 and 347:
Date Day of Wk 10/24/06 Tuesday 10/
-
Page 348 and 349:
Exhibit D Metropolitan (Metro) WWTP
-
Page 350 and 351:
MCES Metropolitan Plant Final Efflu
-
Page 352 and 353:
Date Day of Wk 4/19/07 Thursday 4/2
-
Page 354 and 355:
Date Day of Wk 4/19/07 Thursday 4/2
-
Page 356 and 357:
Date Day of Wk 4/19/07 Thursday 4/2
-
Page 358 and 359:
MCES Seneca Plant Final Effluent Sa
-
Page 360 and 361:
Date Day of Wk 10/8/06 Sunday 10/9/
-
Page 362 and 363:
Date Day of Wk 10/8/06 Sunday 10/9/
-
Page 364 and 365:
Date Day of Wk 10/8/06 Sunday 10/9/
-
Page 366 and 367:
Metropolitan Council Recycling Trea
-
Page 368 and 369:
Section 5 - Costs Table of Contents
-
Page 370 and 371:
TM3: Recycled Wastewater System Com
-
Page 372 and 373:
TM3: Recycled Wastewater System Com
-
Page 374 and 375:
WWTP 1 - 2 - 3 - 4 - 5 - 1 Treatmen
-
Page 376 and 377:
TM3: Recycled Wastewater System Com
-
Page 378 and 379:
TM3: Recycled Wastewater System Com
-
Page 380 and 381:
TM3: Recycled Wastewater System Com
-
Page 382:
o Synthetic medium o Two-stage Surf
-
Page 385 and 386:
TM3: Recycled Wastewater System Com
-
Page 387 and 388:
TM3: Recycled Wastewater System Com
-
Page 389 and 390:
TM3: Recycled Wastewater System Com
-
Page 391 and 392:
TM3: Recycled Wastewater System Com
-
Page 393 and 394:
TM3: Recycled Wastewater System Com
-
Page 395 and 396:
TM3: Recycled Wastewater System Com
-
Page 397 and 398:
TM3: Recycled Wastewater System Com
-
Page 399 and 400:
TM3: Recycled Wastewater System Com
-
Page 401 and 402:
TM3: Recycled Wastewater System Com
-
Page 403 and 404:
Table 13 WATER REUSE SYSTEM COST OF
-
Page 405 and 406:
TM3: Recycled Wastewater System Com
-
Page 407 and 408:
TM3: Recycled Wastewater System Com
-
Page 409 and 410:
Cost of Service, $/1000 gallon 1.00
-
Page 411 and 412:
TM3: Recycled Wastewater System Com
-
Page 413 and 414:
TM3: Recycled Wastewater System Com
-
Page 415 and 416:
TM3: Recycled Wastewater System Com
-
Page 417 and 418:
TM3: Recycled Wastewater System Com
-
Page 419 and 420:
Cost of Service, $/1000 gallons 8.0
-
Page 421 and 422:
TM3: Recycled Wastewater System Com
-
Page 423 and 424:
Appendix A Water Reuse Regulatory E
-
Page 425 and 426:
Table A-1. 2000 California Water Re
-
Page 427 and 428:
California Department of Health Ser
-
Page 429 and 430:
Other Media Type Filters Fuzzy Filt
-
Page 431 and 432:
Appendix B TECHNICAL MEMORANDUM Rec
-
Page 433 and 434:
Appendix B Reclaimed Water Transmis
-
Page 435 and 436:
Exhibit 1 Transmission Main Cost To
-
Page 437 and 438:
Pipe Installation Data (DR 18 PVC P
-
Page 439 and 440:
Equipment Costs (with O&P) Item Des
-
Page 441 and 442:
Water Reuse Pipe Line Construction
-
Page 443 and 444:
Construction Unit Costs Item (2006
-
Page 445 and 446:
Crew Costs (with O&P) St. Paul Pres
-
Page 447 and 448:
Capital PROJECT Cost Curves for Rec
-
Page 449 and 450:
Diam (in) Annual Average Day Flow A
-
Page 451 and 452:
Diam (in) Annual Average Day Flow A
-
Page 453 and 454:
Pipe Capital Project Cost, $ Millio
-
Page 455 and 456:
Pipe Capital Project Cost, $/1000 g
-
Page 457 and 458:
Capital PROJECT Cost Curves for Rec
-
Page 459 and 460:
Capital PROJECT Cost Curves for Rec
-
Page 461 and 462:
Annual Pipe Average Annual Velocity
-
Page 463 and 464:
Pipe Capital Project Cost, $ Millio
-
Page 465 and 466:
Exhibit 3 Water Reuse System O&M Co
-
Page 467 and 468:
Diam (in) Annual Average Day Flow (
-
Page 469 and 470:
Diam (in) Annual Average Day Flow (
-
Page 471 and 472:
Diam (in) Annual Average Day Flow (
-
Page 473 and 474:
Diam (in) Annual Average Day Flow (
-
Page 475 and 476:
Pumping Cost, $/1000 gallons 0.095
-
Page 477 and 478:
Water Reuse System Estimated Cost o
-
Page 479 and 480:
WATER REUSE SYSTEM COST OF SERVICE
-
Page 481 and 482:
WATER REUSE SYSTEM COST OF SERVICE
-
Page 483 and 484:
WATER REUSE SYSTEM COST OF SERVICE
-
Page 485 and 486:
WATER REUSE SYSTEM COST OF SERVICE
-
Page 487 and 488:
WATER REUSE SYSTEM COST OF SERVICE
-
Page 489 and 490:
Appendix D-1 Water Reuse System Cos
-
Page 491 and 492:
Water Reuse System Estimates of Pro
-
Page 493 and 494:
Cost of Service, $/1000 gallon 2.00
-
Page 495 and 496:
Cost Curves as Basis for Tertiary 1
-
Page 497 and 498:
Cost Curves as Basis for Tertiary 1
-
Page 499 and 500:
Water Reuse System Estimated Cost o
-
Page 501 and 502:
Cost of Service, $/1000 gallon 10.0
-
Page 503 and 504:
Cost Curves as Basis for Tertiary 2
-
Page 505 and 506:
Appendix D-3 Water Reuse System Cos
-
Page 507 and 508:
Water Reuse System Estimates of Pro
-
Page 509 and 510:
Cost of Service, $/1000 gallon 5.00
-
Page 511 and 512:
Cost Curves as Basis for Tertiary 3
-
Page 513 and 514:
Water Reuse System Estimated Cost o
-
Page 515:
Cost of Service, $/1000 gallon 10.0
-
Page 519 and 520:
Appendix D-5 Water Reuse System Cos
-
Page 521 and 522:
Water Reuse System Estimates of Pro
-
Page 523 and 524:
Cost of Service, $/1000 gallon 5.00
-
Page 525 and 526:
Appendix D-6 Water Reuse System Cos
-
Page 527 and 528:
Water Reuse System Estimates of Pro
-
Page 529 and 530:
Cost of Service, $/1000 gallon 5.00
-
Page 531 and 532:
Cost Curves as Basis for Tertiary 4
-
Page 533 and 534:
Secondary Treatment Assumptions Sus
-
Page 535 and 536:
Secondary Treatment Assumptions Sus
-
Page 537 and 538:
Secondary Treatment Assumptions Sus
-
Page 539 and 540:
Secondary Treatment Assumptions Sus
-
Page 541 and 542:
Craddock Consulting Engineers 1 In
-
Page 543 and 544:
TM4: WWTP Effluent Quality Recyclin
-
Page 545 and 546:
!( !( !( !( !( !( !( !( !( !( !( !(
-
Page 547 and 548:
TM4: WWTP Effluent Quality Recyclin
-
Page 549 and 550:
Frequency of Occurrence, % Frequenc
-
Page 551 and 552:
No. of Plants Total Permitting Desi
-
Page 553 and 554:
TM4: WWTP Effluent Quality Recyclin
-
Page 555 and 556:
!( !( !( !( !( !( !( !( !( !( !( !(
-
Page 557 and 558:
TM4: WWTP Effluent Quality Recyclin
-
Page 559 and 560:
Frequency of Occurrence, % Frequenc
-
Page 561 and 562:
No. of Plants Total Permitting Desi
-
Page 563 and 564:
TM4: WWTP Effluent Quality Recyclin
-
Page 565 and 566:
!( !( !( !( !( !( !( !( !( !( !( !(
-
Page 567 and 568:
TM4: WWTP Effluent Quality Recyclin
-
Page 569 and 570:
Craddock Consulting Engineers 1 In
-
Page 571 and 572:
1.0 Introduction This technical mem
-
Page 573 and 574:
Exhibit A Regulatory Stakeholder Me
-
Page 575 and 576:
MCES Recycling Treated Wastewater f
-
Page 577 and 578:
MCES Recycling Treated Wastewater f
-
Page 579 and 580:
Municipal Wastewater Reuse Regulato
-
Page 581 and 582:
MCES Recycling Treated Wastewater f
-
Page 583 and 584:
Exhibit B Industry Stakeholder Meet
-
Page 585 and 586:
Recycling Treated Wastewater For In
-
Page 587 and 588:
Institutional Issues Topic Discussi
-
Page 589 and 590:
Institutional Issues Topic Discussi
-
Page 591 and 592:
Recycling Treated Wastewater For In
-
Page 593 and 594:
Recycling Treated Wastewater For In
-
Page 595 and 596:
Recycling Treated Wastewater For In
-
Page 597 and 598:
Recycling Treated Wastewater For In
-
Page 599 and 600:
Exhibit C Broader Base Stakeholder
-
Page 601 and 602:
Recycling Treated Wastewater For In
-
Page 603 and 604:
Recycling Treated Wastewater For In
-
Page 605 and 606:
Recycling Treated Wastewater For In
-
Page 607 and 608:
Recycling Treated Wastewater For In
-
Page 609 and 610:
Recycling Treated Wastewater For In
-
Page 611 and 612:
Recycling Treated Wastewater For In
Change language