8196446 - Frymaster

More documents

Recommendations

Info

1.14.6 M3000 Filter Error Flowchart Fryer returns to cook mode for 4 minutes or 15 minutes if pad change expired. SIXTH CONSECUTIVE FILTER ERROR NORMAL OPERATION RESUMES Change filter pad and ensure filter pan is pulled out for a minimum of 30 seconds. This chart follows the process of clearing a filtration issue. The prompt is displayed when any of the following occur: 1. a clogged filter pad, 2. a tripped or defective filter pump, 3. a leaky O-ring on the pick-up tube, 4. a failed drain valve/actuator, or 5. a failed return valve/actuator. 1-37 TECH ENTERS CODE MESSAGE DISPLAYED Call an Authorized Repair Technician Fryer returns to cook mode for 15 minutes. If the computer displays SERVICE REQUIRED, the fryer can be used in most cases by answering NO when the prompt for SYSTEM ERROR FIXED? YES NO is displayed. The message repeats every 15 minutes until the issue is repaired and error cleared by a technician. To clear the error, enter 1111 after answering YES when SYSTEM ERROR FIXED? YES NO is displayed.
1.14.7 M3000 Menu Summary Tree Reflected below are the major programming sections in the M3000 and the order in which submenu headings will be found under the sections in the Installation and Operation Manual. Adding New Menu Items See section 4.10.2 Storing Menu Items in Product Buttons See section 4.10.3 Draining, Refilling, and Disposing of Oil See section 4.10.4 1-38
Page 1 and 2: This equipment chapter is to be ins
Page 3 and 4: DANGER Improper installation, adjus
Page 5 and 6: • no fryer will be warranted unde
Page 7 and 8: BIELA14 SERIES GEN II LOV ELECTRIC
Page 9 and 10: 3. Remove the two screws from the u
Page 11 and 12: 4. Locate the red (or yellow) and w
Page 13 and 14: Full vat element wire routing 3 6 2
Page 15 and 16: 4. The contactors and relays are he
Page 17 and 18: 23. Position the element tube assem
Page 19 and 20: Disconnect flexlines indicated by t
Page 21 and 22: Problem Probable Causes Corrective
Page 23 and 24: 1.10.3 Replacing the ATO board, LON
Page 25 and 26: 1.11.2 MIB (Manual Interface Board)
Page 31 and 32: 1.12.2 RTI LOV Wiring 1.12.3 Frymas
Page 33 and 34: 8. “Filling” is displayed durin
Page 35 and 36: 1.13.2 AIF (Auto Intermittent Filtr
Page 37 and 38: 1.13.5 Replacing a Rotary Actuator
Page 39 and 40: Problem Probable Causes Corrective
Page 41 and 42: 1.14.3 Service Required Errors A SE
Page 43: 1.14.5 Tech Mode Tech mode allows t
Page 47 and 48: 1.15 Loading and Updating Software
Page 49 and 50: 1.17 Interface Board Diagnostic Cha
Page 51 and 52: 1.19 Wiring Diagrams 1.19.1 Compone
Page 53 and 54: 1.19.3 Component Wiring (CSA) 1-46
Page 55 and 56: 1.19.5 Contactor Box - Delta Config
Page 57 and 58: 1.19.7 Simplified BIELA14 LOV Gen I
Page 59 and 60: 1.19.9 Simplified BIELA14 LOV Gen I
Page 61 and 62: 1.19.11 BIELA14 Gen II Series LOV S
Page 63 and 64: 2.2 Doors, Sides, Tilt Housings, Ca
Page 65 and 66: 2.3.2 Drain Valves and Associated P
Page 67 and 68: 2.4.1 Component Boxes cont. ITEM PA
Page 69 and 70: 2.4.2.1 Left and Right Contactor Bo
Page 71 and 72: 2.4.3.1 Element Assemblies and Hard
Page 73 and 74: 2.4.3.2 Element Tube Assemblies con
Page 75 and 76: 2.4.5.3 Contactor Box Wiring Assemb
Page 77 and 78: 2.4.5.6 Component Box and Filter Pu
Page 79 and 80: 2.5 Filtration System Components 2.
Page 81 and 82: 2.5.2 Auto Intermittent Filtration
Page 83 and 84: 2.6 Frypot Assemblies and Associate
Page 85 and 86: 2.7 Oil Return Manifolds ITEM PART
Page 87 and 88: 2.9.2 JIB Cap and Pick Up Assembly
Page 89 and 90: 2.10 RTI 2.10.1 RTI Manifold and Ac
Page 91 and 92: 2.10.2 RTI Dispose Waste Valve ITEM
Page 93 and 94: 2.12 Fasteners ITEM PART # COMPONEN

8196446 - Frymaster

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?