ORNL-1771 - Oak Ridge National Laboratory
ORNL-1771 - Oak Ridge National Laboratory ORNL-1771 - Oak Ridge National Laboratory
J Fig, 3.4. Inconel Forced-Circulation Corrosion Loop. PERIOD ENDING SEPTEMBER IO, 7954 39
ANP QUARTERLY PROGRESS REPORT TEMPERATURE DIFFERENTIAL, 159.2OF REYNOLDS NO. AT 13OO0F, 3730 REYNOLDS NO. AT 1459"F, 4540 FLOW, 0.81 gprn VELOCITY, 5.29 fps MASS FLOW RATE, 0.361 Iblsec LENGTH OF HEATING SECTION, 5.13 ft LENGTH OF COOLING SECTION, 5.86 ft POWER, 17.6 kw CURRENT, 400 amp VOLTAGE, 44 HEATING SECTION 1 ORNL - LR -DWG 3097 0.02 5 -in. WALL INCONEL TUBING Fig. 3.5. Configuration and Design Conditions for lnconel Forced-Circulation Loop to Operate at a Temperature Differential of Approximately 16OOF. A summary of the design dimensions and expected operating conditions for each of the six loops is presented in Table 3.1, which also indicates the current status of each loop. Three methods of heating were studied: electr ical-res i stance, gas- fired furnace, and liquid bath. The liquid bath was discounted because it would require pres- surization of the liquid rneta1,an excessively long heat exchanger,and a large investment. A gas- fired furnace was considered, but lack of operating experience and the high heat flux necessary for the loops indicated the use of electrical heating, with which considerable experience has been ob- tained. A gas-fired furnace is being studied as a possible heat source for a large number of cor- rosion loops. Preliminary calculations of the pressure drop through the loops indicate that the 40 Model LFA pump8 can be used, and thus it will not be necessary to develop a pump. For purposes of preliminary design the following assumptions were made: (1) The specific resis- tivity of molten NaF-ZrF,-UF, (50-46-4 mole %) is so high that the resistance of the electrically heated lnconel tube may be taken as the parallel circuit re~istance.~ (2) Heat transfer to the fluoride mixture may be calculated by relations established for water." (3) A thermal loss equal 'W. 6. McDonald et al., ANP Quar. Prog. Rep. Mar. 10, 1954, ORNL-1692, p 15. n 'A. L. Southern, personal communication. 'OD. F. Salmon, Turbulent Heat Transfer from a Molten Fluoride Salt Mixture to NaK in a Double Tube Heat Exchanger, ORNL-1716 (to be issued).
- Page 2 and 3: Contract No. W-7405-eng-26 AIRCRAFT
- Page 4 and 5: 1. G. M. Adamson 2. R. G. Affel 3.
- Page 6 and 7: 197-198. Powerplant Laboratory (WAD
- Page 8: FOREWORD This quarterly progress re
- Page 11 and 12: PART II . MATERIALS RESEARCH 5 . CH
- Page 13 and 14: Remote Metallography ..............
- Page 15 and 16: ANP QUARTERLY PROGRE.S.5 REPORT ver
- Page 17 and 18: AMP QUARTERLY PROGRESS REPORT A dev
- Page 20: part I REACTOR THEORY, COMPONENT DE
- Page 23 and 24: AMP QUARTERLY PROGRESS REPORT After
- Page 25 and 26: ANP QUARTERLY PROGRESS REPORT the A
- Page 27 and 28: ANP QUARTERLY PROGRESS REPORT 67 g
- Page 29 and 30: ANP QUARTERLY PROGRESS REPORT appro
- Page 31 and 32: ANP QUARTERLY PROGRESS REFORT be si
- Page 33 and 34: ANP QUARTERLY PROGRESS REPORT TABLE
- Page 35 and 36: ANP QUARTERLY PROGRESS REPORT - 22
- Page 37 and 38: in the ZPU system, While this arran
- Page 40 and 41: I ORNL-LR-DWG 3092 CALCULATIONS EXT
- Page 42 and 43: Power level TABLE 2.6. COMPARISON O
- Page 44 and 45: PERIOD ENDING SEPTEMBER JO, 1954 Fi
- Page 46 and 47: I R j I Fig. 2.7. Surfaces of Beryl
- Page 48 and 49: that will permit remote, momentary
- Page 50 and 51: sump in that it must be sufficientl
- Page 54 and 55: - PERIOD ENDING SEPTEMBER 10, 1954
- Page 56 and 57: from 18 to 31 so that tests of long
- Page 58 and 59: A A Fig. 4.1. First Reflector-Moder
- Page 60 and 61: - 40 32 c 3 24 A F! P ._r >- k > ir
- Page 62 and 63: with and without 0.OZin.-thick cadm
- Page 64: Part II MATERIALS RESEARCH
- Page 67 and 68: ANP QUARTERLY PROGRESS REPORr propo
- Page 69 and 70: ANP QUARTERLY PROGRESS REPORT appar
- Page 71 and 72: ANP QUARTERLY PROGRESS REPORT urani
- Page 73 and 74: ANP QUARTERLY PROGRESS REPORT seems
- Page 75 and 76: ANP QUARTERLY PROGRESS REPORT ~~ -
- Page 77 and 78: AN P QUARTER 1Y PROGRESS R EPOR J T
- Page 79 and 80: ANP QUARTERLY PROGRESS REPORT of 0.
- Page 81 and 82: ANP QUARTERLY PROGRESS REPORT q0-2
- Page 83 and 84: 4NP QUARTERLY PROGRESS REPORT on d
- Page 85 and 86: ANP QUARTERLY PROGRESS R €PO RT P
- Page 87 and 88: ANP QUARTERLY PROGRESS REPORT ammet
- Page 89 and 90: ANP QUARTERLY PROGRESS REPORT catho
- Page 91 and 92: P,NP QUARTERLY PROGRESS REPOK'I ___
- Page 93 and 94: ANP QUARTERLY PROGRESS REPORT CH EM
- Page 95 and 96: ANP QUARTERLY PROGRESS REPORT A pla
- Page 97 and 98: ANP QUARTERLY PROGRESS REPORT Fig.
- Page 99 and 100: ANP QUARTERLY PROGRESS REKIRT TABLE
- Page 101 and 102: ANP QUARTERLY PROGRESS REPORT TABLE
J<br />
Fig, 3.4. Inconel Forced-Circulation Corrosion Loop.<br />
PERIOD ENDING SEPTEMBER IO, 7954<br />
39