BCT-1510 BCT-1520 BCT-1530

More documents

Recommendations

Info

$D:\FUJITSU\TRWAM 1200F-S\newTRW$

TS5, BCT-1510, BCT-1520, BCT-1530 1. SAFETY INFORMATION This service manual is intended for qualified service technicians ; it is not meant for the casual do-ityourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician. WARNING This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to cause cancer, birth defects or other reproductive harm. Health & Safety Code Section 25249.6 – Proposition 65 NOTICE (FOR CANADIAN MODEL ONLY) Fuse symbols (fast operating fuse) and/or (slow operating fuse) on PCB indicate that replacement parts must be of identical designation. REMARQUE (POUR MODÈLE CANADIEN SEULEMENT) Les symboles de fusible (fusible de type rapide) et/ou (fusible de type lent) sur CCI indiquent que les pièces de remplacement doivent avoir la même désignation. 2 (FOR USA MODEL ONLY) 1. SAFETY PRECAUTIONS The following check should be performed for the continued protection of the customer and service technician. LEAKAGE CURRENT CHECK Measure leakage current to a known earth ground (water pipe, conduit, etc.) by connecting a leakage current tester such as Simpson Model 229-2 or equivalent between the earth ground and all exposed metal parts of the appliance (input/output terminals, screwheads, metal overlays, control shaft, etc.). Plug the AC line cord of the appliance directly into a 120V AC 60Hz outlet and turn the AC power switch on. Any current measured must not exceed 0.5mA. Device under test Test all exposed metal surfaces Also test with plug reversed (Using AC adapter plug as required) Leakage current tester AC Leakage Test Reading should not be above 0.5mA Earth ground ANY MEASUREMENTS NOT WITHIN THE LIMITS OUTLINED ABOVE ARE INDICATIVE OF A POTENTIAL SHOCK HAZARD AND MUST BE CORRECTED BEFORE RETURNING THE APPLIANCE TO THE CUSTOMER. 2. PRODUCT SAFETY NOTICE Many electrical and mechanical parts in the appliance have special safety related characteristics. These are often not evident from visual inspection nor the protection afforded by them necessarily can be obtained by using replacement components rated for voltage, wattage, etc. Replacement parts which have these special safety characteristics are identified in this Service Manual. Electrical components having such features are identified by marking with a on the schematics and on the parts list in this Service Manual. The use of a substitute replacement component which does not have the same safety characteristics as the PIONEER recommended replacement one, shown in the parts list in this Service Manual, may create shock, fire, or other hazards. Product Safety is continuously under review and new instructions are issued from time to time. For the latest information, always consult the current PIONEER Service Manual. A subscription to, or additional copies of, PIONEER Service Manual may be obtained at a nominal charge from PIONEER.
TS5, BCT-1510, BCT-1520, BCT-1530 3
Page 1: CANAL PLUS TUNER TS5 BCT-1510 BCT-1
Page 5 and 6: (1) PACKING PARTS LIST Mark No. Des
Page 7 and 8: (1) EXTERIOR SECTION PARTS LIST Mar
Page 9 and 10: S8004 CN5004 BKP1122 5 6 7 8 TS5, B
Page 11 and 12: IC1004 5 6 7 8 TS5/BCT-1510/BCT-152
Page 13 and 14: A 7/7 A 1/7 5 6 7 8 A 7/7 A 7/7 A 7
Page 15 and 16: A 7/7 5 6 7 8 SDRAM (16M) TS5, BCT-
Page 17 and 18: A 7/7 A 7/7 5 6 7 8 TS5, BCT-1510,
Page 19 and 20: 1 2 3 4 TS5, BCT-1510, BCT-1520, BC
Page 21 and 22: 5 6 7 8 Modem IC TS5, BCT-1510, BCT
Page 23 and 24: Reset IC 5 6 7 8 : The power supply
Page 25 and 26: 3.10 CARD ASSY CARD ASSY (BWE1080)
Page 27 and 28: TS5, BCT-1510, BCT-1520, BCT-1530 2
Page 29 and 30: 4.2 CARD ASSY C 1 2 3 4 CARD ASSY T
Page 31 and 32: 5 6 7 8 RCA PIN JACK D-SUB 25PIN IE
Page 33 and 34: 5 6 7 8 TS5, BCT-1510, BCT-1520, BC
Page 35 and 36: TS5, BCT-1510, BCT-1520, BCT-1530 M
Page 37 and 38: 7. GENERAL INFORMATION TS5, BCT-151
Page 39 and 40: •Pin Function (2/3) 39 POR Ο Pow
Page 41 and 42: STI5512MWD (MAIN ASSY(2/7) : IC2001
Page 43 and 44: TS5, BCT-1510, BCT-1520, BCT-1530
Page 45 and 46: •Pin Function (4/5) Pin In/Out Fu
Page 47 and 48: CXA2161R (MAIN ASSY(4/7) : IC4001)
Page 49 and 50: •Pin Function (1/3) Pin Num 50 7
Page 51 and 52: •Pin Function (3/3) Pin Num 10 12
Page 53 and 54:
73K324BL-IH (MAIN ASSY(6/7) : IC600
Page 55 and 56:
•Pin Function (2/3) PARALLEL MICR
Page 57 and 58:
AMC2442ACVF(0.87) (MAIN ASSY(6/7) :
Page 59 and 60:
PE5181A (MAIN ASSY(7/7) : IC7001)
Page 61:
8.2 SPECIFICATIONS RF Moduration Me
show all

BCT-1510 BCT-1520 BCT-1530

Create successful ePaper yourself

Delete template?

Save as template?