S1800 Marine Model Ice Machines – Service Manual - Manitowoc Ice
S1800 Marine Model Ice Machines – Service Manual - Manitowoc Ice
S1800 Marine Model Ice Machines – Service Manual - Manitowoc Ice
Create successful ePaper yourself
Turn your PDF publications into a flip-book with our unique Google optimized e-Paper software.
Electrical System Section 6<br />
Automatic Shut-Off<br />
7. AUTOMATIC SHUT-OFF<br />
When the storage bin is full at the<br />
end of a harvest cycle, the sheet of<br />
cubes fails to clear the water curtain<br />
and holds it open. After the water<br />
curtain is held open for 30 seconds,<br />
the ice machine shuts off.<br />
The ice machine remains off until<br />
enough ice is removed from the<br />
storage bin to allow the sheet of<br />
cubes to drop clear of the water<br />
curtain. As the water curtain swings<br />
back to the operating position, the bin<br />
switch closes and the ice machine<br />
restarts (steps 1-2), provided the 3<br />
minute delay period is complete.<br />
NOTE: The ice machine must remain<br />
off for 3 minutes before it can<br />
automatically restart.<br />
L1<br />
(88)<br />
Ground<br />
(89)<br />
High<br />
Pressure<br />
Cutout<br />
(42)<br />
Self-Contained — Automatic Shut-Off<br />
Table 6-7. Self-Contained <strong>Model</strong>s<br />
7. Automatic Shut-Off (Until Bin Switch Closes)<br />
Toggle Switch ICE<br />
Bin Switch<br />
Control Board Relays<br />
Open<br />
#1 Water Pump OFF<br />
#2 Harvest Valve (Left) OFF<br />
#3 Harvest Valve (Right) OFF (When Used)<br />
#4 Air Compressor OFF (When Used)<br />
#5 Water Inlet Valve OFF<br />
#6 Water Dump Valve OFF<br />
#7 Contactor Coil Open / OFF<br />
#7A Compressor OFF<br />
#7B Condenser Fan Motor OFF<br />
Safety Controls (Which could stop ice machine operation)<br />
High Pressure Cut-Out Closed<br />
Main Fuse (On Control Board) Closed<br />
(55)<br />
<strong>Ice</strong> Thickness<br />
Probe<br />
Water Level Probe<br />
Contactor<br />
Contacts<br />
(Black)<br />
L1<br />
Overload<br />
(51) (85)<br />
Control Board<br />
(2)<br />
(6)<br />
(5)<br />
(1)<br />
(7)<br />
(4)<br />
Trans.<br />
Fuse (7a)<br />
Water Valve<br />
(21)<br />
(22)<br />
Harvest Valve<br />
(77)<br />
(80)<br />
SV3137-1<br />
6-8 Part Number 80-1634-3<br />
Low DC<br />
Voltage<br />
Plug<br />
(Red)<br />
Fan Cycle<br />
Control<br />
(9)<br />
L2<br />
(25)<br />
(8)<br />
Compressor<br />
(86)<br />
(Yellow)<br />
(61)<br />
(26)<br />
(1)<br />
(2)<br />
(20)<br />
(60)<br />
(57)<br />
(6)<br />
(46)<br />
(58)<br />
Dump Valve<br />
(76)<br />
(81)<br />
Water Pump<br />
(98)<br />
(59)<br />
Terminates at<br />
Pin Connection<br />
Contactor Coil<br />
(56)<br />
Air Compressor<br />
Bin Switch<br />
PTCR<br />
Fan Motor<br />
Clean<br />
OFF<br />
ICE<br />
Run Capacitor<br />
(74)<br />
Run Capacitor<br />
(50)<br />
(45)<br />
(99)<br />
(75)<br />
L2 or N