298 94 307/02 Untersuchungen zum Stand der Umsetzung des ...
298 94 307/02 Untersuchungen zum Stand der Umsetzung des ... 298 94 307/02 Untersuchungen zum Stand der Umsetzung des ...
Teil 3 Seite 7-4 Parameter Unit Average value Range Acid capacity KS4,3 l mmol/ Hydrogen carbonate mmol/ l Total water density (Ca, Mg) mmol/ l 53 54-85 6,4 - 0,05 0,03-0,1 COD homogenised mg/l - 4000-18000 BOD5 homogenised mg/l - 3600-16000 Carbon acids C1 – C6 (as COD) mg/l 5900 3200-6600 Ammonium-N mg/l 800 180-3000 org.-N mg/l 105
Teil 3 Seite 7-5 - Cleaning wastewater of the clean side, with a considerably lower load than that of the unclean side. With this part-stream, we find again that it does not increase proportion- ately with the size of the plant. - Wastewater from the exhaust air treatment, which is comprised of the wastewater from the process exhaust air and the room exhaust air. The treatment can be done together or separately. The wastewater from the process exhaust air treatment can be highly loaded with organic components (up to 25.000 mg/l COD), Merkaptanes (up to approx. 2.000 mg/l, hydrogen sulphide (up to approx. 800 mg/l), ammonium nitrogen (up to approx. 400 mg/l), ethereal oils, phenoles, aldehydes, etc. Because of the low waste- water production, however, only low loads can be expected. - Wastewater from the lorry cleaning, which may contain mineral oil and high ratios of solids, possibly also cleaning agents. - Wastewater from the production water processing, which is produced during the re- generation as neutral saline solution. - De-sludging wastewater from the evaporators, which is has hardly any organic load, but which may contain higher concentrations of phosphorous compounds from the conditioning agents. This part-stream has particularly high pH-values, which must be taken care of. - Wastewater from the de-sludging of the cooling water recirculation - Cooling water from the continuous-flow cooling - Domestic wastewater, which additionally contains laundry water, so that principally for - each member of the staff the full population equivalent is assumed Wastewater from fortified areas with a lower load. According to Table 1, the specific entire raw wastewater production is 0,9–1,6 m 3 /t of raw material. The average specific raw wastewater production can be assumed to be 1,1 m 3 /t of raw material. The larger the respective plant, the lower is the specific wastewater production, because particularly the cleaning wastewater amounts do not correlated with the size of the plant. In the majority of plants, there is not production at the weekends, so that then no waste- water is produced. Thus, in this industry wastewater equalisation is used. The pollutant concentrations and loads are mainly caused by the process water from sterilisation and drying, so that also for the entire production wastewater there results a dependence on the kind and condition of the raw material and thus also on the outside temperatures (summer and winter values). As the process water, the entire production wastewater has a high load of organic substances and reduced nitrogen compounds. Phosphorous is contained in higher concentrations only when the entire wastewater con- tains also process water from the blood processing. Otherwise, there is a shortage of phosphorous. The composition of the raw wastewater from TBAs (without processing of blood, feathers, and bones) is presented in the following table.
- Seite 265 und 266: Age of sludge (tTS) Is this of spec
- Seite 267 und 268: Example plants Teil 3 Seite 4-40 Co
- Seite 269 und 270: BSB5 - load Bd (BSB ) NH4 -N - load
- Seite 271 und 272: Fe Fl Fe Fl P D MB Teil 3 Seite 4-4
- Seite 273 und 274: Teil 3 Seite 4-46 Parameters Unit M
- Seite 275 und 276: Teil 3 Seite 4-48 To optimise the m
- Seite 277 und 278: Driving force for implementation Ex
- Seite 279 und 280: Teil 3 Seite 4-52 Table 4-15 Dimens
- Seite 281 und 282: Teil 3 Seite 4-54 liquid fertiliser
- Seite 283 und 284: - No cross media effects Teil 3 Sei
- Seite 285 und 286: Teil 3 Seite 4-58 3. Filtermaterial
- Seite 287 und 288: Decomposition level Measure- Teil 3
- Seite 289 und 290: Teil 3 Seite 6-2 FAT/ HEAT TRANSFER
- Seite 291 und 292: Teil 3 Seite 6-4 Clarification plan
- Seite 293 und 294: Teil 3 Seite 6-6 ENERGY FAT/ HEAT C
- Seite 295 und 296: Teil 3 Seite 6-8 ENERGY/ STEAM INPU
- Seite 297 und 298: Teil 3 Seite 6-10 water if necessar
- Seite 299 und 300: Teil 3 Seite 6-12 - In- vessel comp
- Seite 301 und 302: Teil 3 Seite 6-14 For 1000 kg of de
- Seite 303 und 304: Teil 3 Seite 6-16 Liming is usually
- Seite 305 und 306: Teil 3 Seite 6-18 ceous earth filte
- Seite 307 und 308: See description under 1 Limed bone
- Seite 309 und 310: H Concentration See description und
- Seite 311 und 312: Teil 3 Seite 6-24 The excess acid i
- Seite 313 und 314: Teil 3 Seite 7-1 7 CURRENT CONSUMPT
- Seite 315: 7.1.1 Rendering 7.1.1.1 Water Teil
- Seite 319 und 320: Teil 3 Seite 7-7 Table 7-5 shows th
- Seite 321 und 322: 7.1.2 Fat melting 7.1.3 Fish meal a
- Seite 323 und 324: Teil 3 Seite 8-1 8 TECHNIQUES TO CO
- Seite 325 und 326: Reference literature Teil 3 Seite 8
- Seite 327 und 328: Teil 3 Seite 8-5 Corporate clarific
- Seite 329 und 330: Economics Driving force for impleme
- Seite 331 und 332: 8.1.9 Rubishes Teil 3 Seite 8-9 8.1
- Seite 333 und 334: Oberding animal carcass disposal pl
- Seite 335 und 336: Operational data Applicability Econ
- Seite 337 und 338: Teil 3 Seite 8-15 Corporate clarifi
- Seite 339 und 340: Driving force for implementation Ex
- Seite 341 und 342: Continuous sterilisation Teil 3 Sei
- Seite 343 und 344: Teil 3 Seite 8-21 through a system
- Seite 345 und 346: Cross media effects Operational dat
- Seite 347 und 348: Teil 3 Seite 8-25 The energy requir
- Seite 349 und 350: Teil 3 Seite 8-27 For the wastewate
- Seite 351 und 352: Teil 3 Seite 8-29 Corporate clarifi
- Seite 353 und 354: Driving force for implementation Ex
- Seite 355 und 356: Teil 3 Seite 8-33 Table 8-3: Perfor
- Seite 357 und 358: Teil 3 Seite 8-35 one often tries t
- Seite 359 und 360: Teil 3 Seite 8-37 storage rooms and
- Seite 361 und 362: Teil 3 Seite 8-39 Rethmann TBA Gent
- Seite 363 und 364: Teil 3 Seite 9-1 9 BEST AVAILABLE T
- Seite 365 und 366: Teil 3 Seite 10-2 costs for the coo
Teil 3 Seite 7-4<br />
Parameter Unit Average value Range<br />
Acid capacity KS4,3<br />
l<br />
mmol/<br />
Hydrogen carbonate mmol/<br />
l<br />
Total water density (Ca, Mg) mmol/<br />
l<br />
53 54-85<br />
6,4 -<br />
0,05 0,03-0,1<br />
COD homogenised mg/l - 4000-18000<br />
BOD5 homogenised mg/l - 3600-16000<br />
Carbon acids C1 – C6 (as COD) mg/l 5900 3200-6600<br />
Ammonium-N mg/l 800 180-3000<br />
org.-N mg/l 105